V011605_2043736
Service Bulletin Details
Public Details for: V011605_2043736
Remove cjaa engine applicability. Cjaa equipped jetta's not equipped with active radiator grille.
Models from 2015
2015 VOLKSWAGEN JETTA |
Models from 2014
2014 VOLKSWAGEN JETTA |
Technical Bulletin Model(s) Year Eng.Code Trans. Code VIN Range From VIN Range To All All All 1.8T (CPKA, CPRA) Jetta 2015-2016 2.0L TDI (CVCA) Condition 01 16 05 April 25, 2016 2043736 Supersedes Technical Bulletin V011604 dated April 8, 2016 to remove CJAA engine code applicability. MIL ON, DTC P05A3 and/or P05A0 Active Radiator Shutter Grille faults stored in ECM Fault Memory Customer states the MIL light is on, OTC P05A3 and/or P05A0 in the ECM. DTC Description P05A3 Active Grille Air Shutter "A" Control Circuit Range/Performance P05A0 Active Grille Air Shutter "A" Stuck On Technical Background Fault code being stored in the ECM due to the incorrect software within the motor of the Active Radiator Grille. Production Solution Updated Active Radiator Grille part number 95B 965 501 H. Page 1 of 4 © 2016 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Service Inspect the Active Radiator Grille motor part number (located on the motor itself, see Figure 1) and perform one of the two following steps. I Note: To access the grill motor information, remove the noise insulation (lower engine shield) from beneath the car and the motor will be located in the center of the lower air intake of the bumper. • If part number is less than 95B 965 501 H, similar to the picture below, the motor/grille will need to be replaced. • If part number is 95B 965 501 H or higher, the motor/grille is OK and normal Guided Fault Finding diagnosis must be performed. This technical bulletin does not apply. Figure 1 If the Active Radiator Grille needs to be replaced, follow the steps outlined in ELSA to replace the Active Radiator Grille. Page 2 of 4 © 2016 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Warranty To determine if this procedure is covered under Warranty, always refer to the Warranty Policies and Procedures Manual 1> Model(s) Year(s) Eng. Code(s) Trans. Code(s) VIN Range From VIN Range To All All All 1.8T (CPKA, CPRA) Jetta 2015-2016 2.0 TDI (CJAA, CVCA) SAGA Coding Claim Type: Use applicable Claim Type 1> HST Damage Location (Depends on Service No.) -- Use applicable when indicated in Elsa (L/R) Damage Service Number: Code 1932 0040 Parts Manufacturer 3ME Jetta Labor Operation 3> : Charge Battery 27068950 = 10 TU Labor Operation 3> : Remove and Install Noise Insulation (Lower engine shield) Gasoline: 10821900 = 30 TU Labor Operation 3> : Remove and Install Front bumper 63291900 = 60 TU Labor Operation 3> : Remove and Install Radiator Shutter 19321950 = 10 TU Causal Part: 5C6122321 Diesel: 10821903 = 40 TU Diagnostic Time GFF Time expenditure 2> 01500000 = 20 TU max. 4> YES Page 3 of 4 © 2016 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin 01210002 = 00 TU Road Test YES 01210004 = 10 TU 01320000 = 00 TU max. Technical Diagnosis NO Claim Comment: Input "As per Technical Bulletin 2043736" in comment section of Warranty Claim. 1> Vehicle may be outside any Warranty in which case this Technical Bulletin is informational only 2 > Code 3 > Labor 4 > Documentation per warranty vendor code policy. Time Units (TUs) are subject to change with ELSA updates. required per Warranty Policies and Procedures Manual. Required Parts and Tools Part Description Part Number Active Radiator Grille 95B965501H Tool Description Tool No: Midtronics Battery Tester/Charger lnCharge 940 (INC-940) or GRX3000VAS VAS Diagnostic Tool VAS 6150/X & VAS 6160/X with: ODIS Service with current online updates Trim Removal Wedge 3409 Pry Lever 80-200 Additional Information All part and service references provided in this Technical Bulletin are subject to change and/or removal. Always check with your Parts Dept. and Repair Manuals for the latest information. Page 4 of 4 © 2016 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.