A2020282060032_1

20 MIL on, DTC P045600 and/or P044200 stored in the ECM
20 20 28 2060032/1 July 15, 2020.
Model(s)
Year
VIN Range
Vehicle-Specific Equipment
Q5
2019
All
Not Applicable
Q5
2020
000001 - 078943
Not Applicable
Condition
Customer states:
 MIL on.
Workshop findings:
One or more of the following DTCs are stored as static or sporadic in the engine control module (ECM), J623
(address word 0001):
 DTC P045600 (EVAP Emission Contr.Sys.(Very Small Leak) Leak Detected).
 DTC P044200 (EVAP Emission Contr.Sys.(Small Leak) Leak Detected).
Technical Background
EVAP leak detection pump (GX36) internal defect is causing a false leak detection.
Production Solution
Optimized EVAP LD Pump (GX36, DMTL) introduced at the beginning of March 2020.
Service
1. Replace the EVAP LD Pump GX36.
2. Confirm that there is no leak in the system by manually adding and performing test plan: V144 - Fuel system
diagnostic pump - Component test.
Page 1 of 3
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
Warranty
Claim Type:
 110 up to 48 Months/50,000 Miles.
 G10 for CPO Covered Vehicles – Verify Owner.
 If the vehicle is outside any warranty, this Technical Service Bulletin is informational
only.
Service Number:
2048
Damage Code:
0010
Labor Operations:
Leak diagnosis pump removed + reinstall
2048 1950
See SRT with
associated
operations
Rear wheel housing liners removed + reinstall
6676 1900
See SRT with
associated
operations
GFF – Checking and clearing fault codes
included in existing labor operations
0150 0000
Time stated on
the diagnostic
protocol (Max
30 TU)
Road test prior to the service procedure
No allowance
0 TU
Road test after the service procedure
No allowance
0 TU
Diagnostic Time:
Claim Comment:
As per TSB #2060032/1
All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures
Manual. Claims are subject to review or audit by Audi Warranty.
Required Parts and Tools
Always check with your Parts Department and/or ETKA for the latest information and parts bulletins.
Part Number
Part Description
Quantity
See ETKA
Fasteners, Bolts, Nuts, and Screws as needed per the
Repair Manual
See ETKA/ELSA
7L0906243A
LD Pump (DMTL)
01
Page 2 of 3
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
Additional Information
All parts and service references provided in this TSB (2060032) are subject to change and/or removal.
©2020 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes
at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the
publisher.
Page 3 of 3
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.