Bmw K1200lt 2004
Vehicle Details: Recalls, Investigations, Consumer Complaints, Service Bulletins
Below you will find all available information on the 2004 BMW K1200lt.
Manufacturer | Known WMI(s) | Fuel Type |
---|---|---|
BMW |
Use the box here to look up VINs from BMW as well as other manufacturers
Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.
- B611305 - ELECTRICAL SYSTEM: The electrical system of bmw vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on ho
- MC611104 - EQUIPMENT ADAPTIVE/MOBILITY: With the introduction of the new watertight fuse box a change was made from large type fuses to mini fuses. While the correct fuses are installed in the fuse box, the older, large type fuses were supplied in the on-board tool kit.
- B611305 - EQUIPMENT ADAPTIVE/MOBILITY: Discharged battery energy diagnosis must be performed: the electrical system of bmw vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This doc
- MC62133778 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Map data should be stored on a 64 gb sd card. In garmin express the note appears that a maximum of 32 gb is possible.
- SIB-63-02-01 - EXTERIOR LIGHTING: Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty. *rm
- SIB-16-02-09 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP: Bmw vehicles: fuel level sensor repairs. Where it is necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as wel
- SB-00-021-07 - FUEL SYSTEM, OTHER: Bmw motorcycle: engine fuels containing ethanol. Bmw motorrad has no objection to the use of si engine fuels containing up to a maximum of 10% ethanol and imposes no warranty restrictions. Ethanol mixtures in proportions higher than 10%
- SB-17927831-02 - SERVICE BRAKES, AIR:DISC: Bmw motorcycle: wheel speed dependent, clearly audible clanking noise occurs when braking to adjust speed. E series (k25; k25/02; k25/03; k25/11; k25/12; k25/hp; k26; k27; k28; k29; k29/hp; k40; k41; k43; k43/hv; k44; k589/03; k71). No mod
- 1300204 - ENGINE AND ENGINE COOLING:ENGINE: Engine resisting throttle input when the engine is started from cold. *tt
M/c final drive ball bearing failure investigation # DP12001
The office of defects investigation (odi) received a defect petition requesting that it open an investigation into model year (my) 1998-2009 bmw klt series motorcycles for final drive bearing failures.The petitioner asked nhtsa to issue an order that [bmw] be required to recall the affected models for inspection ofcomponent wear and proper assembly of the [final drive] bearing.Odi has reviewed the petition, assessed relevant consumer complaints, and gathered other data in the course of investigating this issue.Based on its review, odi does not believe that a safety-related defect trend currently exists for final drive bearing failures in the subject motorcycles.Therefore, in view of the need to allocate and prioritize nhtsas limited resources to accomplish the agencys safety mission, the petition is denied.However, the agency will continue to monitor information related to this issue and will take further action if warranted.For detailed information, see the federal register notice: https://federalregister.Gov/a/2013-13779.
Crash | Fire | Towed | Injured | Deaths | Failure Date |
---|
No | No | N | None | None | 20130626 |
Fuel line quick disconnect failed as vehicle slowed for stopping at intersection. Fuel under pressure from running engine was released onto the engine, the road surface and driver's right leg. No warning, sound or loss of engine power, just strong smell of gasoline until i looked down and saw the fuel wetting everything. This is apparently a common failure and is well documented on the bmwlt.Com forum, involving hundreds of these and similar model bmw motorcycles. These oem quick disconnects are made of plastic and cannot withstand common usage. Repair is commonly made with all metal parts of the same design. Fires have been reported from this failure, with total loss of the vehicle reported. I believe this to be a life-safety issue which the manufacturer is aware of, but is not acknowledging, and a recall of this part is advisable. *tr
No | No | N | None | None | 20101016 |
Bmw 2004 k1200lt motorcycle fuel line quick release fitting broke spraying fuel on me while i was driving made out of plastic and will break bmw said there is no recall this is a poor design and will happen again. *tr
No | No | N | None | None | 20080209 |
Tl*the contact owns 2004 bmw k1200lt motorcycle. The motorcycle was in a parked position when the contact observed an excessive amount of fuel leaking. The motorcycle was towed to an independent mechanic for inspection. The technician stated the failure was contributed to the fuel line. The original fuel line was made of plastic and it was replaced with a steel line. In addition, the throttle cable disengaged from the engine while traveling in traffic. There was an estimated cost of $900.00 for the motorcycle service repair. It has not been repaired . The contact had concerns of the significant safety hazard. The vin was rejected from the system. The failure mileage was 48,000. The failure mileage was 58,000. Updated 10/13/09. *lj updated 10/13/09