Dodge Grand-caravan-c-v-ffv 2003

• Recall 55811 [USA]: Power steering fluid leakage in the presence of an ignition source can result in an under hood fire.
  On certain minivans equipped with 3.3 or 3.8l v-6 engine, the upper power steering cooler hose may split and cause a fluid leak.
  dealers will replace the upper power steering cooler hose. This recall began on september 27, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
  recall no. D37.Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 62777 [USA]: A possible fire can occur in the presence of an ignition source.
  Certain aftermarket replacement fuel filters, models wix filter part numbers 33576, 33577, 33734; napa filter part numbers 3576, 3577, 3734; and carquest filter part numbers 86576, 86577, 86734 used on 1996-2000 daimlerchrysler town & country, dodge caravan, and plymouth voyager vehicles, can cause the fuel lines to leak.
  wix will notify its customers and replace the fuel filters free of charge. Note: this does not involve any products manufactured by the daimlerchrysler corp. Nor any dailmerchrysler dealers. Owner notification is expected to begin during november 2003. Owners who do not receive the free remedy within a reasonable time should contact wix at 704-864-6711.
  this recall only pertains to aftermarket replacement fuel filters and has no relation to any original equipment installed on chrysler town & country, plymouth voyager, and dodge caravan minivansor any other products manufactured by daimlerchrysler corporation.Customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 64419 [USA]: This overheating condition can cause the running board to melt or cause a fire.
  Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
  dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
  customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 2005103 [Canada]: Other
  On certain vehicles, the power lift-gate (plg) latch may become stuck in an unopened state and may not cinch on the striker during a plg closing cycle. If the operator does not observe the visual and audible indicators that the plg is not closed, the plg may rise during typical low speed driving manoeuvres. Correction: dealers will replace the power lift-gate module.

  Show Content

• Recall 2004276 [Canada]: Steering
  On certain minivans equipped with a 3.3l or 3.8l engine, the upper power steering cooler hose could split, causing a fluid leak. Power steering fluid leakage in the presence of an ignition source can result in an underhood fire. Correction: dealers will replace the upper power steering hose.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Engine stall after refueling investigation # DP14002

  This defect petition evaluates july 7, 2014 allegations from an owner of a model year (my) 2007 dodge grand caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioners vehicle is a chrysler rs platform minivan.The rs platform includes my 2003 through 2007 dodge grand caravan, dodge caravan, chrysler town and country and chrysler voyager minivans.Nhtsa evaluated the petition by analyzing consumer complaints submitted to the agency, analyzing field data, reviewing technical information provided in chryslers response to an agency information request and testing an rs minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, nhtsa has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the agencys view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize nhtsas limited resources to best accomplish the agencys safety mission, the petition is denied.This action does not constitute a finding by nhtsa that a safety-related defect does not exist. The agency will take further action if warranted by future circumstances. More details concerning our review can be found in the federal register notice for this action.The following 161 voqs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300
  

  Show Content

• Power liftgate latch investigation # EA04031

  This investigation was opened as pe04-054 regarding reports of alleged power liftgate (plg) opening while driving.The investigation was upgraded on november 22, 2004 based on information provided by daimlerchrysler corporation (dcc) in its september 17, 2004 response to pe04-054. By letter of april 5, 2005, dcc has notified the agency that it will conduct a safety recall of 70,235 model year (my) 2003 chrysler town & country and dodge grand caravan vehicles equipped with the plg option.Dcc has identified a problem in early production my 2003 plg control modules that can prevent the plg door from latching closed in a power open/close cycle.In this condition the plg can rise (not power open) during vehicle operation.Dealers will install a revised plg control module to remedy the affected vehicles.See safety recall 05v134 for details.
  

  Show Content

Tl* the contact owns a 2003 dodge grand caravan. While driving, the steering wheel became difficult to turn to the right. The vehicle was examined by an independent mechanic who diagnosed that the clockspring pin was fractured and caused the failure. The local dealer and manufacturer were not notified of the failure. The failure mileage was 367,000.

There are two problems that are very serious. First, in 2017 as i was exiting the interstate, i drove through a puddle. As i attempted to turn left onto the road, my steering wheel locked and it was only with extreme force and slamming on the brakes that i kept from running through the guardrail, and dropping down to the interstate below. I was unable to make the turn and stopped on the overpass until my steering wheel unlocked. Yes, my engineer husband keeps up with all of our regular maintenance, including the belts. Next, with an unusually heavy rain this past week, my battery light came on. After parking for an hour, my steering wheel would not turn when i attempted go again. I restarted the car five times before the steering unlocked. All week, during that heavy rain, the steering locked regularly. These problems are all over the web. Women and children everywhere are in danger of dying from something that should have been recalled years ago. Why is there no recall for this problem? If you are refusing to do anything about this, then you are eligible for being sued along with chrysler, for allowing this to continue uncorrected.

