Blue Bird Tc2000 2000

• Recall 56547 [USA]: Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
  Certain 1998 through 2002 blue bird all american, tC2000 school and transit buses, and commercial series buses equipped with cummins isb diesel engines. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
  customers will be notified by cummins to bring their vehicles to an authorized dealer to have the fuel lift pump replaced free of charge. For more information, customers may contact cummins at 1-800-diesels.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 34007 [USA]: The rear of the driver's platform may not be properly retained in the event of a crash which could increase the risk of injury or death to passengers.
  Certain school buses fail to comply with the requirements of federal motor vehicle safety standard no. 221, "school bus body joint strength." one or more of the bolts attaching the driver's platform to the floor structure was omitted.
  blue bird will notify its customers and inspect and repair the affected units. Owner notification began on november 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 478-822-2242.
  also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 1790 [USA]: if this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. in the event of a crash, the seat occupant would not be properly restrained resulting in an injury.
  On certain school and transit buses equipped with passenger seat belts with retractors, the cover halves for the retractable portion of the belt can separate completely and release the seat belt connector. If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. In the event of a crash, the seat occupant would not be properly restrained resulting in an injury. The seat belt supplier, am-safe, will provide a snap on "over-cover" to owners to prevent the seat belt cover from separating.
  owners will be provided a snap-on "over-cover" to prevent the seat belt cover from separating. Owner notification is expected to begin on or about september 27, 2002. Owners who do not receive the free remedy within a reasonable time should contact blue bird at 1-478-822-2242.
  also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 1026 [USA]: The operator could place the engine switch in a position other than that intended, increasing the risk of a crash.
  Certain transit buses fail to comply with requirements of federal motor vehicle standard no. 101, "controls and displays." this standard requires specific labeling for "engine start" and "engine stop." the wording of the labels on these vehicles do not meet the requirements of the standard.
  owners will be provided with new decals and installation instructions. Owner notification began august 29, 2002. Owners who do not receive the free label and installation instructions within a reasonable time should contact blue bird at 1-478-822-2242.
  also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 3216 [USA]: Insufficient tightening permits movement between the components that could result in bolts and studs breaking, increasing the risk of a crash.
  Vehicle description: school buses equipped with hendrickson rear air suspension. Inadequate tightening of the 5/8" bolts on the rear air suspension hanger bolts and on rear axle torque arm axle seat studs.
  dealers will replace the 5/8" grade 8-hanger bolts. In addition, axle spring seat fasteners will be checked for proper tightness and, if needed, tightened to specifications. Owner notification began january 18, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-478-822-2242.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 5476 [USA]: This condition can result in power failure and/or risk of fire in the engine compartment.
  Vehicle description: school and transit buses equipped with rear mounted engines. The 12-volt power supply cable(s) may be chaffed by hoses, harnesses, frame components, or clamps.
  dealers will remove and inspect the 12-volt power cable(s) from the battery to the starter and, if necessary, will replace the cables. Owner notification began july 30, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-822-2242.
  blue bird recall no. R01ff.Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 3838 [USA]: This can cause a potential for reduced braking effort, increasing the risk of a crash.
  Vehicle description: school and transit buses equipped with a combination spicer j230 rear axle, spring suspension, and crewson brunner automatic slack adjusters. The crewson brunner slack adjuster contacts a u-bolt mounting bracket when a combination of the listed components are installed. The combination does not allow for full extension of the slack adjuster when brakes are applied.
  dealers will install modified u-bolt brackets that will provide the needed clearance. Owner notification began march 15, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-825-2021.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 6924 [USA]: Failure of the electronic control unit to detect an extreme wheel speed sensor air gap can result in the loss of antilock braking function on the wheel(s) where the air gap exists, increasing the risk of a crash.
  Vehicle description: transit and school buses equipped with meritor wabco phase 1, d-version antilock brake system (abs), fail to comply to the requirements of fmvss no. 105, "hydraulic and electric brake systems." an internal diagnostic system in the abs may not detect an extreme wheel speed sensor air gap. Such a condition could possibly occur during (1) original assembly or (2) subsequent wheel end service.
  the abs ecu will be removed and replaced or the ecu will be reprogrammed.
  owner notification began february 12, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at . Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 6845 [USA]: This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash.
  Vehicle description: school and transit buses built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
  dealers will replace the abs ecu.
  owner notification began september 5,2000.Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-825-2021. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 6468 [USA]: This condition could cause the pedal to go to full throttle if both return springs break, increasing the risk of a crash.
  Vehicle description: school and transit buses equipped with electronic engines and felsted electronic accelerator pedals. The return springs can break on the accelerator pedals that are equipped with stainless steel or electroplated music wire return springs.
  replacement accelerator pedals equipped with return springs manufactured of music wire with one additional coil on each spring and with an organic coating, eliminating electroplating will be installed.
  owner notification began august 18, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-822-2242.Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 8074 [USA]: Under certain conditions, such as parked on an incline, driver activates the parking brake but removes foot from the threadle valve, the bus could roll before the parking brake is fully engaged.
  Vehicle description: school and transit buses equipped with bendix air brakes. Bendix changed the internal design of the qr1c relay valve by adding a hole in the internal diaphragm. When the hole in the diaphragm aligns with the hole in the valve body, the brake application time increases.
  dealers will replace the diaphragms with holes with solid diaphragms for the qr1c valves.
  owner notification began june 14, 2000.Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-825-2021. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 9479 [USA]: With the brake system installed incorrectly, future maintenance might be affected by this inconsistency, causing the brakes to be installed incorrect, increasing the risk of a crash.
  Vehicle description: school and transit buses equipped with bendix abs anti-lock braking system. The primary and secondary brake treadle valve air lines were installed incorrectly at the bendix r12dc relay valve.
  dealers will correct the air line plumbing at the bendix r12dc relay valve.
  owner notification began march 8, 2000.Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-825-2021. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

While driving the bus air tank which opened doors, and air seat blew out. Dealer notified. Independent shop will fix it the bus at the school board expenses.*ak

Common OBD-II Error Codes

• C2000 [1] Manufacturer Controlled DTC