Dodge Caravan-ffv 2006

• Recall 83891 [USA]: If the area in question fractures or breaks, this could cause an unstable driving condition, possibly resulting in a crash.
  Curt mfg is recalling certain class 3 receiver hitches, p/n 13347, sold as aftermarket equipment for use on 1997-2007 chrysler town and country vans, 1996-2007 dodge caravans, and 1996-2004 plymouth voyager vans. When the hitch is loaded to the maximum rating, the hitch may fracture or break at the bend location where the main body of the hitch meets the hitch muffler strap.
  curt mfg will notify owners of record and will replace the hitch free of charge. The safety recall is expected to begin during august 2010. Owners may contact curt mfg at 1-715-831-8713.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 73740 [USA]: If the front crash sensors become inoperative, the driver is immediately alerted by illumination of the airbag warning light and the vehicle should be promptly serviced. until the vehicle is repaired, the airbags may not provide the enhanced protection in the event of a crash.
  Chrysler is recalling certain model year 2005-2006 dodge caravan, grand caravan and chrysler town & country vehicles originally sold in or currently registered in the states of connecticut, delaware, iowa, illinois, indiana, kansas, kentucky, massachusetts, maine, maryland, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, west virginia, wisconsin, alaska and the district of columbia. The front crash sensors may crack under certain environmental conditions and allow water to enter into the sensor. This can cause the sensor to become inoperative and illuminate the airbag warning light. These sensors were added to enhance the performance of the airbag system in certain frontal crashes.
  chrysler will replace the front airbag sensors with a new design. This service will be performed free of charge. The safety improvement campaign will begin during june 2010. Owners may contact chrysler at 1-800-853-1403.
  chrysler's campaign number is j38. Chrysler has not decided that this is a defect related to motor vehicle safety.However, chrysler has informed nhtsa that it will provide the modifications described above at no cost.

  Show Content

• Recall 78374 [USA]: Decreased lighting visibility may result in a vehicle crash.
  Eagle eyes is recalling 11,534 headlamp assemblies, p/nos. Cs090-b001l and cs090-b001r, sold for use as replacement equipment for the above listed passenger vehicles. These headlamps fail to conform to the lower beam photometry requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
  eagle eyes will notify owners and offer replacement headlamps free of charge. The recall began on september 30, 2008. Owners may contact eagle eyes at 1-800-568-1098.
  this recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by chrysler llc.Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 75030 [USA]: In the event of a vehicle crash, the occupant(s) may be seriously injured by shattered glass.
  Certain curved tempered replacement glass manufactured by hangzhou safety glass ltd and supplied to safelite by auto temp inc., identified as dot-430, and sold for use on certain domestic and foreign vehicles may not break into small pieces as expected of tempered glass and fails to conform to federal motor vehicle safety standard no. 205, "glazing materials."
  safelite will notify its retail customers and replace the glass free of charge. Retail customers can contact safelite toll free at 1-888-843-2906. Safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their customer's glass. Wholesale customers can contact safelite's wholesale division, service autoglass toll free at 1-888-246-6298. The recall began on january 15, 2008.
  this recall only pertains to certain curved tempered replacement glass manufactured by hangzhou safety glass, ltd. (dot-430) and supplied to safelite by auto temp inc., and has no relation to any original equipment installed on the vehicles listed above. Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 49954 [USA]: During certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash.
  On certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break.
  dealers will inspect and replace the windshield wiper motor free of charge. The recall began on june 19, 2006, to dodge durango owners. Minivan owners will be notified during july 2006. Owners may contact daimlerchrysler at 1-800-853-1403.
  daimlerchrysler recall no. F10.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 2019420 [Canada]: Other
  Issue: this recall is for aftermarket replacement rear window glass produced by vitro automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: this is a voluntary recall that is not being conducted under the requirements of the motor vehicle safety act. Safety risk: glass that breaks in to large pieces could create a risk of injury. Corrective actions: the company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “dot 287” along with the lettering “vmr” (replacement market) and a date code that is before july 2019. This information is printed on the bottom corner of the glass. Consumers should contact vitro's customer service at 1-412-995-6457 or [email protected] to arrange for replacement of the glass.

