Scheduled Mainte
Service Bulletin Details
Public Details for: Scheduled Mainte
Additional maintenance section: added: (1.4l jetta only) to "coolant pump toothed belt: check at 150,000 miles, then every 20,000 miles" and "timing belt: check at 150,000 miles, then every 20,000 miles"
- 2018 -
Models from 2018
2018 VW Maintenance Schedule - All Models except e-Golf
MY 2018 Maintenance Intervals - USA
The intervals shown in this table are based on vehicles operating under normal conditions. In case of severe conditions, such as
extremely low temperatures, excessive dust, etc., it is necessary for certain operations to be carried out in between the given intervals. This
applies particularly to engine oil changes and the cleaning or replacing of the air cleaner filter element.
Service intervals in miles
10K
Minor Maintenance 1)
Standard Maintenance 2)
Extended Maintenance
Additional Maintenance Items
20K
X
30K
40K
X
X
50K
60K
X
X
80K
X
X
X
70K
90K
100K
X
X
110K
120K
X
X
X
X
X
Refer to the Additional Maintenance Items Table below
1) First minor maintenance service at 10,000 miles or 1 year after delivery, whichever occurs first. Minor maintenance
services thereafter occur at intervals of 20,000 miles or every 2 years after the last minor maintenance service, whichever
occurs first.
2) First standard maintenance service at 20,000 miles or 2 years after delivery, whichever occurs first. Standard maintenance services thereafter occur at intervals of 20,000 miles or every 2 years after the last standard maintenance service,
whichever occurs first.
Minor Maintenance
Brake pads (front and rear): Check thickness and brake disc condition. Look for contact pattern and corrosion of brake discs
Engine: Change oil and replace filter
Service interval display: Reset
Sunroof water drains: Check for clearance and clean if necessary (Passat only)
Standard Maintenance (Includes All Minor Maintenance Items)
Battery: Check with battery tester (and second battery if applicable)
Brake fluid: Check level
Brake pads: Check thickness and brake disc condition. Look for contact pattern and corrosion of brake discs (front and rear)
Cooling system: Check level and frost protection
Engine: Change oil and replace filter
Engine and engine compartment components (from above): Check for leaks and damage
Engine and engine compartment components (from below): Check related components including transmission, final drive, and drive
axle boots for leaks and damage
Exterior Lighting: Check function of front and rear lights, headlights (adjust if necessary), automatic headlights (if applicable), turn
signals, cornering lights, and hazard warning lights
Headlight washing system: Check function (if equipped)
Horn: Check function
Removable trailer hitch: Check function and inspect for damage (Tiguan, Tiguan Limited, and Atlas only if equipped)
Service interval display: Reset
Sunroof water drains: Check for clearance and clean if necessary (Passat only)
Test drive: Check braking, kickdown, steering, electrical, heating/ventilation systems, air conditioning, handling, and parking brake
Tire pressure monitoring system: Calibrate to correct tire pressure settings
Tire pressure: Check LF________ RF________ LR ________ RR ________ Spare ________
Tire repair kit: Check for damage and prior use
Tires: Check condition and wear pattern. Record tread depth
Windshield wiper/washer system: Check function and adjust spray nozzle if necessary, fluid level, and freeze protection
1
Revised 11/10/2017
Standard Maintenance (continued)
Wiper blades: Bring into service position, check for damage, and check park position
Extended Maintenance
Body interior and exterior: Check for corrosion
Brake system: Check for leaks and damage
Coil Springs and Shock Absorbers (front and rear): Check for damage
Convertible top: Clean and lubricate locking element. Perform leak test (Beetle Convertible only)
Exhaust system: Check for leaks and damage
Hood latch: Lubricate (Does not apply to: Passat, Golf, Beetle, and Jetta)
Interior lighting: Check function of glove box lights, cigarette lighter/power outlets, luggage compartment, and all warning lights
Ribbed belt: Check condition
Sunroof, Panoramic Sliding (if applicable): Check function
Sunroof, Non-Panoramic Sliding (if applicable): Check function and clean, then lubricate guide rails with special lubricant
Suspension and Steering: Check ball joints, wheel bearings, drive axles, coupling rods, tie rod ends, and stabilizer bar rubber bushings for damage and excessive play
Underbody: Check underbody protection, underbody trim panels, wire routing, and plugs for damage
Windshield: Check for damage
Additional Maintenance Items
Air filter element and snow screen: Replace element. Clean
screen and housing
Every 60,000 miles or 6 years, whichever occurs first
AWD clutch: Change fluid (if equipped)
Every 3 years (AWD only vehicles)
Brake fluid: Change
3 years after initial registration, then every 2 years, regardless of
mileage
Coolant pump toothed belt: Check
At 150,000 miles, then every 20,000 miles (*1.4L Jetta only)
Dust and pollen filter: Replace
Every 40,000 miles or 2 years, whichever occurs first
Front axle differential lock (if equipped): Change fluid
Every 3 years
Panorama Sliding Sunroof: (if equipped)
{{ For gray grease, the guide rails must be cleaned and
greased, and the wind deflector must also be cleaned.
{{ For colorless grease, only perform a functional check
while listening for unusual noises
After 40,000 miles or 3 years, then every 40,000 miles or 2 years,
whichever occurs first
Spark plugs: Replace
Every 40,000 miles or 4 years, whichever occurs first (*4-cyl Gasoline: 1.4L, 1.8L, and 2.0L)
Spark plugs: Replace
Every 60,000 miles or 6 years, whichever occurs first (*6-cyl Gasoline: 3.6L engines only)
Timing belt: Check
At 150,000 miles, then every 20,000 miles (*1.4L Jetta only)
Tire Filler Bottle (if equipped): Check expiration date
Every 2 years: Must not be more than 4 years old
Transmission, 6-Speed DSG: Change fluid and filter
Every 40,000 miles
Transmission, 7-Speed DSG: Change fluid (Golf R only)
Every 80,000 miles
Transmission, Automatic (non-DSG): Change fluid and filter
Every 80,000 miles
© 2017 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without
notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying,
recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
2
Revised 11/10/2017