V691301 2029767

Technical Bulletin
Model(s)
Year
Eng. Code
Trans. Code
VIN Range From VIN Range To
Golf,GTI, Jetta
SportWagen
2010 - 2013
All
All
All
All
Jetta Sedan
2011 - 2013
All
All
All
All
Passat
2012 – 2013
All
All
All
All
Condition
69 13 01 February 11, 2013 2029767 Supersedes T.B. V691202 dated October 2, 2012 to include additional
model.
Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag Control Module
Technical Background
Airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp.
Note:
Symptom as described will not affect airbag functionality.
Production Solution
Information only.
Service
Procedure
• Verify airbag indicator lamp in instrument cluster is ON.
• Using GFF, scan vehicle for DTCs.
• Verify DTC B101614 is stored in airbag module.
Fault Code
B101614
Description
Front passenger airbag disabled indicator lamp
interruption/short - circuit to ground
Note:
If any other faults are present in airbag module, further diagnosis is required.
Page 1 of 4
© 2013 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Technical Bulletin
• If DTC is present, clear fault memory and recheck for code.
• If fault clears, and the airbag indicator in the instrument cluster does not illuminate, no repairs necessary.
• If DTC reoccurs, remove center console cover using wedge tool 3409, inspect wiring connections to
“PASSENGER AIR BAG WARNING LAMP” (see figures 3 and 4), for loose connection.
• Secure wiring connections as necessary.
• If connection is secure, further diagnosis is needed. This technical bulletin does not apply.
• Clear DTCs again and retest operation to verify airbag lamp is OFF in instrument cluster.
Figure 1
No - Climatronic
Figure 3
Figure 2
Climatronic
Figure 4
Page 2 of 4
© 2013 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Technical Bulletin
Warranty
To determine if this procedure is covered under Warranty, always refer to the Warranty Policies and
1)
Procedures Manual
Model(s)
Year(s)
Eng. Code(s)
Trans. Code(s)
VIN Range From
VIN Range To
Golf, GTI, Jetta
SportWagen
2010 - 2013
All
All
All
All
Jetta Sedan
2011 - 2013
All
All
All
All
Passat
2012 – 2013
All
All
All
All
SAGA Coding
Claim Type:
Use applicable Claim Type
Service
Number:
Damage
6982
0015
Code
Parts
Manufacturer
1)
HST
Damage Location (Depends on
Service No.)
--
Use applicable when indicated
in ElsaWeb (L/R)
2)
Golf, GTI
WWO
Jetta Sedan, Jetta SportWagen
3ME
2)
Passat
Tx6
2)
3) :
Labor Operation Remove and Install Center
console trim, reconnect passenger airbag
warning lamp harness connector.
69824199 = 20 TU (loose connection found)
Causal Part: Select labor operation
69824199
Diagnostic Time
GFF Time expenditure
01500000 = 20 TU max.
Road Test
01210002
YES
NO
01210004
Technical Diagnosis
4)
0132xxxx = 00 TU max.
NO
Claim Comment: Input “As per Technical Bulletin 2029767” in comment section of Warranty Claim.
Page 3 of 4
© 2013 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Technical Bulletin
1)
Vehicle may be outside any Warranty in which case this Technical Bulletin is informational only
2)
Code per warranty vendor code policy.
3)
Labor Time Units (TUs) are subject to change with ELSA updates.
4)
Documentation required per Warranty Policy Procedures Manual.
Required Parts and Tools
No special parts required.
Tool Description
Tool No:
Wedge Tool
3409
Midtronics Battery Tester/Charger
InCharge 940 (INC-940)
VAS Diagnostic Tool
VAS-PC, 5051B, 5052A, 6150X
(Base CD V19.01.00 and Brand DVD V19.19.00 or
higher)
Additional Information
All part and service references provided in this Technical Bulletin are subject to change and/or removal.
Always check with your Parts Dept. and Repair Manuals for the latest information.
Page 4 of 4
© 2013 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.