  Show Content

• Recall 2006058 [Canada]: Other
  On certain vehicles, the front windshield wiper motor armature shaft may break which could result in a loss of front windshield wiping capability. This could impair the driver's vision and cause a crash without warning. Correction: dealers will inspect and, if necessary, replace the front windshield wiper motor.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Engine stall after refueling investigation # DP14002

  This defect petition evaluates july 7, 2014 allegations from an owner of a model year (my) 2007 dodge grand caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioners vehicle is a chrysler rs platform minivan.The rs platform includes my 2003 through 2007 dodge grand caravan, dodge caravan, chrysler town and country and chrysler voyager minivans.Nhtsa evaluated the petition by analyzing consumer complaints submitted to the agency, analyzing field data, reviewing technical information provided in chryslers response to an agency information request and testing an rs minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, nhtsa has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the agencys view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize nhtsas limited resources to best accomplish the agencys safety mission, the petition is denied.This action does not constitute a finding by nhtsa that a safety-related defect does not exist. The agency will take further action if warranted by future circumstances. More details concerning our review can be found in the federal register notice for this action.The following 161 voqs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300
  

  Show Content

• Loss of headlight illumination investigation # EA11010

  There is no summary currently available
  

  Show Content

• Fleet vehicle recall completion audit investigation # AQ10001

  On november 18, 2010, nhtsas recall management division (rmd) opened an audit query (aq10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.Rmd queried three (3) major motor vehicle manufacturers (ford, chrysler, and general motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated documents link above.In december 2015, congress enacted the fixing americas surface transportation (fast) act.One section of the act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the fast act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
  

  Show Content

• Front air bag crash sensor failure investigation # RQ09003

  There is no summary currently available
  

  Show Content

When gas tank is full leaks from the top of tank by fuel pump. Faulty pump cracked at seam and leaks.

Driving down a crowded interstate and the dash cluster started going crazy then stopped working. Mechanic said it was a kniwn wiring issue with the cluster and anti theft device.

Driving down a crowded interstate and the dash cluster started going crazy then stopped working. Mechanic said it was a kniwn wiring issue with the cluster and anti theft device.

Passenger side air bag exploded. Luckily no injury. Vehicle was not moving. I didn't even know it could do that! I'd like this fixed. Also, two leaks in engine. Oil leak/transmission leak. Is this normal? Leaks are ongoing. Another thing: noticing headlights getting slightly dimmer, then brighter, at night as if some sort of electrical problem? This happens during driving and not driving.

Tl* the contact owns a 2006 dodge caravan. The contact stated that on several occasions the rear tail lamps, headlamps, and instrument panel lights became inoperable. The contact stated that the instrument panel lights became dim, the indicator lights and headlamps failed to operate as intended. The vehicle was taken to an unknown mechanic to be diagnosed. The contact was informed that the steering column and attached electrical switches needed to be replaced. The vehicle was not repaired. Neither a local dealer nor the manufacturer were contacted or informed of the failures. The failure mileage was 46,000.

Tl* the contact owns a 2006 dodge caravan. The contact stated that on several occasions the rear tail lamps, headlamps, and instrument panel lights became inoperable. The contact stated that the instrument panel lights became dim, the indicator lights and headlamps failed to operate as intended. The vehicle was taken to an unknown mechanic to be diagnosed. The contact was informed that the steering column and attached electrical switches needed to be replaced. The vehicle was not repaired. Neither a local dealer nor the manufacturer were contacted or informed of the failures. The failure mileage was 46,000.

Tl* the contact owns a 2006 dodge caravan. While driving, the vehicle experienced an electrical failure. The vehicle was towed to an independent mechanic who diagnosed that the fuse box malfunctioned and caused the vehicle's computer to fail. Patterson chrysler dodge jeep ram tyler (3120 s sw loop 323, tyler, tx 75701, (903) 561-2404) was contacted and confirmed the diagnosis. The manufacturer was contacted and stated that there were no recalls. The contact was referred to nhtsa and was informed to tow the vehicle to the dealer. The failure mileage was 126,000. *bf*jb

The sliding doors open as your traveling down the road.

The sliding door latch malfunction where door comes open while driving the auto lock also malfunctioning. I'm a master mechanic and this isn't the first time i heard of this problem on these vehicles. Mopar needs to have these vehicles recalled before someone gets hurt or their pet falls out.

Common OBD-II Error Codes

• P0461 [1] Fuel Level Sensor Circuit Range/Performance
• P0457 [1] Evaporative Emission Control System Leak Detected
• P0522 [1] Engine Oil Pressure Sensor/Switch Circuit Low Voltage