TSB-15-01-010

SB-10058132-4656
GROUP
CAMPAIGN
Technical Service Bulletin
SUBJECT:
NUMBER
15-01-010
DATE
MODEL(S)
MARCH 2015
SONATA (YF)
SANTA FE SPORT (AN)
ECM UPDATE - DTC P0087 (SERVICE CAMPAIGN 935)
 IMPORTANT
*** Retail Vehicles Only ***
Dealers must perform this Service Campaign whenever an affected vehicle is in the shop for any
maintenance or repair.
When a vehicle arrives at the Service Department, access Hyundai Motor America's "Warranty
Vehicle Information" screen via WEBDCS to identify open Campaigns.
Description:
This bulletin provides information related an Engine Control Module (ECM) update for certain 20122013MY SONATA (YF) and 2013MY SANTA FE SPORT (AN) vehicles equipped with 2.0T or 2.4L
GDI engines to update the diagnostic logic for DTC P0087 (Fuel Rail/System Pressure - Too Low).
NOTICE
This ECM update revises the diagnostic logic for DTC P0087 that may occur with a normally
operating vehicle.
Further diagnosis may be required if the Malfunction Indicator Light (MIL) is illuminated for
DTC P0087 with the following conditions:
o extended crank while starting the engine
o hesitation and/or reduced power during acceleration
If DTC P0087 and/or any of the listed conditions exist after the ECM update, then proceed
with the diagnosis of the fuel system to perform the final repair as necessary.
Applicable Vehicles:
 Certain 2012-2013MY SONATA (YF) with 2.0T or 2.4L GDI engine
 Certain 2013MY SANTA FE SPORT (AN) with 2.0T or 2.4L GDI engine
GDS Information:
Event #
Description
“YFA 2.4GDI HIGH PRESSURE CONTROL LOGIC IMPROVE”
347*
“AN 2.4GDI HIGH PRESSURE CONTROL LOGIC IMPROVE”
348*
“YFA 2.0T-GDI HIGH PRESSURE CONTROL LOGIC IMPROVE”
350*
“AN 2.0T-GDI HIGH PRESSURE CONTROL LOGIC IMPROVE”
352*
(*or use a later available event as listed in the GDS ECU Update screen if one is available.)
Circulate To: Service Manager, Warranty Manager, Service Advisors, Technicians, Fleet Repair
SUBJECT:
ECM UPDATE - DTC P0087 (SERVICE CAMPAIGN 935)
Warranty Information:
Model
Op Code
SONATA YF 2.0TGDI/2.4GDI
50CA03R0
SANTA FE SPORT AN 2.0TGDI/2.4GDI
50CA03R1
Operation
Op Time
ECU UPGRADE
0.3 M/H
NOTE:
 Submit claim on Campaign Claim Entry Screen.
 Causal part not required for campaign.
NOTICE
You must initially perform GDS ECU Update in Auto Mode.
 If ECU update starts but then fails in Auto Mode, perform update in the Manual Mode to recover.
 Refer to the General Instructions found in TSB: 15-GI-001 (GDS Mobile) and 15-GI-002 (PC GDS).
TSB #: 15-01-010
Page 2 of 6
SUBJECT:
SUBJECT:
ECM UPDATE - DTC P0087 (SERVICE CAMPAIGN 935)
ROM ID Information Table:
Verify the ECU ROM ID before updating the software. Refer to the table below.
#347
Model
Trans
IMMOBILIZER
MY
ECM P/N
12MY(SULEV)
39111-2G677
OLD
NEW
ROM ID
ROM ID
YCS4RB3A
YCS4RB3B
YDS4RE1A
IMMO
13MY(SULEV)
39111-2G678
YDS4REAA
YDS4RF0A
YDS4RF3B
YDS4RF3A
6AT
12MY(SULEV)
39111-2G667
YCS4MB3A
YCS4MB3B
YDS4ME1A
NON IMMO
13MY(SULEV)
39111-2G668
YDS4MEAA
YDS4MF0A
YDS4MF3B
YDS4MF3A
12MY(ULEV)
IMMO
