Fleetwood Expedition 2005
Vehicle Details: Recalls, Investigations, Consumer Complaints, Service Bulletins
Use the box here to look up VINs from FLEETWOOD as well as other manufacturers
-
Where is the 2005 FLEETWOOD Expedition produced?
- The 2005 FLEETWOOD Expedition is produced in Decatur Indiana, United States (usa).
-
Are there recalls for the 2005 FLEETWOOD Expedition?
- There are 4 recall(s) for the 2005 FLEETWOOD Expedition, additional information is below.
Recall 81261 [USA]: If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
Recall 54972 [USA]: The weight label on the hitch receiver provides the maximum trailer weight rating and the maximum tongue weight rating. it is important that these ratings not be exceeded. failure to comply could result in damage to the motor home frame, body, or hitch receiver and could cause unstable driving and handling characteristrics which may result in a vehicle crash.
Recall 2008246 [Canada]: Other
Recall 2005227 [Canada]: Label
To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.
Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.
- No comms 2023-06 - UNKNOWN OR OTHER: There are no manufacturer communications in accordance with 49 cfr 579.5 to report for june 2023 for rev recreation group.
- No comms 2023-03 - UNKNOWN OR OTHER: There are no manufacturer communications in accordance with 49 cfr 579.5 to report for march 2023 for rev recreation group.
- No comms 2021-11 - UNKNOWN OR OTHER: There are no manufacturer communications in accordance with 49 cfr 579.5 to report for november 2021 for rev recreation group.
- No comms 2021-07 - EQUIPMENT: There are no manufacturer communications in accordance with 49 cfr 579.5 to report for july 2021 for rev recreation group.
- No comms 2021-04 - EQUIPMENT: There are no manufacturer communications in accordance with 49 cfr 579.5 to report for april 2021 for rev recreation group.
Inadvertent slide-out extension movement investigation # PE06005
This investigation was opened based on odis receipt of a congressional letter on behalf of a constituent.The constituent reported incidents where the "slide out" room of his motor home would inadvertently move (extend) during highway use.Odi was concerned that a fully extended slide out would degrade the vehicles dynamic handling characteristics and/or possibly impact an object or another vehicle, resulting in a crash.Odi contacted fleetwood and discovered that slide out rooms were installed in motor homes, travel trailers and folding trailers. As part of the investigation odi visited a rv show and the fleetwood paxinos plant to examine "slide outs" in various new make and model vehicles and gain an understanding of how the systems work.During the investigation odi learned that there are two methods used to extend slide out rooms.Some manufacturers use hydraulic systems and others, such as fleetwood, use an electric motor. (continued on page 2)
[pdf]
User Manual Owner's Manual Instructions Specifications Guide Application Guide Diagram
Autocraft Carquest Application Guide Auto Parts Table of contents Untitled Refer to the vehicle owner s manual for other specific information Allstate Chrysler Crosley Ford Frazer Nash GM Henry J Hudson Jeep Be sure vent caps are tight and level Make certain that vehicles not touching both ignition switches turned OFF position 1 Connect positive booster cable terminal discharged battery CQ BatteryApplicationGuide 2015 16 carquestprofessionals batteries TABLE OF CONTENTS Table of Contents OPTIMA Battery Product Line AutoCraft / CARQUEST AGM Battery Product Line AutoCraft / CARQUEST Flooded Battery Product Line AutoCraft / CARQUEST Marine Battery Line AutoCraft / CARQUEST Specialty Battery Product Line Safety Information Battery Replacement Data ... lang:en score:23 filesize: 24.78 M page_count: 440 document date: 2019-05-15 |
Crash | Fire | Towed | Injured | Deaths | Failure Date |
---|
No | No | N | None | None | 20210508 |
Dual pane window seals rupture and dual pane windows become foggy and stained making visibilty terrible and unsafe. Especially can't see your mirrors. According to forums it appears to be a very common problem among fleetwood products.
No | No | N | None | None | 20160501 |
All se-gi made windows fogging up making it very dangerous; very hard to see.
No | No | N | None | None | 20150917 |
Tl* the contact owns a 2005 fleetwood expedition. While driving various speeds, the driver and passenger side windows retained moisture and caused a glare due to the sunlight. The failure occurred constantly. The motor home was not diagnosed nor repaired. The defogger feature failed to rectify the failure. The manufacturer was made aware of the failure. The vin was invalid. The failure mileage was approximately 25,000.
No | Fire | N | None | None | 20131011 |
While driving my fleetwood motorhome, i noticed an electrical odor. I looked toward the back of the coach and the rear bedroom was full of smoke. When i finally got the coach to a service center, it was determined that the exhaust system had a hole in it near the engine. The coach only had 32000 miles. The heat from the engine through the exhaust heated the electrical control box that is immediately adjacent to the engine, the coating on the wiring melted and that resulted in an electrical fire. I feel that there is a major design flaw that could result in bodily injury or death. *tr
No | No | N | None | None | 20121207 |
In the middle of the night in one place that i didn't have any light just the cars passing i had to stop because the engine failsafe mode was on. I stop to read the manual for to know what i have to do? After 20 min without leaving the car because i was alone i start driving again so slow to my house. *tr
No | No | N | None | None | 20110214 |
Driver's side window fogged up because seal to thermal pane failed causing reduced vision to left side mirror on the coach. This creates a safety hazard because one is unable to see traffic out left mirror especially when sun is shining just right that creates a glare in the mirror.
No | No | N | None | None | 20081206 |
Tl* the contact owns a 2005 fleetwood expedition diesel rv. While driving approximately 55 mph, the contact noticed that the seals on the three windows on the driver side had failed causing air to seep into the vehicle through the windows. The contact stated that all the windows in the vehicle had the same failure except for the windshield. This also caused the window panes to become foggy and turn blue, making visibility difficult for the contact. The manufacturer was contacted and offered no assistance. The company was taken over by new owners who advised that they would not be able to assist the contact with any repairs. The failure mileage was 28,000 and the current mileage was 31,000.
No | No | N | None | None | 20070604 |
Our drivers side window is so fogged that it is extremely dangerous for us to drive it .Others have the fog as well, i am just disgusted with the fact it is now so dangerous. I understand from other websites this has been a common problem with these windows. I do not understand with the price of these rv's how fleetwood would continue to use such defective windows and actually think the public will return to purchase another fleetwood product. *tr
No | No | N | None | None | 20070604 |
Tl*the contact owns a 2005 fleetwood expedition. The contact stated that the insulated window seals were defective. There was moisture seeping through the panels, which caused the windows to become excessively foggy. The contact's visibility was reduced. The vehicle was taken to the authorized dealer and they stated that the failure was related to the seal leakage. The vehicle has not been repaired. The vin was unknown. The failure mileage was 20,000 and current mileage was 26,000.