A4722202068205_2

Technical Service Bulletin
47 Vibration/noise from brake pedal area - pedal feels different - DTC P05FF00
47 22 20 2068205/2 November 8, 2022. Supersedes Technical Service Bulletin Group 47 number 22-19 dated
October 10, 2022 for reasons listed below.
Model(s)
e-tron GT, and
RS e-tron GT
Year
VIN Range
Vehicle-Specific Equipment
2022 – 2023
All
Not Applicable
Condition
REVISION HISTORY
Revision
Date
Purpose
2
-
Revised Service (Revised Procedure)
Revised Parts and Tools (Added table)
Revised Warranty (Added Labor Operation)
1
10/10/2022
Initial publication
Customer states:
During braking at low speeds, a vibration/pulsation is felt at the brake pedal, and/or the brake pedal feels “different
”.
Workshop findings:
The following DTC may be stored in the ABS/ESC Control Module -J104- (address word 0003):
• DTC P05FF00 – Brake pressure sensor / Sensor for brake pedal travel deviation.
Page 1 of 4
© 2022 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,
stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to
other sites, without the prior expressed written permission of the publisher.
Technical Service Bulletin
The complaint can be reproduced.
Technical Background
Not applicable.
Production Solution
Under Analysis.
Service
1. Read out the measured value “Adaption value offset wheel brake stiffness” and upload the log to GFF Paperless.
2. If the measured value is above 5mm, replace the J104 ABS control unit and bleed the system fully according to
ELSA>>Workshop Manual>>Chassis>>Brake System>>47 Hydraulic Components>>Hydraulic
System>>Bleeding.
3. If the measured value is below 5mm, only bleed the brake system.
4. Clear DTCs in the J104 ABS/ESC control unit.
5. Re-evaluate the vehicle for improvements concerning noises and brake pedal feel. If the issue has been solved,
release the vehicle. If the complaint is still present, repeat the bleed procedure.
Note:
For noise complaints, please upload a video/audio file to DOC-IT with the respective VIN number.
Warranty
Page 2 of 4
© 2022 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,
stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to
other sites, without the prior expressed written permission of the publisher.
Technical Service Bulletin
Claim Type
• 110 up to 48 Months/50,000 Miles.
• If the vehicle is outside any warranty, this Technical Service Bulletin is informational
only.
Service Number:
4708 (bleed brake system)
4530 (ABS replacement)
Damage Code:
0011 (bleed brake system)
0010 (ABS replacement)
Labor Operations:
Diagnostic Time:
Replace hydraulic unit
4530 5550
See SRT
Bleed brake system
4701 0750
See SRT
GFF
0150 0000
Time stated on
the diagnostic
protocol (Max 70
TU)
Claim Comment:
Road test prior to the service procedure
0121 0002
10 TU
Road test after the service procedure
0121 0004
10 TU
As per TSB 2068205/2
All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures
Manual. Claims are subject to review or audit by Audi Warranty.
Required Parts and Tools
Always check with your Parts Department and/or ETKA for the latest information and parts bulletins.
Page 3 of 4
© 2022 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,
stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to
other sites, without the prior expressed written permission of the publisher.
Technical Service Bulletin
Part Number
Part Description
Quantity
See ETKA
Fasteners, Bolts, Nuts, and Screws as needed per the
See ETKA/ELSA
Repair Manual
See ETKA
Hydraulic Unit
01 (if necessary)
Additional Information
All part and service references provided in this TSB (2068205) are subject to change and/or removal. Always check
with your Parts Department and/or ETKA for the latest information and parts bulletins. Please check the Repair
Manual for fasteners, bolts, nuts, and screws that require replacement during the repair.
©2022 Audi of America, Inc. All rights reserved. The information contained in this document is based on the latest
information available at the time of printing and is subject to the copyright and other intellectual property rights of
Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time
without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any
form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be
modified or reposted to other sites, without the prior expressed written permission of the publisher.
Page 4 of 4
© 2022 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,
stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to
other sites, without the prior expressed written permission of the publisher.