39111-2G672
YCC4RB3A
YCC4RB3B
YDC4RE1A
13MY(ULEV)
39111-2G673
YDC4REAA
YDC4RF3B
YDC4RF3A
6AT
12MY(ULEV)
YFA 2.4GDI
NON IMMO
39111-2G662
YCC4MB3A
YCC4MB3B
YDC4ME1A
13MY(ULEV)
39111-2G663
YDC4MEAA
YDC4MF3B
YDC4MF3A
12MY(ULEV)
39112-2G672
YCC4RB3A
YCC4RB3B
YDC4RF0A
IMMO
YDC4RE1A
13MY(ULEV)
39112-2G673
YDC4REAA
YDC4RF3B
YDC4RF0A
YDC4RF3A
6MT
12MY(ULEV)
39112-2G662
YCC4MB3A
YCC4MB3B
YDC4MF0A
NON IMMO
YDC4ME1A
13MY(ULEV)
39112-2G663
YDC4MEAA
YDC4MF3B
YDC4MF0A
YDC4MF3A
TSB #: 15-01-010
Page 3 of 6
SUBJECT:
SUBJECT:
ECM UPDATE - DTC P0087 (SERVICE CAMPAIGN 935)
#348
Model
Trans
Drivetrain
IMMO
MY
ECM P/N
OLD
NEW
ROM ID
ROM ID
BDC4RE5A
BDC4RG0B
BDC4RE5B
IMMO
39100-2GAE0
BDC4RE5C
BDC4RE5D
BDC4RG0A
2WD
BDC4ME5A
39100-2GAG0
IMMO
6AT
BDC4MG0B
BDC4ME5B
Non
AN 2.4GDI
BDC4RG0C
BDC4ME5C
BDC4ME5D
BDC4MG0C
BDCMRG0A
13MY(ULEV)
BDC4RE5A
BDC4RG0B
BDC4RE5B
IMMO
39100-2GAE5
BDC4RE5C
BDC4RE5D
BDC4RG0C
BDC4RG0A
4WD
BDC4ME5A
BDC4MG0B
BDC4ME5B
Non
39100-2GAG5
IMMO
BDC4ME5C
BDC4ME5D
BDC4MG0C
BDC4MG0A
#350
Model
Trans
IMMO
MY
ECM P/N
12MY(ULEV)
39111-2G691
OLD
NEW
ROM ID
ROM ID
YCC0RB3A
YCC0RC0B
YCC0RC0C
YDC0RE1A
YFA 2.0T-GDI
6AT
39111-2G691
IMMO
13MY(ULEV)
TSB #: 15-01-010
YDC0RE3A
YDC0RE5A
YDC0REAB
YDC0REAA
39111-2G692
YDC0RF3A
YDC0RF3B
39111-2G694
YDC0RG1A
YDC0RG1B
Page 4 of 6
SUBJECT:
SUBJECT:
ECM UPDATE - DTC P0087 (SERVICE CAMPAIGN 935)
#352
Model
Trans
Drivetrain
IMMO
MY
ECM P/N
OLD
NEW
ROM ID
ROM ID
BDC0RE3A
BDC0RE3B
BDC0RE5A
IMMO
39100-2GBB0
BDC0RE5B
BDC0RF2A
BDC0RG02
BDC0RF3A
BDC0RG0A
BDC0RG01
2WD
BDC0ME3A
BDC0ME3B
BDC0ME5A
Non-IMMO
39100-2GBD0
BDC0ME5B
BDC0MF2A
BDC0MG02
BDC0MF3A
BDC0MG0A
AN 2.0T-GDI
6AT
BDC0MG01
13MY(ULEV)
BDC0RE3A
BDC0RE3B
BDC0RE5A
IMMO
39100-2GBC0
BDC0RE5B
BDC0RF2A
BDC0RG02
BDC0RF3A
BDC0RG0A
BDC0RG01
4WD
BDC0ME3A
BDC0ME3B
BDC0ME5A
Non-IMMO
39100-2GBE0
BDC0ME5B
BDC0MF2A
BDC0MG02
BDC0MF3A
BDC0MG0A
BDC0MG01
TSB #: 15-01-010
Page 5 of 6
SUBJECT:
SUBJECT:
ECM UPDATE - DTC P0087 (SERVICE CAMPAIGN 935)
MANUAL MODE PASSWORD INFORMATION TABLE:
#347 MENU
PASSWORD
YFA 2.4GDI SULEV 6AT NON IMMO 39111-2G667
2667
YFA 2.4GDI SULEV 6AT NON IMMO 39111-2G668
2668
YFA 2.4GDI SULEV 6AT IMMO 39111-2G677
2677
YFA 2.4GDI SULEV 6AT IMMO 39111-2G678
2678
YFA 2.4GDI ULEV NON IMMO 39111/12-2G662
2662
YFA 2.4GDI ULEV NON IMMO 39111/12-2G663
2663
YFA 2.4GDI ULEV IMMO 39111/12-2G672
2672
YFA 2.4GDI ULEV IMMO 39111/12-2G673
2673
#348 MENU
PASSWORD
AN 2.4GDI 6AT NON IMMO 39100-2GAG0/G5[~ME5A]
0025
AN 2.4GDI 6AT NON IMMO 39100-2GAG0/G5[~ME5B,~ME5C,~ME5D,~MG0A]
0026
AN 2.4GDI 6AT IMMO 39100-2GAE0/E5[~RE5A]
0027
AN 2.4GDI 6AT IMMO 39100-2GAE0/E5[~RE5B,~RE5C,~RE5D,~RG0A]
0028
#350 MENU
PASSWORD
YFA 2.0T-GDI IMMO 39111-2G691[~RB3A,~RC0B]
2691
YFA 2.0T-GDI IMMO 39111-2G691[~RE1A,~RE3A,~RE5A,~REAA]
2692
YFA 2.0T-GDI IMMO 39111-2G692
2693
YFA 2.0T-GDI IMMO 39111-2G694
2694
#352 MENU
PASSWORD
AN 2.0T-GDI 6AT NON IMMO 39100-2GBD0/BE0
0020
AN 2.0T-GDI 6AT IMMO 39100-2GBB0/BC0
0021
NOTE: IMMO is for Start-Stop Button Start. NON IMMO is for Key Start.
TSB #: 15-01-010
Page 6 of 6
SUBJECT: