A4324822073034_1
Service Bulletin Details
Public Details for: A4324822073034_1
This bulletin provides information for when there is an air suspension fault - dtc C118D01.
Models from 2024
Models from 2023
Technical Service Bulletin 43 Air suspension system fault - DTC C118D01 Compressor for level control electrical error 43 24 82 2073034/1 February 19, 2024. Model(s) Year A6, A6 allroad, S6, RS 6 Avant, A7, S7, RS 7, A8, S8, e-tron quattro, e-tron Sportback quattro, e-tron S, 2023 – 2024 Q5, Q5 e quattro, Q5 Sportback, SQ5, SQ5 Sportback, Q7, SQ7, Q8, SQ8, and RS Q8 Q8 e-tron, Q8 Sportback e-tron, SQ8 e-tron, and SQ8 Sportback e-tron VIN Range Vehicle-Specific Equipment All Air Suspension 2024 Condition Customer states: The message “Air suspension: system fault” is shown in the instrument cluster. Workshop findings: The following DTC is logged in the suspension control unit J775 (diagnostic address 0074): • C118D01: Compressor for level control electrical error. Technical Background Not applicable. Page 1 of 5 © 2024 Audi of America, Inc. Internal All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Production Solution Improved software for compressor electronics J1135 is planned. Service The described procedure only applies if compressor electronics with part number index A are fitted in the vehicle (affected part number 4M0.907.778.A) (Figure 1, number 30). Page 2 of 5 © 2024 Audi of America, Inc. Internal All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Figure 1. Verify that the compressor electronics is part number 4M0.907.778.A. If no irregularities are found when checking the wiring/contacts at the air compressor and compressor electronics J1135, proceed as follows: • If the DTC is passive/intermittent, delete the DTC. Page 3 of 5 © 2024 Audi of America, Inc. Internal All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin If the DTC is logged as active/static and remains active/static after the ignition is switched off and then on again, replace the control unit for compressor electronics J1135 (not the air compressor). Warranty Claim Type: • 110 Up to 48 Months/50,000 Miles. • G10 for CPO Covered Vehicles – Verify Owner. • If the vehicle is outside of any warranty, this Technical Service Bulletin is informational only. Service Number: 4316 Damage Code: 0039 Labor Operations: Check wiring between control units J775 and J1135 4316 0199 30 TU Remove and install control unit J1135 4316 19xx See SRT with associated operations GFF 0150 0000 Time stated on the diagnostic protocol Diagnostic Time: (Max 50 TU) Claim Comment: Road test prior to the service procedure No allowance 0 TU Road test after the service procedure No allowance 0 TU As per TSB 2073034/1 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. Page 4 of 5 © 2024 Audi of America, Inc. Internal All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Required Parts and Tools Always check with your Parts Department and/or ETKA for the latest information and parts bulletins. Part Number Part Description Quantity See ETKA Fasteners, Bolts, Nuts, and Screws as needed per the Repair Manual See ETKA/ELSA See ETKA Control unit for compressor electronics J1135 (if necessary) 01 Additional Information All parts and service references provided in this TSB (2073034) are subject to change and/or removal. ©2024 Audi of America, Inc. All rights reserved. The information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites without the prior expressed written permission of the publisher. Page 5 of 5 © 2024 Audi of America, Inc. Internal All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.