Freightliner Fld120 2006

• Recall 88493 [USA]: There is a possibility that the fifth wheel may fail to latch without the driver's knowledge. when the occurs, the driver could drive away and the trailer could become disengaged increasing the risk of a crash.
  On certain truck-tractors equipped with holland simplex se or se ii fifth wheels, the latch lever pivot bolt assembly may have been over-tightened which could distort the pivot bolt spacer sleeve. Corrosion or contaminates in the pivot may cause it to bind and prevent the fifth wheel jaw from latching securely around the trailer king pin.
  dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer. The recall began on january 3, 2008. Owners may contact freightliner at 1-800-547-0712.
  freightliner recall no. Fl-514.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 89142 [USA]: These conditions could either result in leakage and cause a delay in the application of the spring brake without warning or possibly lead to unintended vehicle rollaway or brake drag which could result in a vehicle crash, personal injury, or death.
  Certain freightliner school bus chassis, heavy trucks, and thomas built school buses manufactured between july 2002 and july 3, 2007, equipped with bendix sr-7 spring brake control valves. The parker scv brass 90 degree single check valves (scv) which attach to the supply port of a bendix sr-7 spring brake modulating valve can break apart. Pieces of the parker scv can become lodged inside the sr-7 spring brake modulating valve, potentially causing either leakage out of the sr-7 valve or preventing air from properly exhausting from the sr-7 valve. Also, due to a manufacturing defect in the internal rubber check valve inside the sr-7 spring brake modulating valves, the valves can become deformed and not seat properly.
  freightliner will notify owners and repair the vehicles free of charge. The recall began on january 11, 2008 to freightliner, sterling, and freightliner custom chassis owners; to thomas built bus owners on february 1, 2008. Owners can contact freightliner at 1-800-547-0712.
  freightliner recall no. Fl-504.Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 2007231 [Canada]: Brakes
  On certain vehicles, the internal rubber check valve inside the bendix sr-7 spring brake modulating valve can become deformed over time. The effect of this defect is intermittent and presents a potential delay or failure in applying the parking brakes; potentially resulting in a vehicle roll away. Should this occur, the unattended roll away vehicle could strike a bystander or cause property damage. Correction: dealers will install a check valve repair kit.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

• Insecure fifth wheel latching investigation # PE07047

  On november 19, 2007, freightliner filed defect report 07v-530 which outlines a safety recall program to notify the affected owners and correct the affected vehicles.
  

  Show Content

Check engine light came on then tractor starting loosing power. Took to w.W. Williams detroit diesel. They found delta p sensor out of calibration. V-pod cutting out, turbo had excessive play in vnt. They replaced the v-pod which was under warranty. The same problem occurred in march 2013. Problems. Check engine light came on, low power, back fires, puffs black smoke. Oil leak by turbo. Ww williams stated cause as bad v-pod, turbo drain line. Ww willliams found v-pod cutting out and replaced v-pod again under warranty, turbo drain lined replaced. Same problem again on 5/27/13 check engine light came on again, loosing power. Took back to ww williams, they stated code 39 came up, bad injectors. Replaced all injectors, not under warranty. Replaced v-pod again, under warranty. *tr