K128NAS1

TECHNICAL BULLETIN
K128NAS1
25 SEPT 2012
THIS SERVICE ACTION SUPERSEDES UPDATE PRIOR TO SALE NOTICE 0512-4b,
IS VALID FOR A LIMITED TIME ONLY, AND WILL EXPIRE ON 30 SEPTEMBER 2014
SECTION: 417
Service Action: Right-Hand Rear Fog Lamp
AFFECTED VEHICLE RANGE:
XK (X150)
VIN:
Model Year:
Specific vehicles; see attached list
2012
CONDITION SUMMARY:
Situation: A limited number of 2012 model year Jaguar XK vehicles may have been manufactured away from
process and in some cases the right-hand (RH) rear fog lamp may be incorrectly welded.
Action: Dealers are required to 'HOLD' the affected vehicles within your control and refrain from releasing the
vehicles for new or used vehicle sale pending completion of the rework action detailed in this Technical
Bulletin. For vehicles in dealer inventory, this Service Action should be performed in conjunction with the
vehicle Pre-Delivery Inspection (PDI). For vehicles in dealer inventory which have already had the PDI
completed, this UPS should be completed prior to final preparation / customer handover. For those vehicles
already in the hands of customers, this should be done at the next available opportunity prior to the expiration
date.
PARTS:
PART NO.
DESCRIPTION
QTY
% OF VEHICLES REQUIRING PART*
C2P21456
Foam seal
1
100
C2P21458
Rear fog lamp (right-hand)
1
100
* when ordering parts, order the expected percentage failure rate of parts identified only
TOOLS:
Refer to Workshop Manual for any required special tools
WARRANTY:
NOTE: Repair procedures are under constant review, and therefore times / prices are subject to
change; those quoted here must be taken as guidance only. Always refer to DDW to obtain the latest
repair time. Check DDW to ensure that the vehicle is affected by this Service Action prior to
undertaking any rework action. At the time of confirming a booking for vehicle repair, ensure that all
outstanding Service Actions are identified to ensure the correct parts are available and adequate
workshop time is allocated for repairs to be completed at one visit.
Warranty claims must be submitted quoting Program Code 'K128' together with the relevant Option Code
from the table. SRO and parts information is included for information only. The Option Code(s) that allows for
the drive in / drive out allowance can only be claimed if the vehicle is brought back into the workshop for this
action alone to be undertaken.
This Service Action is valid for a limited time only. Warranty claims with a repair date prior to the
30 September 2014 closure date must be submitted for payment within 30 calendar days of completion of the
repair.
NOTE: The information in Technical Bulletins is intended for use by trained, professional Technicians with the knowledge, tools, and
equipment required to do the job properly and safely. It informs these Technicians of conditions that may occur on some vehicles, or
provides information that could assist in proper vehicle service. The procedures should not be performed by 'do-it-yourselfers'. If you are
not a Retailer, do not assume that a condition described affects your vehicle. Contact an authorized Jaguar service facility to determine
whether this bulletin applies to a specific vehicle.
© Jaguar Land Rover North America, LLC
555 MacArthur Boulevard
Mahwah, NJ 07430
PROGRAM
CODE
OPTION
CODE
DESCRIPTION
SRO
K128
K128
B
Fit foam seal; replace right-hand rear fog lamp Coupe
86.94.41
0.50
C2P21456
C2P21458
1
1
Fit foam seal; replace right-hand rear fog lamp Coupe
Drive in / drive out
86.94.41
0.50
C
10.10.10
0.10
C2P21456
C2P21458
-
1
1
-
K128
B
Fit foam seal; replace right-hand rear fog lamp Convertible
86.94.41
0.30
C2P21456
C2P21458
1
1
0.30
C
Fit foam seal; replace right-hand rear fog lamp Convertible
Drive in / drive out
86.94.41
K128
10.10.10
0.10
C2P21456
C2P21458
-
1
1
-
Normal Warranty policies and procedures apply
REPAIR PROCEDURE
REPLACE RIGHT-HAND REAR FOG LAMP
1. Convertible only: refer to Workshop Manual section 501-05
and remove the luggage compartment lid trim panel.
2. Coupe only: refer to Workshop Manual, section 501-05 and
remove the liftgate lower trim panel.
3. Remove the right-hand (RH) reverse / fog lamp:

Remove the three (3) plastic nuts.

Disconnect the electrical connector.
TIME
(HOURS)
PART NO.
QTY.
CAUTION: Clean the contact areas on the lamp making
sure all grease and dirt is removed before installing the
foam surround.
4. Fit foam seal surround to new RH reverse / fog lamp:

Starting at the top of the new lamp, peel back the
protection and apply foam surround to lamp.

Cut off and discard any excess seal.
5. Install the new right-hand (RH) reverse / fog lamp:

Connect the electrical connector.

Install the three (3) plastic nuts.
6. Convertible only: refer to Workshop Manual section 501-05
and install the luggage compartment lid trim panel.
7. Coupe only: refer to Workshop Manual, section 501-05 and
install the liftgate lower trim panel.
Service Action K128
Affected VIN List
Canada
RETAILER CODE / NAME
VIN
3306 John Scotti Jaguar
B47642
4495 Coventry North Jaguar
B47645
USA
RETAILER CODE / NAME
VIN
0518 San Jose British Motors
B47599*
5398 Jaguar Greensboro
B47557*
5581 Jaguar Palm Beach
B47636
5609 Jaguar Boise
B47533
5612 Jaguar Huntsville
B47537
5684 Bergen Jaguar
B47632
5691 Jaguar of Sarasota
B47652
5708 THE COLLECTION
B47541
B47613
5727 Crest Jaguar of Woodbridge
B47641
5729 Gaudin Jaguar
B47530
5744 Jaguar Huntington
B47545
5755 Jaguar Anaheim Hills
B47605
*vehicles currently shown in retailer stock