T-SB-0086-14 Rev
Service Bulletin Details
Public Details for: T-SB-0086-14 Rev
Tsb: some 2014 - 2015 model year corolla vehicles may exhibit a condition where the a/c system blows warm air intermittently while the vehicle is at idle. An updated a/c compressor is available to address this condition.
Models from 2015
2015 TOYOTA COROLLA |
Models from 2014
2014 TOYOTA COROLLA |
T-SB-0086-14 Rev1 August 11, 2014 Intermittent Poor A/C Cooling at Idle Service Category Vehicle Interior Section Heating/Air Conditioning Market USA Applicability YEAR(S) MODEL(S) 2014 – 2015 Corolla ADDITIONAL INFORMATION REVISION NOTICE October 16, 2014 Rev1: • Applicability has been updated to include 2015 model year Corolla vehicles. • The Parts Information, Warranty Information, and Repair Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Introduction Some 2014 – 2015 model year Corolla vehicles may exhibit a condition where the A/C system blows warm air intermittently while the vehicle is at idle. An updated A/C compressor is available to address this condition. Production Change Information This bulletin applies to vehicles produced BEFORE the Production Change Effective VINs shown below. MODEL PLANT TMMC Corolla TMMMS TMMC TMMMS ENGINE PRODUCTION CHANGE EFFECTIVE VIN 2ZR-FE 2ZR-FAE © 2014 Toyota Motor Sales, USA 2T1BURHE#EC217552 5YFBURHE#EP171965 2T1BPRHE#EC223722 5YFBURHE#FP178442 Page 1 of 4 Rev1 T-SB-0086-14 August 11, 2014 Page 2 of 4 Intermittent Poor A/C Cooling at Idle Parts Information PART NUMBER PART NAME QTY 88310-02851 Compressor, Assembly 1 88320-0Z070 Compressor Assy, Cooler 1 PREVIOUS NEW 88310-02850 88320-0Z060 Warranty Information OP CODE DESCRIPTION TIME OFP T1 T2 AC1400 Compressor w/ Magnetic Clutch Assembly 1.8 88310-02850 88320-0Z060 72 50 APPLICABLE WARRANTY • This repair is covered under the Toyota Basic Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle’s in-service date. • Warranty application is limited to occurrence of the specified condition described in this bulletin. Required Tools & Equipment REQUIRED EQUIPMENT Techstream 2.0* Techstream Lite SUPPLIER ADE PART NUMBER QTY TS2UNIT TSLITEPDLR01 1 * Essential SST. NOTE • Only ONE of the Techstream units listed above is required. • Software version 9.20.022 or later is required. • Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at 1-800-368-6787. Repair Procedure 1. Connect Techstream and navigate to the A/C System Data List. 2. With the vehicle at idle, cycle the A/C button and watch the Regulator Control Current, Regulator Pressure Sensor, and Evaporator Fin Thermistor Data List graphs. © 2014 Toyota Motor Sales, USA T-SB-0086-14 Rev1 August 11, 2014 Page 3 of 4 Intermittent Poor A/C Cooling at Idle Repair Procedure (Continued) 3. When the condition is occurring the following data will be seen: • Regulator Control Current: “0.7” “A” or higher • Regulator Pressure Sensor: Low pressure and not increasing • Evaporator Fin Thermistor: Higher than normal and increasing Figure 1. 1 1 Normal 2 2 Condition Ocurring Can the concern be duplicated? • YES — Continue to step 4. • NO — This bulletin does NOT apply. Continue diagnosis using Problem Symptoms table in the applicable Repair Manual. © 2014 Toyota Motor Sales, USA T-SB-0086-14 Rev1 August 11, 2014 Page 4 of 4 Intermittent Poor A/C Cooling at Idle Repair Procedure (Continued) 4. Remove and replace the A/C compressor. Refer to the Technical Information System (TIS), applicable model and model year Repair Manual: • 2014 Corolla (2ZR-FE): Vehicle Interior – Heating/Air Conditioning – “Compressor (for 2ZR-FE): Removal / Installation” • 2014 Corolla (2ZR-FAE): Vehicle Interior – Heating/Air Conditioning – “Compressor (for 2ZR-FAE): Removal / Installation” • 2015 Corolla (2ZR-FAE): Vehicle Interior – Heating/Air Conditioning – “Compressor (for 2ZR-FAE): Removal / Installation” 5. Verify that the intermittent warm air condition is no longer present. © 2014 Toyota Motor Sales, USA