Use the box here to look up VINs from FLEETWOOD as well as other manufacturers
Frequently Asked Questions
Are there recalls for the 2004 FLEETWOOD Flair?
- There are 11 recall(s) for the 2004 FLEETWOOD Flair, additional information is below.
NHTSA Mandated Recalls
Recall 84584 [USA]: The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
Fleetwood is recalling 509 my 2001-2008 class a motor homes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver. dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign please see 09v-110. The manufacturer has not yet provided an owner notification schedule. Owners may contact workhorse at 1-877-246-7731. Workhorse will conduct the owner and dealer notification. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .
Recall 81212 [USA]: If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. fleetwood is working with dometic to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.
Recall 45851 [USA]: Release of coolant under certain conditions could ignite and result in a fire.
Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. fleetwood will be working with dometic in order to repair these refrigerators (please see 06e076). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.
Recall 37079 [USA]: In the presence of an ignition source, a fire could result.
On certain motor homes built on workhorse chassis and equipped with general motors 8.1l v8 engines, improper hardening during the heat treatment process can cause the fuel rail pulse damper retainer clip to fracture, resulting in inadequate retention of the damper. If the damper becomes loose, fuel could be pumped by the fuel pump into the under hood area. workhorse is handling the owner notification and remedy for this campaign (please see 06v225). Dealers will replace the fuel rail pulse damper retainer clips on these engines free of charge. Owners may contact workhorse at 877-294-6773 or fleetwood at 1-800-322-8216. customers can also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.
Recall 36969 [USA]: At night the instrument cluster lights may fail and the driver may not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash.
Certain motor homes built on workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard no. 101 "controls and displays" and no. 105 "hydraulic and electric brake systems." if the brake fail input falls below a voltage of 1.5v, the brake failure lamp and alarm will be activated. Also activation of the abs telltale when the abs is not properly functioning does not always occur. workhorse is conducting the owner notification and remedy for this campaign and reprogram the instrument panel cluster free of charge. Owners may contact workhorse at 1-877-246-7731 or fleetwood at 1-800-322-8216. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.
Recall 41505 [USA]: The welds could break, allowing the hitch receiver box and the towed load to separate from the towing vehicle, increasing the risk of a crash.
Certain motor homes equipped with draw tite hitch receivers may be missing one or more welds between the hitch receiver box and the bottom support plate. dealers will inspect and replace the hitch receiver. The recall is expected to begin during august 2004. Owners should contact fleetwood at 1-800-322-8216. fleetwood recall no. 40715.Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Recall 33301 [USA]: An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.
On certain travel trailers equipped with samsung microwave ovens, these ovens were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads. samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or fleetwood at 1-800-629-8454. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Recall 2008246 [Canada]: Other
On certain motorhomes, conventional travel trailers and fifth wheel travel trailers equipped with a dometic corporation refrigerator, a fatigue crack can develop in the boiler tube. This could allow the release of pressurized coolant solution into an area where an ignition source is present, which could result in a fire. Correction: dealers will install a secondary burner housing.
Recall 2007047 [Canada]: Other
On certain motorhomes, conventional travel trailers and fifth wheel travel trailers equipped with a dometic corporation refrigerator, a fatigue crack can develop in the boiler tube. This could allow the release of pressurized coolant solution into an area where an ignition source is present, which could result in a fire. Correction: dealers will replace the refrigerator's boiler tube assembly.
Recall 2006208 [Canada]: Fuel supply
On certain motorhomes equipped with workhorse custom chassis, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of the damper. If the damper comes loose, a fuel leak may result in the underhood area which may result in a fire. Correction: dealers will replace the engine fuel rail pulse damper retainer clip.
Recall 2004264 [Canada]: Other
On certain vehicles, the draw tite brand hitch receiver may be missing one or more welds that would normally exist between the hitch receiver box and the bottom support plate. During use, forces may be applied that could cause the existing welds to break and the hitch receiver box and towed load to separate from the towing vehicle, which could result in a crash. Correction: dealers will inspect the hitch receiver, and if any welds are missing, will replace it.
To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.
Bulletins
Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.
0251 - ENGINE AND ENGINE COOLING:ENGINE: Air intake baffle procedure/installation which may be susceptible to stalling or sputtering during heavy rains or when water is sprayed directly at the front end. The check engine light may illuminate also. Various models including fleet
Known Recall Investigations
Inadvertent slide-out extension movement investigation # PE06005
This investigation was opened based on odis receipt of a congressional letter on behalf of a constituent.The constituent reported incidents where the "slide out" room of his motor home would inadvertently move (extend) during highway use.Odi was concerned that a fully extended slide out would degrade the vehicles dynamic handling characteristics and/or possibly impact an object or another vehicle, resulting in a crash.Odi contacted fleetwood and discovered that slide out rooms were installed in motor homes, travel trailers and folding trailers. As part of the investigation odi visited a rv show and the fleetwood paxinos plant to examine "slide outs" in various new make and model vehicles and gain an understanding of how the systems work.During the investigation odi learned that there are two methods used to extend slide out rooms.Some manufacturers use hydraulic systems and others, such as fleetwood, use an electric motor. (continued on page 2)
Tl*the contact owns a 2004 fleet wood flair31af motor home (rv). The contact was driving at speeds of 35 mph when the steering wheel began to shake excessively. The contact found that the frame bolts which separated the frame bolts from the chassis had fractured. The vehicle was driven to a local repair facility where the bolts to the chassis were replaced. The manufacturer was not contacted. The failure mileage was 75,301 and the current was unknown. Updated 8/25/10 *cn the consumer stated both of tires were defective. Updated 08/27/10