Ford E-250 1998

• Recall 67384 [USA]: A vehicle fire could occur with or without the engine running.
  Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
  ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009. Owners may contact ford at 1-888-222-2751.
  ford's recall campaign number is 09s09.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 75756 [USA]: As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
  Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. The affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
  dealers will install a new wiring harness, or replace the mating electrical component. The recall began on february 18, 2008. Owners may contact ford at 1-800-392-3673.
  ford recall no. 08s01.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 90341 [USA]: This could result in an underhood fire.
  On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
  dealers will install a fused wiring harness. Owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. As soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. The recall began on august 13, 2007, and mailing completed by september 19, 2007. Owners may contact ford at 1-888-222-2751.
  ford recall no. 05s28.Customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 55926 [USA]: In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries to a wheelchair occupant.
  On certain vans equipped with sure-lok wheelchair securement systems, the sprocket teeth of the retractor assembly is out of alignment.
  dealers will inspect and replace the wheelchair securement retractors as necessary. Sure-lok will handle the repairs for this campaign. Owners should contact sure-lock at 1-908-231-1804 or mobilityworks at 1-800-769-8267.
  sure-lok recall no. 04e-058.Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 6524 [USA]: These vehicles do not comply with the requirements.
  Vehicle description: bi-fuel cng pickup trucks and bi-fuel cng vans, modified by cfi control systems, inc., fail to conform to the requirements of fmvss no. 303, "fuel system integrity of compressed natural gas vehicles." the label affixed to the fuel filler door by the vehicle modifier contains the inspection date and expiration date of the cng tank. However, it does not contain the statement "see instructions on the fuel container for inspection and service life."
  owners will be provided a label with the required statement, along with instructions for affixing the label at the fuel filler door. Owner notification began november 2, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 2009292 [Canada]: Other
  On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: dealers will install a new switch or fused wiring harness. Note: this is an expansion of recall 2005028 (05s28) for vehicles not previously included in the campaign.

  Show Content

• Recall 2008038 [Canada]: Electrical
  On certain vehicles, a wiring harness that is not compatible with the vehicle circuit polarity may have been inadvertently installed during servicing for recall 2005028 or 2007258. As a result, the fuse is located in the output circuit rather than in the input power feed circuit, and will not offer the intended protection in the event of an electrical short to ground. This could result in a vehicle fire, causing property damage and/or personal injury. Correction: dealers will install an updated wiring harness.

  Show Content

• Recall 2007258 [Canada]: Electrical
  On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The failure mode appears to be different than that of recall 2005028 (05s28). This time, the concern is with long term durability performance issues causing the switch to fail. Correction: initially as an interim repair, owners will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. As soon as replacement parts are available, owners will be instructed to return to the dealers for installation of a fused wiring harness designed to eliminate the potential risk of fire.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Hvac switch failures investigation # EA10003

  This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.Odi was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.After a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, odi did not identify the existence of a safety defect trend.Odi reviewed 1,036 complaints, claims, and field reports of failed blower motor control switches and determined that only two fires were likely to have been caused by a failing subject blower motor control switch.This represents a failure rate of 0.2 r/100k on a population of 1,076,975 vehicles that have been in service for up to 14 years.Odi has found that when the subject switches do fail and begin to melt, they are constructed in a manner that typically prevents the failing switch from igniting and developing into an open flame.Ford motor company has agreed to take two actions to further reduce the likelihood an overheated blower motor switch in the subject vehicles.Ford informed odi that it has implemented a series of design changes to the subject switch that will help prevent it from developing internal high resistance short circuits.Ford has also informed odi that it would release a technical service bulletin (tsb-11-11-21) instructing subject vehicle owners to replace the electrical connector at the same time a failed switch is replaced.In light of the low rate of failure resulting in open flame and fire spread on the subject vehicles, and fords actions to reduce the likelihood of a switch failure through switch design changes and a tsb, further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.The agency reserves the right to take further action if warranted by the circumstances.The odi complaints cited above can be reviewed at www-odi.Nhtsa.Dot.Gov/owners/searchnhtsaid under the following (odi) numbers: 10427875, 10114393, 10257890for additional information, see the attached closing report.
  

  Show Content

• Spark plug ejection from cylinder head investigation # DP05005

  On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.Odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.As of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.In addition, odi is aware of only two incidents where the vehicle stalled without restart.Information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.In the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.In one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.In another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.None of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.As the petitioner noted, and odi¿s analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles.However, odi¿s analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences.None of these showed any evidence of a serious safety consequence.Given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low.In view of the foregoing, it is unlikely that nhtsa would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition.Therefore, in view of the need to allocate and prioritize nhtsa¿s limited resources to best accomplish the agency¿s safety mission, the petition is denied.
  

  Show Content

1998 ford econoline van 5.4l eng. Abs brakes: while applying brakes, the brake pedal responds with forceful back pressure to prohibit brakes from operating. Operator then exerts excessive pressure to force braking, still yet vehicle brakes very sluggishly. Operator notes that when the condition occurs, if he releases then re-applies brake pedal pressure the brakes tend to grab and try to lock up. Operator has taken the van in for service, replaced the speed sensor on rear diff, problem went away for 2 days recurring there after. Shop mgr states that the problem could be a dump valve causing malfunction. Still investigating problem. Vehicle mfr has recently sent a recall notice identifying desc # 09s09, speed control system modification. Operator will be scheduling the service. More to follow on this subject. Problem has been noted and continues to this day, dec 28 2010

Spark plug blew out of head with threads in my 98 e250 with 92,000 well maintained miles on it. The cost is yet to be determined. *tr

I received a recall notice to install a fused wiring harness for my brake light switch. I took it to the dealer in august and had the work done. Now i have received another recall notice which states that fomoco "has decided that a defect which relates to motor vehicle safety exists in a fused jumper harness the was installed in your vehicle when it was serviced." this appears to be a recall of the harness that was installed as part of the first recall. I called the local ford dealer and they were unaware of a second recall and said they had been waiting for months for the harnesses required for the first recall. Since i still didn't know if there was a second recall i called fords toll free number and explained the situation. I was told to call the local dealer and give them my vin number. I have not done this yet since i already called them and didn't get an answer. This sounds like a very serious problem and i would like a correct answer. Thanks. If they don't have the harnesses how can they do the repairs? Why are they not aware of the second recall? Why are the recalls not found on your nhtsa website? *tr

Ford econoline e250 hd - 1998 extended model; column gear shift will shift from park to gear without it going into gear and from gear to park without vehicle going into park but staying in gear. *jb

While driving 65 mph spark plug blew out. Vehicle was towed to dealer, and problem was repaired. *ak

While driving 30 mph, the spare tire cable broke. As a result the spare tire flew twenty-five feet in the air. No collision reported. Please provide additional information. *jb

Rear door was not installed properly on my 1998 chinook motor home. This improper installation has resulted in extensive internal damage and left me without a safe closure for the vehicle. It was presented for repair and the dealer failed to make proper repairs to repair this poor factory installation. Both the manufaturer and dealer are not accepting responsibility for this structural failure that could result in people being ejected from the vehicle. Ts

While trying to switch lane steering went out.*ak

Consumer states this vehicle is experiencing problems with this vehicle similar to those stated in tsb 99-20-7. *slc

Common OBD-II Error Codes

• P0300 [2] Random/Multiple Cylinder Misfire Detected
• P0308 [2] Cylinder 8 Misfire Detected