TB441403
Service Bulletin Details
Public Details for: TB441403
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking, or surface rust built up during transportation.
Models from 2014
Models from 2013
Models from 2012
Technical Bulletin Model(s) Year(s) Eng. Code(s) Trans. Code(s) VIN Range From VIN Range To CC 2012-2013 All All AN_CE500000 AN_DE510569 Condition 44 14 03 October 27, 2014 2031249 Supersedes Technical Bulletin V441401 dated January 17, 2014 to update part number. Tire Pressure Monitor Warning Indicator ON Technical Background The tire pressure warning indicator illuminates indicating a fault in the Tire Pressure Monitoring System (TPMS) module. Production Solution New sensors in production as of AN_DE510569. Service If any of the following fault codes are displayed, replace all 4 TPMS sensors. See repair manual group 44, Chassis, Suspension, Wheels, Steering/ Wheels, Tires, Wheel Alignment/ Removal Installation/ Tire Pressure Sensor in Elsa. DTC Description C105031 Left front tire pressure monitoring sensor No signal. C105131 Right front tire pressure monitoring sensor No signal. C105231 Left rear tire pressure monitoring sensor No signal. C105331 Right rear tire pressure monitoring sensor No signal. Page 1 of 4 © 2014 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Note: Be sure to check service history in Elsa for any previous TPMS sensor replacements. • Replace original BERU sensors part number 3AA 907 275. • Install new HUF sensors 3AA 907 275 B. Note: Order TPMS kit number 3AA998270 as specified in the warranty parts table below. This kit includes the 4 new HUF sensors plus additional hardware. Page 2 of 4 © 2014 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Warranty To determine if this procedure is covered under Warranty, always refer to the Warranty Policies and 1) Procedures Manual Model(s) Year(s) Eng. Code(s) Trans. Code(s) VIN Range From VIN Range To CC 2012-2013 All All AN_CE500000 AN_DE510569 SAGA Coding Claim Type: Use applicable Claim Type 1) Damage Service Number: HST Damage Location (Depends on Service No.) -- Use applicable when indicated in ElsaWeb (L/R) Code 4432 0040 Parts Manufacturer CC 3) Labor Operation : Remove and Install, 4 wheel electronics BEB 44322055 = 70 TU (includes wheel balance) 3) Labor Operation : Remove and Install, 4 wheels 44052004 = 50 TU Causal Part: 3AA 998 270 Diagnostic Time GFF Time expenditure 01500000 = 20 TU max. 4) YES 01210002 = 10 TU Road Test YES 01210004 = 10 TU Technical Diagnosis 01320000 = 00 TU max. NO Claim Comment: Input “As per Technical Bulletin 2031249” in comment section of Warranty Claim. 1) Vehicle may be outside any Warranty in which case this Technical Bulletin is informational only Page 3 of 4 © 2014 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin 2) Code per warranty vendor code policy. 3) Labor Time Units (TUs) are subject to change with ELSA updates. 4) Documentation required per Warranty Policy Procedures Manual. Required Parts and Tools Tool Description Tool No: Midtronics Battery Tester/Charger InCharge 940 (INC-940) or GRX3000VAS VAS Diagnostic Tool VAS 6150/X & VAS 6160/X with ODIS Service with: current online updates Part Description Part Number Tire Pressure Control System Repair Kit 3AA 998 270 Additional Information All part and service references provided in this Technical Bulletin are subject to change and/or removal. Always check with your Parts Dept. and Repair Manuals for the latest information. Page 4 of 4 © 2014 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.