Ford E250 1997

• Recall 67383 [USA]: A vehicle fire could occur with or without the engine running.
  Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
  ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009. Owners may contact ford at 1-888-222-2751.
  ford's recall campaign number is 09s09.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 75755 [USA]: As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
  Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. The affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
  dealers will install a new wiring harness, or replace the mating electrical component. The recall began on february 18, 2008. Owners may contact ford at 1-800-392-3673.
  ford recall no. 08s01.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 90340 [USA]: This could result in an underhood fire.
  On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
  dealers will install a fused wiring harness. Owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. As soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. The recall began on august 13, 2007, and mailing completed by september 19, 2007. Owners may contact ford at 1-888-222-2751.
  ford recall no. 05s28.Customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 55925 [USA]: In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries to a wheelchair occupant.
  On certain vans equipped with sure-lok wheelchair securement systems, the sprocket teeth of the retractor assembly is out of alignment.
  dealers will inspect and replace the wheelchair securement retractors as necessary. Sure-lok will handle the repairs for this campaign. Owners should contact sure-lock at 1-908-231-1804 or mobilityworks at 1-800-769-8267.
  sure-lok recall no. 04e-058.Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 2009292 [Canada]: Other
  On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: dealers will install a new switch or fused wiring harness. Note: this is an expansion of recall 2005028 (05s28) for vehicles not previously included in the campaign.

  Show Content

• Recall 2008038 [Canada]: Electrical
  On certain vehicles, a wiring harness that is not compatible with the vehicle circuit polarity may have been inadvertently installed during servicing for recall 2005028 or 2007258. As a result, the fuse is located in the output circuit rather than in the input power feed circuit, and will not offer the intended protection in the event of an electrical short to ground. This could result in a vehicle fire, causing property damage and/or personal injury. Correction: dealers will install an updated wiring harness.

  Show Content

• Recall 2007258 [Canada]: Electrical
  On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The failure mode appears to be different than that of recall 2005028 (05s28). This time, the concern is with long term durability performance issues causing the switch to fail. Correction: initially as an interim repair, owners will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. As soon as replacement parts are available, owners will be instructed to return to the dealers for installation of a fused wiring harness designed to eliminate the potential risk of fire.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Hvac switch failures investigation # EA10003

  This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.Odi was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.After a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, odi did not identify the existence of a safety defect trend.Odi reviewed 1,036 complaints, claims, and field reports of failed blower motor control switches and determined that only two fires were likely to have been caused by a failing subject blower motor control switch.This represents a failure rate of 0.2 r/100k on a population of 1,076,975 vehicles that have been in service for up to 14 years.Odi has found that when the subject switches do fail and begin to melt, they are constructed in a manner that typically prevents the failing switch from igniting and developing into an open flame.Ford motor company has agreed to take two actions to further reduce the likelihood an overheated blower motor switch in the subject vehicles.Ford informed odi that it has implemented a series of design changes to the subject switch that will help prevent it from developing internal high resistance short circuits.Ford has also informed odi that it would release a technical service bulletin (tsb-11-11-21) instructing subject vehicle owners to replace the electrical connector at the same time a failed switch is replaced.In light of the low rate of failure resulting in open flame and fire spread on the subject vehicles, and fords actions to reduce the likelihood of a switch failure through switch design changes and a tsb, further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.The agency reserves the right to take further action if warranted by the circumstances.The odi complaints cited above can be reviewed at www-odi.Nhtsa.Dot.Gov/owners/searchnhtsaid under the following (odi) numbers: 10427875, 10114393, 10257890for additional information, see the attached closing report.
  

  Show Content

• Spark plug ejection from cylinder head investigation # DP05005

  On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.Odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.As of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.In addition, odi is aware of only two incidents where the vehicle stalled without restart.Information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.In the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.In one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.In another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.None of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.As the petitioner noted, and odi¿s analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles.However, odi¿s analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences.None of these showed any evidence of a serious safety consequence.Given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low.In view of the foregoing, it is unlikely that nhtsa would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition.Therefore, in view of the need to allocate and prioritize nhtsa¿s limited resources to best accomplish the agency¿s safety mission, the petition is denied.
  

  Show Content

• Shift-lock investigation # PE99022

  There is no summary currently available
  

  Show Content

Tl* the contact owns a 1997 ford e-250. While driving at approximately 55 mph, the fan switch that controls the fan speed melted and burned. The contact coasted to the side of the road, pulled the cover for the dashboard, and removed the wires that were connected to the switch. The vehicle was taken to an independent mechanic who stated that the burned wires switch needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 236,092.

Spark plug ejection. Possible fire hazard. *tr

Ford motor company has failed to provide the necessary service to remedy the cruise control recall specified in odi id number : 10056190. I have contacted the dealerships in asheville, north carolina & black mountain, north carolina monthly since i was advised of the recall august, 2007. Each time i have been told that the repair kit is unavailable from ford. *tr

Spark plug ejected from cylinder head and repeatedly struck pressurized fuel rail. *jb

Ford econoline ( 25v) 1997, engine burst into flames while driving. *bf prior to the fire the consumer had other work performed on the vehicle. The alternator was replaced, the overdrive light was on and it was difficult to shift into 2nd gear. The consumer wanted to know if the fire had anything to do with the faulty cruise control switch that are in ford vehicle. *jb

Heater temp control fails. *ak

Blown spark plug right out of the head, took the threads with it costing over $3000.00 ford will not except responsability for there negligence in there machine shop can you help?

Cruise control failure, engine sped up, loss of brakes

Steering box failure. Set screw on race nut backed out causing gear race nut to completely back out causing gear input shaft to move and bind on gear valve housing. This caused my steering to lock up to the right and force me off the freeway at 45 mph.

Common OBD-II Error Codes

• P0300 [3] Random/Multiple Cylinder Misfire Detected
• P0308 [3] Cylinder 8 Misfire Detected