T-58-0161-13A
Service Bulletin Details
Public Details for: T-58-0161-13A
Some 2010 model year tacoma vehicles equipped with the 2tr-fe engine may exhibit a front exhaust pipe catalyst rattle noise and/or mil "on" condition with otc P0420 (catalyst system efficiency below threshold) stored in the engine contro
- 2010 -
Models from 2010
2010 TOYOTA TACOMA |
@TOYOTA Technical Service Bulletin October 31, 2013 T-58-0161-13 Front Exhaust Pipe Catalyst Rattle Noise and/or MIL "ON" OTC P0420 Service Category Engine/Hybrid System Section Intake/Exhaust Toyota Supports ~ ASE Certification V USA Market Applicability YEAR(S) MODEL(S) 2010 Tacoma ADDITIONAL INFORMATION VDS(s) : NX4CN, NX4GN , PX4EN , TX4CN , TX4GN , UX4EN Introduction Some 2010 model year Tacoma vehicles equipped with the 2TR-FE engine may exhibit a front exhaust pipe catalyst rattle noise and/or MIL "ON" condition with OTC P0420 (Catalyst System Efficiency Below Threshold) stored in the Engine Control Module (ECM) (SAE Term: Powertrain Control Module/PCM). Refer to the repair procedure to address this condition . Warranty Information OP CODE DESCRIPTION TIME OFP T1 T2 170171 R & R Front Exhaust Pipe Assembly 0.7 17410-0C100 06 14 APPLICABLE WARRANTY • This repair is covered under the Toyota Federal Emission Warranty. This warranty is in effect for 96 months or 80,000 miles, whichever occurs first, from the vehicle's in-service date. • Warranty application is limited to occurrence of the specified condition described in this bulletin. Parts Information PART NUMBER PART NAME QTY 1741 O-OC100 Pipe Assembly, Exhaust, Front 1 17451-00020 90080-43033 © 2013 Toyota Motor Sales, USA Gasket 1 1 Page 1 of 3 @TOYOTA Page 2 of 3 October 31, 2013 T-SB-0161-13 Front Exhaust Pipe Catalyst Rattle Noise and/or MIL "ON" OTC P0420 Required Tools & Equipment REQUIRED EQUIPMENT SUPPLIER Techstream 2.0* TIS Techstream PART NUMBER QTY TS2UNIT ADE Techstream Lite TSPKG1 TSLITEDLR01 * Essential SST. NOTE • Only ONE of the Techstream units listed above is required. • Software version 8.30.023 or later is required. • Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at 1-800-368-6787. Repair Procedure 1. Test drive and verify that an abnormal rattle noise is heard while accelerating. 2. Raise the vehicle on a hoist with the engine running. © 2013 Toyota Motor Sales, USA @TOYOTA T-SB-0161-13 October 31, 2013 Page 3 of 3 Front Exhaust Pipe Catalyst Rattle Noise and/or MIL "ON" OTC P0420 Repair Procedure (Continued) 3. Increase the engine speed and listen to the catalytic converter section on the front exhaust pipe assembly for a rattle noise. CAUTION Avoid contacting any part of the exhaust system - it is VERY HOT. Figure 1. 2TR-FE Front Exhaust Pipe Components ~ x2 1 Catalytic Converter 2 2WD Oxygen Sensor 3 4WD Oxygen Sensor 4. Did the noise appear to be the loudest at the catalytic converter section of the front exhaust pipe assembly? • YES - Continue to step 5. • NO - This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual. 5. Replace the front exhaust pipe assembly. Refer to the Technical Information System (TIS), applicable model and model year Repair Manual: • 2010 Tacoma: Engine/Hybrid Systems - Intake/Exhaust - "2TR-FE Exhaust: Exhaust Pipe: Removal I Installation" 6. Test drive vehicle to confirm repair. © 2013 Toyota Motor Sales, USA