23-EV-005G
Service Bulletin Details
Public Details for: 23-EV-005G
This bulletin provides the procedure for updating the software of the vehicle charge management system (vcms) to improve charging. It may address an intermittent stops charging condition or the following ev light on dtc condition: dtc p1a
- 2023 -
Models from 2023
2023 GENESIS G80 EV |
2023 GENESIS GV60 |
2023 GENESIS GV70 |
SUBJECT: EV Systems 23-EV-005G June 2023 GV60 Electric (JW1 EV), G80 Electric (RG3 EV) GV70 Electric (JK1 EV) VCMS UPDATE FOR CHARGING SOFTWARE IMPROVEMENT Description: This bulletin provides the procedure for updating the software of the Vehicle Charge Management System (VCMS) to improve charging. It may address an intermittent stops charging condition or the following EV Light On DTC condition: DTC P1ABD00 – Battery Charger Coupler Temperature Too High Applicable Vehicles: • 2023MY GV60 Electric (JW1 EV) vehicles produced Feb. 4, 2022 to Jan. 05, 2023 • 2023MY G80 Electric (RG3 EV) vehicles produced Feb. 23, 2022 to Dec. 29, 2022 • 2023MY GV70 Electric (JK1 EV) vehicles produced Dec. 2, 2022 to May 23, 2023 GDS Information: System VCMS Event # Description 928* JW1 EV VCMS CHARGING CONDITION SOFTWARE LOGIC IMPROVEMENT 938* RG3 EV VCMS CHARGING CONDITION SOFTWARE LOGIC IMPROVEMENT 931* JK1 EV VCMS CHARGING CONDITION SOFTWARE LOGIC IMPROVEMENT *or any later updated event that comes up. Warranty Information: GV60 Electric 35001Q0C (JW1 EV) G80 Electric (RG3 EV) 35001Q0C VCMS UPGRADE 0.3 M/H 35000-1XCA0 I14 ZZ3 VCMS UPGRADE 0.3 M/H 35000-1XBA0 I14 ZZ3 GV70 Electric 35001-1XDA0 35001Q0C VCMS UPGRADE 0.3 M/H I14 ZZ3 (JK1 EV) NOTE 1: Op time includes VIN, Mileage, and photo capture of the “ECU Update Complete” screen. NOTE 2: Normal warranty applies. NOTE 3: Submit claim on Claim Entry Screen as “Warranty” type. NOTE 4: If a part that is not covered by this TSB needs replacement while performing this TSB, and the affected part is still under warranty, please submit a separate claim using the same repair order. If the part is out of warranty, submit a prior approval request for goodwill consideration prior to performing the work. Circulate To: General Manager, Service Manager, Parts Manager, Warranty Manager, Service Advisors, Technicians, Body Shop Manager, Fleet Repair VCMS UPDATE FOR CHARGING SOFTWARE IMPROVEMENT Service Procedure: STUI As outlined in the Digital Documentation Policy, all claims require VIN and Mileage validation through VCI connection or photo capture, AND photo capture of the “ECU Update Complete” screen. All claims submitted that have incomplete, illegible, or missing documentation are subject to debit. NOTICE You must initially perform the GDS ECU Update in Auto Mode. • If the ECU Update starts but then fails in Auto Mode, perform the update in Manual Mode to recover. ! WARNING GDS Vehicle Battery Low Voltage Warning: If voltage is below 12 volts as per the below GDS warning, then select Back and run the vehicle for at least 20 minutes to ensure an adequate battery state of charge for reliable update results. Turn ignition back on, and then retry the ECU update again. 1. Perform the VCMS Update in Auto Mode. a. Use the Auto Mode ID Check to verify the VCMS ROM ID before updating the software. TSB #: 23-EV-005G Page 2 of 4 SUBJECT: VCMS UPDATE FOR CHARGING SOFTWARE IMPROVEMENT b. After the ECU Upgrade process shows 100% complete, cycle the ignition key to OFF for at least 10 seconds to reset the control unit. c. Take a screenshot of the ECU Update complete screen and upload to STUI. STUI Take a screenshot of the ECU Update Complete screen using your particular tablet’s screenshot save method and upload to STUI. EXAMPLE 2. Perform an All Systems Fault Code search and erase the history of the DTC that had incidentally occurred from the ECU update. 3. Start the vehicle in Ready mode to confirm proper operation of the vehicle. 4. Confirm that vehicle functions to take a Level-1 ICCB or Level-2 AC Charge. TSB #: 23-EV-005G Page 3 of 4 SUBJECT: VCMS UPDATE FOR CHARGING SOFTWARE IMPROVEMENT ROM ID Information Table: VEHICLE MY SYSTEM ECU P/No. JW1 EV 23MY VCMS RG3 EV 23MY JK1 EV 23MY ROM ID OLD NEW 350001XCA0 EJWE1NM-CS1-D000 EJWE1NM-CS2-D000 EJWE3NM-CS1-D000 EJWE3NM-CS2-D000 VCMS 350001XBA0 ERGE1NM-CS6-D000 ERGE1NM-CS5-D000 ERGE1NM-CS7-D000 VCMS 350011XDA0 EJKE1NM-CS1-D000 EJKE1NM-CS2-D000 Manual Mode Password MENU JW1 EV VCMS 35000-1XCA0 RG3 EV VCMS 35000-1XBA0 JK1 EV VCMS 35001-1XDA0 TSB #: 23-EV-005G PASSWORD 3201 1147 3500 Page 4 of 4 SUBJECT: