B660720

2/26/24, 4:47 AM
66 07 20_SERVICE ACTION: REPLACE LEFT REAR SHORT RANGE RADAR SENSOR (SRR)
SIB 66 07 20
SERVICE ACTION: REPLACE LEFT REAR SHORT RANGE RADAR
SENSOR (SRR)
2024-02-21
This Service Information Bulletin (Revision 2) replaces SI B66 07 20 dated April 2020.
What’s New:
Correction, Parts, Claim Information sections updated
Please perform the procedure outlined in this Service Information on all affected vehicles before customer
delivery. In the event the customer has already taken delivery of the vehicle, please perform the procedure
the next time the vehicle is in the shop.
☐
THIS REPAIR IS MOBILE FRIENDLY
MODEL
E-Series
Model Description
F91
M8 Convertible
G16
8 Series Gran Coupe
G20
3 Series Sedan
G30
5 Series Sedan
Production Date
From
December
3rd, 2019
To
January
31st, 2020
Affected Option
Code
5AS – Driving
Assistance
Or
5AU – Driving
Assistance
Prof
SITUATION
The functionality of the left rear SRR sensor could be reduced which would display the Driving Assistance
Check Control Message.
AFFECTED VEHICLES
Vehicles which require this Service Action to be completed will show it as “Open” when checked either in
AIR, the "Service Menu" of DCSnet (Dealer Communication System) or with ISPA NEXT.
CAUSE
The SRR sensor hardware.
CORRECTION
Replace the left side rear SRR sensor.
Note: This repair is similar to the Service Action for the same models that is described in SI B66 08 20 which
addresses the right rear SRR sensor (Repair Code 0066410100). Not every vehicle will require replacement
of both rear SRR sensors replaced. Refer to “Affected Vehicles.”
If both Service Actions show open on the vehicle, specific flat rate labor operation usage is required to
eliminate the overlap labor (See below for additional information).
PROCEDURE
Depending on the vehicle being repaired, refer to the appropriate ISTA repair instructions for removing and
replacing the left rear SRR.
For F91, G16, G20 vehicles refer to REP 66 32 180
Copyright ©2024 BMW of North America, Inc.
about:blank
1/5
2/26/24, 4:47 AM
66 07 20_SERVICE ACTION: REPLACE LEFT REAR SHORT RANGE RADAR SENSOR (SRR)
For G30 vehicles refer to REP 66 32 140
Program and code the vehicle using ISTA 4.21.3 or higher (released February 2020).
Target I-Level S15A-19-11-555 or higher
Complete all concluding work recommended at the end of ISTA programming session.
Always connect a BMW-approved battery charger/power supply (SI B04 23 10) when performing
programming.
For information on programming and coding with ISTA, refer to CenterNet / TIS / Technical Documentation /
Programming and Diagnostics / Programming Documentation.
PARTS INFORMATION
To determine the part number that applies to the specific vehicle being repaired, enter the VIN/chassis
number into either ETK or AIR, which will consider the specific equipment and/or options that are fitted to the
vehicle.
Part Number
Refer to ETK/AIR
Description
Radar sensor, close range (SRR-01)
Quantity
1
CLAIM INFORMATION
Vehicle Programming and Encoding
During this workshop visit, the affected vehicle may also show one or more programming and encoding
Technical Campaign repairs open, the programming and encoding procedure may only be invoiced one
time.
After replacing the rear radar sensor, select one of these open Technical Campaigns to perform and
submit for updating the vehicle to the required I-level or higher instead (This includes 00 00 006 or
00 00 556, 61 21 528, and 61 00 730).
Please be sure to also perform any additional before and/or after work (including attaching labels) as
required by the open campaigns on the vehicle. Close any other open programming and encoding
Campaign repairs as outlined in the corresponding Service Information Bulletin.
Based on the above, reimbursement for this Service Action will be via normal claim entry utilizing the
applicable work package information below.
Repair
Code:
0066400100
F9x G16 G2x G3x Replace left rear lateral radar sensor
Below are the special flat rate labor operation code choices for this action.