Tl* the contact owns a 2003 dodge grand caravan. While accelerating from a stop, the vehicle stalled without warning. The contact was able to coast the vehicle to the side of the road and powered off the engine. The vehicle failed to restart and was towed to the contact's residence. The vehicle was not taken to a dealer or an independent mechanic for diagnostic testing or repairs. The manufacturer was not contacted. The approximate failure mileage was 238,000.

The passenger side seat belt warning light turns on even when there is no one in that seat and the passenger side seat belt releases when there is someone in the seat! Adults and older children have put the seat belt in place but the warning light stays on. While driving or sitting still, the seat belt will release at random, causing the passenger to have to click it into place again. When the passenger clicks the seat belt in place and pulls on it, it either stays in position or releases. If it stays in position, then while driving and or parked, the seat belt will suddenly release. When the driver had to step harder on the brake to avoid a driver who stopped suddenly, the seat belt released yet at other times, the seat belt remains in place. It doesn't matter whether or not the van is in gear or parked, or if we're stopped, moving, highway driving or city driving, the seat belt will release at random times. This had happened multiple times since we bought the vehicle, sometimes multiple times in one trip. Other times it doesn't happen at all. The date given is the most recent time that it released on its own. I had been parked and then was backing out of a parking space when my daughter's seat belt (passenger side) released on its own. I stopped and put the van in park then had her click in place again. We both pulled on it and since it didn't release, we continued our trip, praying that it wouldn't disconnect again while we were driving.

Tl* the contact owns a 2003 dodge grand caravan. While driving 65 mph, the sun roof exploded without warning while the cover was closed. There were no injuries. The vehicle was not diagnosed or repaired. The local dealer (century dodge chrysler jeep ram, 13500 veterans memorial pkwy, wentzville, mo 63385) was called and stated that there were no open recalls on the vehicle. The manufacturer was not notified of the failure. The failure mileage was unknown.

Tl* the contact owns a 2003 dodge grand caravan. While driving from the gas station at 5 mph, the brakes failed to work without warning. The contact also noticed smoke coming from the front of the vehicle. The vehicle was taken to an independent mechanic on highway 52 in florida where it was diagnosed that the frame that held the motor needed to be replaced. The vehicle was not diagnosed or repaired. The manufacturer was not contacted and was not aware of the failure. The approximate failure mileage was 98,000.

Transmission

During a march 2016 road trip to atlanta, ga, from michigan, while traveling about 65 mph on i-75, temperature gauge needle began to climb toward the red zone on the instrument dial. Within minutes i pulled off onto a highway construction site where i stopped the vehicle and turned off the ignition switch. Opening the hood, i began to investigate the problem(s). Cool upper radiator hose. Cool radiator cap. Turned cap off and discovered no coolant in radiator. No apparent source of leaking. Added ice water from ice chest to radiator hoping to locate source of leak. Turned engine on and located leak beneath passenger side of vehicle: two small holes in corroded exposed steel tubing routing coolant to rear heater assembly in rear of van. The next day discovered that chrysler had changed the part from steel to aluminum in late 2000's to help prevent the corrosive action of road salt in the northern climates that had affected many similar vehicles during the mid-2000's. However, daimler chrysler chose not to institute a recall of the faulty designed part fully exposed beneath the vehicle. The cost of replacing the part at the dealership in stone mountain, ga, was around $650.00 usd, not a huge sum, but obviously not cost-efficient for the automaker and its shareholders. This problem could be life-threatening if the driver and passengers were stranded during the winter months in northern u.S. Or canada, when loss of all coolant occurred. Operating vehicle with no coolant could result in the engine seizing up while traveling at highway speeds, causing injury to driver and passengers and possibly other motorists. A dangerous situation that chrysler has corrected on its later model vehicles since 2010 or 2011.

Takata recall, my can has had some serious safety electrical issues for quite some time now.I've had many dangerous situations. With this can one thing after the next. I'm not sure exactly the problem but something the power control modual or wiring harness is not ok. The radiator fans didn't work as well as the power controls windows,heat,ac,radio, and the wipers ect.There is sparking coming from the car. Wires had started to catch fire. As well as the car overheating.

Common OBD-II Error Codes

• P1776 [1] Torque Converter Clutch Circuit Malfunction