TT271302
Service Bulletin Details
Public Details for: TT271302
Turn the ignition key to the start position. If the engine does not crank but a clicking noise can be heard from the starter, install a jumper cable from the battery negative cable to the engine block and attempt to start the engine again.
- 2014 - 2013 - 2012 - 2011 - 2010 - 2009 -
Models from 2014
2014 VOLKSWAGEN ROUTAN |
Models from 2013
2013 VOLKSWAGEN ROUTAN |
Models from 2012
2012 VOLKSWAGEN ROUTAN |
Models from 2011
2011 VOLKSWAGEN ROUTAN |
Models from 2010
2010 VOLKSWAGEN ROUTAN |
Models from 2009
2009 VOLKSWAGEN ROUTAN |
Tech Tips Date: October 11, 2013 TT 27-13-02 2009-2014 Routan- No Crank/ No Start –Starter Will Not Engage and there are No Related Codes Diagnosis: Turn the ignition key to the START position. If the engine does not crank but a clicking noise can be heard from the starter, install a jumper cable from the battery negative cable to the engine block and attempt to start the engine again. If the engine now cranks perform the following Repair Procedure A. If it still does not crank, perform Repair Procedure B. Repair Procedure A: 1. Inspect the existing grounds on the engine and Powertrain Control Module (PCM). Are the grounds free of corrosion, making a positive connection and are secure at their final termination? a. YES >>> Proceed to Step 2 b. NO >>> Repair as required and retest. 2. Inspect the Transmission Range Sensor (TRS) connector for signs of moisture, corrosion and proper connection. Is the TRS free from moisture, corrosion, and secured properly? a. YES >>> Proceed to Step 3 b. NO >>> Repair as required and retest. 3. Install a redundant ground from the battery negative terminal to the transmission bell housing. It is recommended to use an 8 gauge wire or larger. Repair Procedure B: Install a new Transmission Range Sensor (TRS). Refer to Elsa Web Repair Manual > Transmission > Automatic Transmission >Controls Housing >Removal and Installation >Transmission Range Sensor. Page 1 of 1 ver1.2 © 2013 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.