L-SB-0148-17-Rev
Service Bulletin Details
Public Details for: L-SB-0148-17-Rev
Tsb: revision notice september 12, 2018 rev1: ? The warranty information, parts information, and calibration information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2015 ? 2017 model
Models from 2017
2017 LEXUS GS 200T |
2017 LEXUS IS 300 |
2017 LEXUS RC 350 |
2017 LEXUS RX HYBRID |
2017 LEXUS RX450H |
Models from 2016
2016 LEXUS GS 200T |
2016 LEXUS NX |
2016 LEXUS RC 350 |
2016 LEXUS RX HYBRID |
2016 LEXUS RX450H |
Models from 2015
2015 LEXUS NX |
2015 LEXUS RC 200T |
L-SB-0148-17 Rev1 August 7, 2017 SRS MIL ON DTC B1000 Service Category Vehicle Interior Section Supplemental Restraint Systems Market USA Applicability YEAR(S) MODEL(S) 2015 - 2017 NX200T, NX300H 2016 - 2017 RX350, RX450H ADDITIONAL INFORMATION REVISION NOTICE September 12, 2018 Rev1: The Warranty Information, Parts Information, and Calibration Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Introduction Some 2015 – 2017 model year NX200t, NX300h, and 2016 – 2017 model year RX350 and RX450h vehicles may exhibit an intermittent MIL ON condition with Diagnostic Trouble Code (DTC) B1000 (Center Airbag Sensor Assembly Malfunction) stored in the history. This condition does not affect the proper operation of the Supplemental Restraint System (SRS). The SRS Electronic Control Unit (ECU) logic has been modified to reduce the possibility of this condition occurring. Follow the Repair Procedure in this bulletin to address this condition. Warranty Information OP CODE EL9057 DESCRIPTION MODEL TIME OFP NX200t, NX300h 0.4 89170-78010 0.4 89170-0E190 89170-0E191 89170-0E201 89170-48A81 Reprogram SRS ECU RX350, RX450h T1 T2 8B 71 APPLICABLE WARRANTY This repair is covered under the Lexus Restraint System Warranty. This warranty is in effect for 72 months or 70,000 miles, whichever occurs first, from the vehicle’s in-service date. Warranty application is limited to occurrence of the specified condition described in this bulletin. © 2018 Lexus, a division of Toyota Motor Sales, USA Page 1 of 3 L-SB-0148-17 Rev1 August 7, 2017 Page 2 of 3 SRS MIL ON DTC B1000 Parts Information PART NUMBER MODEL PREVIOUS NX200t, NX300h 89170-78010 RX350, RX450h 89170-0E190 89170-0E191 89170-0E201 89170-48A81 PART NAME QTY Computer Assy, Air Bag 1 NEW NOTE The ECU should NOT be replaced as part of the Repair Procedure. Required Tools & Equipment REQUIRED EQUIPMENT SUPPLIER PART NUMBER Techstream 2.0* Techstream Lite QTY TS2UNIT ADE TSLITEPDLR01 Techstream Lite (Green Cable) 1 TSLP2DLR01 *Essential SST. NOTE Only ONE of the Techstream units listed above is required. Software version 13.10.019 or later is required. Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at 1-800-368-6787. SPECIAL SERVICE TOOLS (SST) PART NUMBER QTY GR8 Battery Diagnostic Station* 00002-MCGR8 1 *Essential SST. NOTE Additional SSTs may be ordered by calling 1-800-933-8335. © 2018 Lexus, a division of Toyota Motor Sales, USA L-SB-0148-17 Rev1 August 7, 2017 Page 3 of 3 SRS MIL ON DTC B1000 Calibration Information CALIBRATION ID MODEL MODEL YEAR NX200t, NX300h 2015 – 2017 RX350, RX450h 2016 – 2017 PREVIOUS NEW 8917F78012 8917F78013 8917F48324 8917F48325 8917F0E103 8917F0E210 8917F0E104 8917F0E105 8917F0E114 8917F0E115 Repair Procedure 1. Using Techstream, check for stored DTCs. Are there ANY DTCs other than DTC B1000 present? NO — Continue to step 2. YES — This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual. 2. Flash reprogram the SRS ECU. NOTE The GR8 Battery Diagnostic Station MUST be used in Power Supply Mode to maintain battery voltage at 13.5V while flash reprogramming the vehicle. For details on how to use the GR8 Battery Diagnostic Station, refer to the GR8 Instruction Manual located on TIS, Diagnostics – Tools & Equipment – Battery Diagnostics. Follow the procedures outlined in Service Bulletin No. L-SB-0001-18 Techstream ECU Flash Reprogramming Procedure, and flash the SRS ECU with the NEW calibration file update. 3. Start the engine and perform a Health Check to confirm proper vehicle operation. © 2018 Lexus, a division of Toyota Motor Sales, USA