T-SB-0094-19_Rev

T-SB-0094-19
Rev1
August 2, 2019
MIL ON DTC P013A00 and/or P013C00 - Incomplete
Weld at Front Exhaust Pipe
Service
Category
Engine/Hybrid System
Section
Intake/Exhaust
Market USA
Applicability
YEAR(S)
MODEL(S)
ADDITIONAL INFORMATION
2016 - 2019
Tacoma
WMI(s): 3TM, 5TF
VDS(s): AZ5CN, BZ5DN, CZ5AN, DZ5BN,
EZ5CN, FZ5DN, GZ5AN, HZ5BN, RZ5CN,
SZ5AN
Engine(s): 2GR
Drive Type(s): 2WD, 4WD
Body Type(s): C CAB, D CAB
Transmission(s): 6MT, 6AT
REVISION NOTICE
October 14, 2019 Rev1:
 The Production Change Information section has been updated.
Any previous printed versions of this bulletin should be discarded.
Introduction
Some 2016 – 2019 model year Tacoma vehicles equipped with a 2GR-FKS engine may exhibit a
MIL ON condition with Diagnostic Trouble Codes (DTCs) P013A00 and/or P013C00
(O2 Slow Response) due to an incomplete weld around the front exhaust pipe assembly
(either bank). Follow the Repair Procedure in this bulletin to address this condition.
© 2019 Toyota Motor Sales, USA
Page 1 of 5
T-SB-0094-19
Rev1
August 2, 2019
Page 2 of 5
MIL ON DTC P013A00 and/or P013C00 - Incomplete Weld at Front Exhaust Pipe
Production Change Information
This bulletin applies to vehicles produced BEFORE the Production Change Effective VINs
shown below.
MODEL
PLANT
DRIVETRAIN
PRODUCTION CHANGE EFFECTIVE VIN
5TFAZ5CN#KX082777
5TFBZ5DN#KX004805
5TFFZ5DN#GX001697
5TFRZ5CN#KX082782
2WD
5TFEZ5CN#KX083074
5TFAZ5CN#KX085794
5TFBZ5DN#KX004889
5TFRZ5CN#KX085791
5TFEZ5CN#KX085816
TMMTX
5TFCZ5AN#KX195109
5TFSZ5AN#KX195001
5TFDZ5BN#KX044313
5TFGZ5AN#KX195292
Tacoma
4WD
5TFHZ5BN#JX037888
5TFCZ5AN#KX205130
5TFSZ5AN#KX205135
5TFDZ5BN#KX045807
5TFGZ5AN#KX205132
3TMAZ5CN#KM102381
3TMBZ5DN#KM021382
3TMEZ5CN#KM102438
3TMCZ5AN#KM255792
TMMBC
2WD
3TMGZ5AN#KM255650
3TMDZ5BN#KM071496
3TMAZ5CN#KM109658
3TMBZ5DN#KM022415
3TMEZ5CN#KM109744
© 2019 Toyota Motor Sales, USA
T-SB-0094-19
Rev1
August 2, 2019
Page 3 of 5
MIL ON DTC P013A00 and/or P013C00 - Incomplete Weld at Front Exhaust Pipe
Production Change Information (continued)
This bulletin applies to vehicles produced BEFORE the Production Change Effective VINs
shown below.
MODEL
PLANT
DRIVETRAIN
PRODUCTION CHANGE EFFECTIVE VIN
3TMCZ5AN#KM274316
3TMGZ5AN#KM274291
Tacoma
TMMBC
4WD
3TMDZ5BN#KM075945
3TMCZ5AN#KM255792
3TMGZ5AN#KM255650
3TMDZ5BN#KM071496
Warranty Information
OP CODE
DESCRIPTION
TIME
OFP
T1
T2
170171
R & R Front Exhaust Pipe Assembly
0.9
17410-0P560
17450-0P350
17450-0P360
8A
68
APPLICABLE WARRANTY
 This repair is covered under the Toyota Federal Emission Warranty. This warranty is in effect for
96 months or 80,000 miles, whichever occurs first, from the vehicle’s in-service date.
 Warranty application is limited to occurrence of the specified condition described in
this bulletin.
© 2019 Toyota Motor Sales, USA
T-SB-0094-19
Rev1
August 2, 2019
Page 4 of 5
MIL ON DTC P013A00 and/or P013C00 - Incomplete Weld at Front Exhaust Pipe
Parts Information
DRIVE TYPE
PART NUMBER
2WD
17450-0P350
PART NAME
QTY
1
Pipe Assy, Exhaust, Front No. 2
4WD
17450-0P360
17410-0P560
1
Pipe Assy, Exhaust, Front
90080-43036
2WD, 4WD
1
1*
Gasket, Exhaust Pipe
17451-21030
90917-A6005
1
Gasket, Exhaust Pipe No. 2
1
*One gasket per affected bank.
Required Tools & Equipment
REQUIRED EQUIPMENT
SUPPLIER
Techstream ADVi*
QTY
TSADVUNIT
Techstream 2.0
Techstream Lite
PART NUMBER
TS2UNIT
ADE
Techstream Lite (Green Cable)
TSLITEPDLR01
TSLP2DLR01
*Essential SST.
NOTE
 Only ONE of the Techstream units listed above is required.
 Software version 14.20.019 or later is required.
 Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE)
at 1-800-368-6787.
Repair Procedure
1. Confirm the condition exists.
Does the vehicle exhibit a MIL ON condition with DTCs P013A00 and/or P013C00?

YES — Continue to step 2.

NO — This bulletin does NOT apply. Continue diagnosis using the applicable
Repair Manual.
© 2019 Toyota Motor Sales, USA
1
T-SB-0094-19
Rev1
August 2, 2019
Page 5 of 5
MIL ON DTC P013A00 and/or P013C00 - Incomplete Weld at Front Exhaust Pipe
Repair Procedure (continued)
2. Inspect the front exhaust pipe for incomplete weld (exhaust leak) around the O2 boss
and flanges.
Does the front exhaust pipe exhibit an exhaust leak condition?

YES — Continue to step 3.

NO — This bulletin does NOT apply. Continue diagnosis using the applicable
Repair Manual.
3. Replace the affected front exhaust pipe and gaskets.
A. Remove the front exhaust pipe and gaskets.
Refer to TIS, applicable model and model year Repair Manual:

2016 / 2017 / 2018 / 2019 Tacoma:
Engine/Hybrid System – Intake/Exhaust –
“2GR-FKS (Exhaust): Exhaust Pipe: Removal”
B. Install the NEW front exhaust pipe and gaskets.
Refer to TIS, applicable model and model year Repair Manual:

2016 / 2017 / 2018 / 2019 Tacoma:
Engine/Hybrid System – Intake/Exhaust –
“2GR-FKS (Exhaust): Exhaust Pipe: Installation”
4. Clear DTCs and test-drive the vehicle to confirm proper operation.
© 2019 Toyota Motor Sales, USA