A011650 2026299-
Service Bulletin Details
Public Details for: A011650 2026299-
Models from 2012
| 2012 AUDI S4 |
| 2012 AUDI S5 |
Models from 2011
| 2011 AUDI A6 |
| 2011 AUDI S4 |
| 2011 AUDI S5 |
Models from 2010
| 2010 AUDI A6 |
| 2010 AUDI S4 |
| 2010 AUDI S5 |
Technical Service Bulletin 01 MIL on, DTC for air-fuel ratio imbalance stored in ECM 01 16 50 2026299/5 January 11, 2016. Supersedes Technical Service Bulletin Group 01 number 14-00 dated October 17, 2014 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment S4, S5 2010 - 2012 All 3.0 TFSI A6 2010 - 2011 All 3.0 TFSI Condition REVISION HISTORY Revision Date Purpose 5 - Revised Service (Added information about crankcase pressure regulating valve) Revised Warranty (Added time for replacement of crankcase pressure regulating valve) Revised Required Parts and Tools (Added entire section) 4 10/17/2014 Revised header data (Corrected Elsa display issue; added DTCs) 3 8/28/2012 Revised Service (Updated SVM table) • MIL on. • One of the following DTCs for air-fuel ratio imbalance is stored in the engine control module (ECM), J623 (address word 01): • DTC P219C00 (stored in cylinder 1) • DTC P219D00 (stored in cylinder 2) • DTC P219E00 (stored in cylinder 3) • DTC P219F00 (stored in cylinder 4) • DTC P21A000 (stored in cylinder 5) • DTC P21A100 (stored in cylinder 6) Technical Background An incorrect software setting causes the DTC to be stored. © 2016 Audi of America, Inc. Page 1 of 4 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Production Solution Not applicable. Service Check the repair history of the vehicle before proceeding: • If crankcase pressure regulating valve 06E103547H (or any newer suffix) has already been installed, no part update is necessary. Proceed to SVM Update Instructions. • If crankcase pressure regulating valve 06E103547H (or any newer suffix) has not been installed, install the latest part number before proceeding to SVM Update Instructions. SVM Update Instructions 1. Follow all instructions in TSB 2011732: 00 Software Version Management (SVM), operating instructions. 2. Update the ECM (J623) using the SVM action code as listed in the table below if necessary. Model S4, S5 (MY 2010) S4, S5 (MY 2011-2012) A6 (or higher) 8K0907551D 0003 01A092 ≤ 0002 8K0907551D 0003 01A092 ≤ 0030 4F1910551D 0050 01A092 Old Software Version New Software Part Number 3.0TFSI 8K0907551A ≤ 0002 3.0TFSI 8K0907551B 3.0TFSI 4F1910551A © 2016 Audi of America, Inc. New Software Version SVM Code Input Old Software Part Number Engine Page 2 of 4 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Warranty Claim Type: Use applicable claim type. If vehicle is outside any warranty, this Technical Service Bulletin is informational only. Service Number: 2470 Damage Code: 0039 Labor Operations: For software update: Check software levels, no update necessary 2470 0199 20 TU Check software levels, perform update 2470 2599 60 TU For crankcase pressure regulating valve installation, if necessary: S4, S5: Crankcase breather remove+reinstall 1050 1991 130 TU 2 Fuel distributor rail remove+reinstall 2441 2091 90 TU Compressor remove+reinstall 2114 1941 190 TU Fuel system pressure decrease 2003 0091 10 TU 1050 1941 370 TU A6: Crankcase breather remove+reinstall Diagnostic Time: GFF – Checking and clearing fault codes including in existing No allowance 0 TU labor operations Road test prior to service procedure 0121 0002 10 TU Road test after service procedure 0121 0004 10 TU Technical diagnosis at dealer’s discretion (Refer to Section 2.2.1.2 and Audi Warranty Online for DADP allowance details) Claim Comment: As per TSB #2026299/5 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. © 2016 Audi of America, Inc. Page 3 of 4 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Required Parts and Tools Part Number Part Description Quantity 06E103547Q Crankcase pressure regulating valve 1 Additional Information The following Technical Service Bulletin will be necessary to complete this procedure: • TSB 2011732 00 Software Version Management (SVM), operating instructions. All parts and service references provided in this TSB (2026299) are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information. © 2016 Audi of America, Inc. Page 4 of 4 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.