SET-TSB-16-002
Service Bulletin Details
Public Details for: SET-TSB-16-002
Southeast toyota accessory fog lights may drain battery due to parasitic draw. Revised harness available.
Models from 2014
2014 TOYOTA TACOMA |
Models from 2013
2013 TOYOTA TACOMA |
Models from 2012
2012 TOYOTA TACOMA |
ATTENTION: This Technical Service Bulletin was issued by Southeast Toyota Distributors, LLC. For Toyota Dealers located within the Southeast Region: Please refer to SET Dealer Daily to obtain instructions on how to order parts and submit a warranty claim (If applicable). For Lexus Dealers or Toyota Dealers NOT located in Florida, Georgia, Alabama, South Carolina or North Carolina: For Repair Authorization, Parts Ordering, and Warranty Claims please contact Southeast Toyota Distributors Warranty Claims Department: (888)851-2722 Press 5, then Press 4 for Out of Region SET Repairs [email protected] Thank you for your continued support. 2/22/2015 SET - TSB-16-002 Category: Vehicle Exterior Section: Lighting (ext) 2012-14 Tacoma Parasitic Draw SET Accessory Fog Lights Applicability YEAR(S) MODEL(S) 2012-14 Tacoma INSTALLED ACCESSORY INFORMATION DESCRIPTION ACCESSORY CODE KIT PART NUMBER Fog Lights LF10 00016-35220 **This Publication does not apply to Vehicles Originally Equipped with a Fog Lamps from the factory or Systems added by other manufacturers. Introduction Some 2012-2014 Tacoma vehicles equipped with SET accessory fog lights may exhibit a customer concern of no crank or crank no start due to low battery voltage after long term vehicle storage. This condition can be caused by a parasitic draw from the SET accessory fog lights. The following modifications to the SET accessory fog lamps to will reduce battery parasitic drain, improving long term vehicle storage battery life. Warranty Information For Dealers located in the Southeast Region, Florida, Georgia, Alabama, South Carolina, or North Carolina, Submit Warranty claim utilizing the information below. OP CODE DESCRIPTION TIME OFP T1 T2 Fog Light Wire Harness ALF051 1.0 00016-32260-01 99 99 Replacement Port Installed Option (PIO) ‐ is in effect for 36 months or 36,000 miles from the vehicle’s in‐service date, whichever occurs first. Unless otherwise specified in vehicle VIN inquiry. Dealer Installed Option (DIO) ‐ is in effect for 12 months, regardless of mileage, from the date the part(s) was installed on the vehicle or the remainder of any applicable New Vehicle Limited Warranty, whichever provides greater coverage. Over the Counter Sale (OCS) ‐ is in effect for 12 months, regardless of mileage, from the date the part(s) were sold. Labor is not warranted for over‐the counter service part replacements. If you are a dealer located outside of the Southeast Region, please contact the SET Accessory Warranty Department at (888) 851-2722 or email [email protected] for claim payment instructions. Parts Information PART NUMBER 00016-35220-01 DISCRIPTION Fog Light Wire Harness If you are a dealer outside of the SET region, please contact the SET accessory department at (888) 8512722 or email [email protected]. 1 February 22, 2016 2 Tacoma Fog Light Parasitic Draw Inspection 1. Perform a TIS VIN inquiry to verify Vehicle has SET Accessory fog lights installed. Port Installed Accessories are identified with “LF 10: Fog Lights” in the Vehicle Info Tab Dealer installed Accessories are identified with the kit part number (00016-35220) appears in service history. This TSB does not apply if vehicle does not have SET accessory fog lights. 2. Inspect accessory wiring. The Fog Light Positive (Red) wire is connected to the Positive Battery Terminal. In this configuration the Accessory Fog light relays tied to the harness behind the driver’s kick panel will have 12 volts available at all times. Proceed to Repair Section in this TSB. The Fog Light Positive (Red) wire is connected to a White-Green near instrument panel junction block connector 1A pin 5 In this configuration the Accessory Fog light relays tied to the harness behind the driver’s kick panel will have 12 volts only when Ignition “ON”. This TSB DOES NOT apply. Refer to Service Manual for further diagnostic info. Southeast Toyota Distributors, LLC February 22, 2016 3 Tacoma Fog Light Parasitic Draw Repair 1. Replace Accessory Wire Harness Reference 00016-35220 SET Accessory Installation instructions on TIS for replacement of 00016-35220-01 Wire harness. Instructions were updated to reflect changes of system on 11/4/2013 2. Verify Parasitic Amp draw measurement. If parasitic draw exceeds specification, refer to TIS for further diagnostics. Southeast Toyota Distributors, LLC