SC189_TSB
Service Bulletin Details
Public Details for: SC189_TSB
Technical service bulletin: voluntary emissions service campaign - auxiliary canister installation and evap leakage test (sc189) - this bulletin provides information on the installation of an auxiliary evap canister on some 2011-2015my opti
- 2015 - 2014 - 2013 - 2012 - 2011 -
Models from 2015
2015 KIA OPTIMA |
Models from 2014
2014 KIA OPTIMA |
Models from 2013
2013 KIA OPTIMA |
Models from 2012
2012 KIA OPTIMA |
Models from 2011
2011 KIA OPTIMA |
GROUP MODEL Emissions 2011-2015MY Service Campaign Optima (TF) NUMBER SC189 DATE August 2020 VOLUNTARY EMISSIONS SERVICE CAMPAIGN AUXILIARY CANISTER INSTALLATION AND EVAP LEAKAGE TEST (SC189) SUBJECT: This bulletin provides information on the installation of an auxiliary EVAP canister on some 2011-2015MY Optima (TF) vehicles equipped with Theta 2.4L GDI engines, produced from August 12, 2010 through July 23, 2015. This is to improve evaporative system performance and ensure compliance with Federal and California emission regulation standards. Before conducting the procedure, verify the vehicle is included in the list of affected VINs. Note: The existing canister should not be uninstalled or replaced. Auxiliary Canister NOTICE VINs which start with KNA are designated Optima (TF/TF HEV) and built in South Korea. VINs that start with 5XX are designated Optima (QF) and built in the United States. This campaign does not apply to Optima (TF HEV and QF) model vehicles. NOTICE To assure complete customer satisfaction, always remember to refer to WebDCS Warranty Coverage (validation) Inquiry Screen (Service → Warranty Coverage → Warranty Coverage Inquiry) for a list of any additional campaigns that may need to be performed on the vehicle before returning it to the customer. Printed TSB copy is for reference only; information may be updated at any time. Always refer to KGIS for the latest information. Circulate To: X General Manager X Service Advisors X Technicians X Service Manager X Parts Manager X Body Shop Manager X Fleet Repair Page 2 of 5 SUBJECT: AUXILIARY CANISTER INSTALLATION AND EVAP LEAKAGE TEST (SC189) Installation Procedure: 1. Lift vehicle on a hoist and locate the evaporative system vent hose (A) near the charcoal canister. A 2a. Measure and mark the 50mm cutting section of the evaporation vent hose (A) in the area shown. A 2b. Using a blade, cut off the 50mm of the evaporation hose as shown. 3a. Install the new auxiliary canister (B) and secure using the two (2) supplied hose clamps (C). C B Printed TSB copy is for reference only; information may be updated at any time. Always refer to KGIS for the latest information. TSB: SC189 Optima (TF) August 2020 Page 3 of 5 SUBJECT: AUXILIARY CANISTER INSTALLATION AND EVAP LEAKAGE TEST (SC189) 3b. Ensure that the auxiliary canister (B) is angled as to not make contact with any surrounding body parts. B 4. Perform KDS Evap Leakage Test using KDS. Note: “Enable Condition” may display differently. 5. Confirm test completed to ensure auxiliary canister installation was successful. Printed TSB copy is for reference only; information may be updated at any time. Always refer to KGIS for the latest information. TSB: SC189 Optima (TF) August 2020 Page 4 of 5 SUBJECT: AUXILIARY CANISTER INSTALLATION AND EVAP LEAKAGE TEST (SC189) ATTENTION: THE PROOF OF CORRECTION CARD AND CAMPAIGN COMPLETION STICKER ARE RESTRICTED TO DEALERS IN THE FOLLOWING STATES: California, Connecticut, District of Columbia, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington. See Parts Information below to order the Proof of Correction Card and Campaign Completion Label from the PDC. VEHICLE EMISSION RECALL - PROOF OF CORRECTION CARD A Vehicle Emission Recall - Proof of Correction card must be filled out for all vehicles registered in California, Connecticut, Maine, Maryland, Massachusetts, New Jersey, Oregon, Pennsylvania, Rhode Island, Vermont, Washington, New York and Delaware. Residents of these states, who own an affected vehicle, will be required to possess a Vehicle Emission Recall - Proof of Correction card as evidence of voluntary service campaign completion, when they apply for vehicle registration renewal. WHAT TO DO WITH THE CARD: The Vehicle Emission Recall - Proof of Correction card must be completed by the Dealership's Service Manager using a permanent ink pen. A fine point pen is recommended. When filling in the information, copy the information directly from the vehicle, not the repair order. ALL INFORMATION MUST BE PRINTED AND NEAT. NOTE: DO NOT COMPLETE THE CARD UNLESS THE SERVICE CAMPAIGN WORK IS COMPLETED. The copy of the card shown below indicates the areas to be filled in. Each area must be filled in. The completed card should be given to the owner of the vehicle upon completion of the Campaign and placement of the Campaign Completion Label outlined below. FILLING OUT AND APPLYING THE CAMPAIGN COMPLETION LABEL (CA and S.177 STATES ONLY): The dealer must fill in the Dealer Code and Date information fields on the Campaign Completion Label. Once complete, affix the campaign completion label under the hood of the vehicle, as shown below. CA and S.177 States Only: Apply SC189 Campaign Completion Label onto the SC189 body in the area next to the shock tower, Dealer Code: as shown. NOTE: Be sure to clean the mounting surface to ensure proper Date: label adhesion. Printed TSB copy is for reference only; information may be updated at any time. Always refer to KGIS for the latest information. TSB: SC189 Optima (TF) August 2020 Page 5 of 5 AUXILIARY CANISTER INSTALLATION AND EVAP LEAKAGE TEST (SC189) SUBJECT: AFFECTED VEHICLE RANGE: Model Production Date Range Optima (TF) August 12, 2010 to July 23, 2015 REQUIRED PART: Part Name Part Number Auxiliary Canister Kit 31410 2T511QQK Figure Qty. 1 SC189 Campaign Completion Label UT160 SC189* Vehicle Emission Recall Proof of Correction Card UT161 SC189* Dealer Code: 1 Date: 1 *Completion Label and Proof of Correction Card only required for vehicles registered in CA, CT, DE, MA, MD, ME, NJ, NY, OR, PA, RI, VT, and WA “States” only. WARRANTY INFORMATION: N Code: N99 C Code: C99 Claim Type R Causal P/N 31421 2T600 Qty. Repair Description Labor Op Code Op Time Replacement P/N Qty. 0 (SC189) Auxiliary Canister Installation and EVAP Leakage Test 200008R0 0.4 M/H 31410 2T511QQK 1 NOTICE VIN inquiry data for this repair is provided for tracking purposes only. Kia retailers should reference SC189 when accessing the WebDCS system. Printed TSB copy is for reference only; information may be updated at any time. Always refer to KGIS for the latest information. TSB: SC189 Optima (TF) August 2020