A011884 2047707-
Service Bulletin Details
Public Details for: A011884 2047707-
Models from 2018
2018 AUDI A5 |
2018 AUDI S4 |
2018 AUDI S5 |
2018 AUDI SQ5 |
Models from 2017
2017 AUDI A4 |
2017 AUDI A4 ALLROAD |
01 DTC(s) P195000, P10EF00, and/or B10F000 stored in engine control module or heating/air conditioning electronics 01 18 84 2047707/7 August 24, 2018. Supersedes Technical Service Bulletin Group 01 number 18-76 dated June 12, 2018 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment A4 2017 - 2018 All Not Applicable A5, S4, S5, and SQ5 2018 All Not Applicable Condition REVISION HISTORY Revision Date Purpose 7 - Revised header data (Added models) 6 06/12/2018 Revised header data (Added models) 5 01/26/2018 Revised Service (Added SVM table) Revised Warranty (Updated Labor Operations) Revised Additional Information (Updated disclaimer) Customer states: The air conditioning system sometimes does not work, only warm air comes out of the vents. The MIL is sometimes on in connection with poor engine performance. Workshop findings: One or more of the following DTC(s) can be entered into the engine control module (ECM), J623 (address word 0001): DTC P195000 (cooling fan -V7 - stiff/blocked). And/or DTC P10EF00 (restricted function because of radiator fan failure). And/or the following DTC can be stored in the heating/air conditioning electronics, E87 (address word 0008): DTC B10F000 (restricted function because A/C compressor was switched off by engine). Page 1 of 3 © 2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Note: After terminal 15 cycle/ignition cycle the air conditioning works again and the engine emergency operation ends. Tip: This DTC has no effect on the function of the cooling fan and does not indicate a failure in the cooling fan. Technical Background Voltage drop at hot start causes a DTC(s) to appear without cause. Production Solution Not applicable. Service Vehicles with 2.0 TFSI engine: If this DTC is discovered during service or any other unrelated repair, erase the DTC upon exiting GFF. When diagnosing this DTC due to a customer concern, only replace the cooling fan if the GFF test result instructs to replace the cooling fan. Vehicles with 3.0 TFSI engine: Update the engine control module (ECM), J623 (address word 0001) using the SVM action code as listed in the table below, if necessary (see TSB 2011732: 00 Software Version Management (SVM), operating instructions): Model Engine and/or Transmission Old Software Part Number Old Software Version New Software Part Number New Software Version SVM Code Input (or higher) S4/S5 (all) CWGD 8W0907559H < 0008 8W0907559H 0008 01A234 SQ5 CWGD 80A907559C < 0007 80A907559C 0007 01A234 Page 2 of 3 © 2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Warranty Claim Type: 110 up to 48 Months/50,000 Miles. G10 for CPO Covered Vehicles – Verify Owner. If vehicle is outside any warranty, this Technical Service Bulletin is informational only. Service Number: 1908 Damage Code: 0040 Labor Operations: 3.0T engine only: Diagnostic Time: Claim Comment: Connect battery charger and perform software update with SVM 2470 2599 50 TU GFF - (2.0TFSI and 3.0T) 0150 0000 Time stated on diagnostic protocol (Max 20 TU) Road test prior to service procedure No allowance 0 TU Road test after service procedure No allowance 0 TU As per TSB #2047707/7 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. Additional Information The following Technical Service Bulletin will be necessary to complete this procedure: TSB 2011732, 00 Software Version Management (SVM), operating instructions. All parts and service references provided in this TSB (2047707) are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information. Please check the Repair Manual for fasteners, bolts, nuts, and screws that require replacement during the repair. ©2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites without the prior expressed written permission of the publisher. Page 3 of 3 © 2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.