A0124132069166_4
Service Bulletin Details
Public Details for: A0124132069166_4
This repair authorization requests that technicians contact the technical assistance center in instances where dtc P044200 is stored in the ecm and the mil is illuminated.
Models from 2024
2024 AUDI Q5 |
2024 AUDI Q5 E PHEV |
Models from 2023
2023 AUDI Q5 |
2023 AUDI Q5 PHEV |
Models from 2022
2022 AUDI Q5 |
2022 AUDI Q5 PHEV |
Technical Service Bulletin 01 Repair Authorization MIL on, DTC P044200 Stored in the ECM 01 24 13 2069166/4 March 13, 2024. Supersedes Technical Service Bulletin Group 01 number 24-10 dated February 23, 2024 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment All 2.0l engine Q5, Q5 e quattro, and Q5 2022 - 2024 Sportback Condition REVISION HISTORY Revision Date Purpose 4 - Revised header (Added additional engine codes) 3 02/23/2024 Revised header (Added MY24) 2 09/12/2023 Revised Service (Updated instructions) Customer states: • MIL is on. Workshop findings: The following DTC may be stored in the ECM, -J623- (address word 0001): • DTC: P044200: EVAP Emission Control System (Small Leak) Leak Detected (Passive/Active). Technical Background Various parts have been replaced under warranty for the condition noted above, but no issues were identified with these parts. To gather information on the DTC codes for the vehicles listed above, we are asking that you contact the Audi Technical Assistance Center (TAC) before replacing any parts. This will assist us in diagnosing any potential issues with the condition noted above. Production Solution No changes to production have been made, as no issue has been identified. Service Audi of America is requesting your cooperation in supplying us with technical information regarding this condition. © 2024 Audi of America, Inc. Internal Page 1 of 2 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin • Verify the condition. • Perform EVAP testing per the ELSA Repair Manual: Engine>>Using the Evaporative Emissions tester >> 20 Fuel Supply >> Fuel System EVAP Leak Test >> EVAP System Leak Test, Vehicles with Fuel Tank Leak Detection Control Module (NVLD) >> EVAP system testing. • If no leaks are detected continue to perform the populated test plan in GFF. • Once the test plan is completed recheck the status of the DTC, if it is still static contact TAC. If it is passive/sporadic perform no repairs and release the vehicle. • If the vehicle is within the New Vehicle Limited Warranty, P044200 has been set in the past OR the fault is still static after performing the GFF test plan contact TAC before proceeding. • Please attach the DTC and diagnostic log to the TAC Web Ticket, and note the tool used to test the EVAP system for leaks. Warranty This TSB is informational only and not applicable to any Audi Warranty. Additional Information All parts and service references provided in this TSB (2069166) are subject to change and/or removal. Always check with your Parts Department and/or ETKA for the latest information and parts bulletins. Please check the Repair Manual for fasteners, bolts, nuts, and screws that require replacement during the repair. ©2024 Audi of America, Inc. All rights reserved. The information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites without the prior expressed written permission of the publisher. © 2024 Audi of America, Inc. Internal Page 2 of 2 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.