Completion before the first vehicle delivery to a customer or the vehicle is already in the workshop
Work Pkg
#1
Labor Operation Description (Plus work)
Labor Allowance
00 69 507
Replacing the left rear short range radar
sensor, program and encode the vehicle
As applicable
control units, includes Carrying out vehicle
test (00 00 556/61 21 528)
00 69 508
Replacing the left rear short range radar As applicable
sensor (Programming, and encoding the
Or:
#2
Copyright ©2024 BMW of North America, Inc.
about:blank
2/5
2/26/24, 4:47 AM
66 07 20_SERVICE ACTION: REPLACE LEFT REAR SHORT RANGE RADAR SENSOR (SRR)
vehicle control units was performed in
conjunction with another campaign/repair
during this workshop visit, excluding
Service Action RC 00 64 41 01 00/SI B66
08 20 – L/O 00 69 511)
Or:
The vehicle arrives at your center and this Service Action shows open (No other main work will be
performed or claimed during this workshop visit)
Work Pkg
#3
Labor Operation Description (Main work)
00 69 006
Labor Allowance
Replacing the left rear short range radar
sensor, program and encode the vehicle
As applicable
control units, includes Carrying out vehicle
test (00 00 006/61 21 528)
Only one Main work flat rate labor operation code can be claimed per workshop visit.
Service Action RC 00 64 41 01 00 Right Rear SRR Sensor (SI B66 08 20)
And, when this Service Action to replace the left rear SSR sensor is performed together with the Service
Action to replace the right rear SRR sensor, please refer to SI B66 08 20 for the applicable Associated labor
operation code that then applies.
Claim Repair Comments
Only reference the SIB number and the work package (Pkg) number performed in the RO technician notes
and the claim comments (For example: B66 07 20 WP 1).
BMW Group’s AIR Application Resource for Flat Rate Labor Operation Codes
To obtain the corresponding flat rate unit (FRU) allowance information from the BMW Group AIR application
resource, start by entering the Chassis Number (the last seven (7) characters of the VIN, select the
applicable Model if two or more vehicle choices show), or enter the full VIN (17 characters), click on the
“Search” button. Next, click on the “Flat Rate Units” button and enter the flat rate labor operation code in the
field to the right, click “Search” to display the Flat Rate Unit Group detail choices.
Vehicle Programming and Encoding – Additional Work (RO and Claim Comments Required)
This procedure automatically reprograms and encodes any vehicle control modules that do not have the
latest software I-level.
If one or more control modules fail during the reprogramming procedure, claim the required consequential
repair work procedures to address this issue (including performing the IRAP Control Unit Recovery first as
required, refer to the SIB in AIR) under the Repair Code in this bulletin together with the corresponding labor
operation codes and their flat rate unit (FRU) allowance(s), including the diagnosis* that applies.
Please explain the additional work procedures that were performed (The why and the what) on the repair
order and in the claim comments.
For covered repairs that address control module failures that occurred prior to performing this
reprogramming procedure, claim this work with the Repair Code listed in AIR together with the
corresponding labor operation codes and their flat rate unit (FRU) allowance(s), including the diagnosis* that
applies.
Copyright ©2024 BMW of North America, Inc.
about:blank
3/5
2/26/24, 4:47 AM
66 07 20_SERVICE ACTION: REPLACE LEFT REAR SHORT RANGE RADAR SENSOR (SRR)
(*) Based on which one applies to your center, please refer to SI B01 01 20 or B01 07 20 for the applicable
procedure for documenting, claiming, and explaining, on the RO and in the claim comments, your diagnosis
work time (WT), job/repair work time (WT), and the vehicle repairs your center performed, unless otherwise
required by State law.
And, as applicable:
Alternative Mobility Solution (AMS) for Vehicle Owners (RO and Claim Comments Required)
This Service Action repair qualifies for Alternative Mobility Solution (AMS) expense reimbursement, claim
this item under the Repair Code noted above as follows:
Sublet Code 2 - Itemize the AMS sublet amount on the repair order and in the claim comment section.
Please refer to SI B01 29 16 for additional information.
FEEDBACK REGARDING THIS BULLETIN
Technical Feedback
Warranty Feedback
Parts Feedback
To submit feedback for the technical topic of this bulletin: Submit your
feedback in the rating box at the top of this bulletin
To submit feedback for the CLAIMS section of this bulletin: Submit an IDS
ticket to the Warranty Department, or use the chat available in the
Warranty Documentation Portal
To submit feedback for the PARTS section of this bulletin: Submit an IDS
ticket to the Parts Department
Copyright ©2024 BMW of North America, Inc.
about:blank
4/5
2/26/24, 4:47 AM
66 07 20_SERVICE ACTION: REPLACE LEFT REAR SHORT RANGE RADAR SENSOR (SRR)
Copyright ©2024 BMW of North America, Inc.
about:blank
5/5