L-SB-0012-14

L-SB-0012-14
February 13, 2014
Floor Mat Installation During PDS
Service
Category
General
Section
Pre-Delivery Service
Market
USA
Lexus Supports ~
ASE Certification-
Applicability
YEAR(S)
2015
MODEL(S)
ADDITIONAL INFORMATION
CT200H , ES300H ,
ES350, GS350,
GS450H , GX460,
IS250 , IS250C , 18350,
IS350C , LS460,
LS600H , LX570,
RX350 , RX450H
Introduction
2015 model year vehicles are equipped with driver's side floor mat retaining clips to secure the floor
mat in the correct position . In addition , some models may utilize retaining clips for passenger side
and rear seat floor mats as well. Follow the appropriate installation procedure to attach the driver's
side, and if applicable, passenger's side and rear seat floor mats to the vehicle carpet using the floor
mat retaining clips during Pre-Delivery Service (PDS) .
CAUTION
• ALWAYS verify the floor mat to ensure it is designed specifically for the model and model
year it is being installed in.
• ONLY use floor mats that can be retained using the retaining clips. All OEM Lexus floor mats
are specifically designed to fit correctly and be retained using the retaining clips.
• Make sure the floor mat is properly placed on the vehicle carpet and secured with the retaining
clips. If the driver side floor mat is NOT properly placed and secured, it could slip and interfere
with the movement of the pedals during driving and may cause an accident.
• Verify the operation of the accelerator, brake, and clutch (if equipped) pedals and clearance
to the mat.
• NEVER install more than one floor mat at a time in the driver's seating position.
• If applicable, any secondary set of floor mats (based upon customer preference, such as the
all-weather floor mats or other floor mats) MUST be placed in the trunk with all the packaging
material intact. Do NOT install the secondary mat on top of the primary floor mat already
installed in the driver's seating position.
© 2014 Lexus, a division of Toyota Motor Sales, USA
Page 1 of 5
L-SB-0012-14
February 13, 2014
Page 2 of 5
Floor Mat Installation During PDS
Warranty Information
OP CODE
DESCRIPTION
TIME
OFP
T1
T2
N/A
Not applicable to Warranty
N/A
N/A
-
-
Installation Procedure (Hook Style)
1. Verify that the driver, and if applicable, passenger side and rear seat floor mats are for the
correct model and model year they are being installed in .
2. Attach the driver and if applicable , passenger side and rear seat floor mats to the vehicle
carpet using the retaining clips. Secure the mat by inserting the retaining clips through the
grommet holes.
Figure 1.
1
2
I
Rotaioiog Clip•
3
I
Correct Installation
Grommets
© 2014 Lexus, a division of Toyota Motor Sales, USA
Page 3 of 5
February 13, 2014
L-SB-0012-14
Floor Mat Installation During PDS
Installation Procedure (Hook Style) (Continued)
3. Verify proper installation .
NOTE
If applicable, DO NOT remove the beige "Caution" tag from the floor mat. This should only be
removed by the customer.
Fig ure 2.
A
Caut ion I Preeauci6o I Attf>ntio.n I .>i:tW
A
NOTICE: THIS TAG TO BE REMOVED BY, cusroMER ONLY.
To avold ·interfettHlce Witii· pedal oper.aJ.iOl'I:·
• E.acl'I m~t .mu:st ~ &ecured with :tstention l'!ooks (.clips}
• Do ~t in$1all a floor ~! on top or an axis.ting flC)O( inal
AVISO: SOLAMENTE El CllENTE DEBE REMOVER ESTA ETIQUETA.
0
:Para..ev1iar lnterfereflcla wn la opera.c!On del pedBI:
· • C;IJ~ fllpete debe 11ujetafS:e
se,glli-0$ de.retencl6n.(broches}.
• Nolnstale un !apete de piso eri~ ~ un tapete de p lso ~ mten e
coo
REMA~QUE : CETTE i:TIQUmE NE PEUT l:TRE ENLE~E QUE PAR LE CL IENT.
Pol.B" e.viter"des in'ter19rencas llVBC le ioncliOOnemenl de la peqale:
·• chaqu~: ta.pis doll.lilt& fix~ ~ !'aide des~$1:$ de ratentiOtl{agtat~)
• N'i.rlslallez pag· un tai)is paMl&ssus un tapos dBj;\ en plate
..1:.:ii W...J'
·
~
o-- .u~,
.~.
e...>l
El
~ : ...Ju...,.;:-.}
. ~1 ~sfe.Jl1.A;t 1~111'u .~ .· :·~-1&-..»1 ~~
J
y
.~ -.,.6,>- ._;..;; (1.~ .i ..>4'-JI ~A)°..,A_y 'i--
© 201 4 Lexus, a division of Toyota Motor Sales, USA
~'
L-SB-0012-14
February 13, 2014
Page 4 of 5
Floor Mat Installation During PDS
Installation Procedure (Knob Style)
1. Verify that the driver, and if applicable, passenger side and rear seat floor mats are for the
correct model and model year they are being installed in .
2. Align the floor mat holes with the retention clip
knobs and place the floor mat holes onto the
retention clip knobs .
Figure 3.
0
1
Retention Clip Eyelet on Floor Mat
2
Retention Clip
3
Front of Vehicle
3. Turn the retention clip knobs a quarter of a turn to Figure 4.
lock in place and verify the "triangle" marks on the . - - - - - - - - - - - - - - - - - - - - - - - .
retention clip knob and floor mat are aligned .
1
Twist Knob
2
Knob in Locked Position
3
Align " Triangle " Marks
© 2014 Lexus, a division of Toyota Motor Sales , USA
L-SB-0012-14
Page 5 of 5
February 13, 2014
Floor Mat Installation During PDS
Installation Procedure (Knob Style) (Continued)
4 . Verify proper installation.
Figure 5.
A
NOTE
If applicable, DO NOT remove the yellow
"Caution" tag from the floor mat. This should
only be removed by the customer.
CAUTION
A
Use this floor mat for driver's
side only.
This noor mat was designed
specifically for use in this model
and model year vehicle and
SHOULD NOT be used In any
olher vehlde.
• To prevent the floor mat from
shifting. the floor mat should be
attached securely to the floor
with the retention d ips.
• To properly use the retention
clips, tum the knobs on the clips
to the lock position as shown in
the following iUustration.
• The floor mat MUST BE
installed directly on the carpeted
floor of the vehicle and property
secured with the retention clips.
The floor mat should NEVER
be Installed on top of another
ftoormal
• NEVER place the floor mat
in the vehicle upsid&-down or
bacl y allo de vehlrulo,
y NO DEBE usarse en ningUn
otro vehirulo.
• Para evilar que el tapete se
mueva, el tapete debe celllrse al
piso de manera segura con las
sujetadores de retencl6n.
• Para usar correctamenta los
sujetadoras de retenci6n, gire
las perillas an los sujetadores
a la posicl6n de bloqueo como
se muestra an la &iguiente
iluslraci6n.
• El tapete DEBE instalarse
dlrectamente al plso
alfombrado del vehlculo y
cenlrse oorrectamanta con las
sujeladores de retenci6n. El
tapeta NUNCA debe instalatse
encima de otro tapete.
• NUNCA ooloque el tapete en el
vehlculo boca abajo o al
raves.
AL-Vll ALJ0N MARK
SIEllPRE AUNEE LAS llAllCAS
TOWOURS AUGNEll LES llARQUU
~
.....~l.lu,.i
~
UNLOCK
D£S8LOQUEAA
otvERAoulUER
e'i'
TnlT - ICOOOI
© 2014 Lexus, a division of Toyota Motor Sales, USA