Honda Passport 2001

• Recall 79114 [USA]: Excessive corrosion may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash.
  Isuzu is recalling certain model year 1998-2002 isuzu rodeo and model year 2002 isuzu axiom vehicles, and honda is recalling certain 1998-2002 honda passport vehicles, that were originally sold, or are currently registered, in the states of maine, new hampshire, vermont, massachusetts, rhode island, connecticut, new york, new jersey, pennsylvania, delaware, maryland, the district of columbia, west virginia, ohio, indiana, michigan, illinois, wisconsin, minnesota, iowa, missouri, and kentucky. Vehicles that have experienced sustained exposure to highly corrosive materials used in some jurisdictions for road deicing purposes may experience excessive corrosion in the vicinity of the forward mounting point bracket for the left or right rear suspension lower link prior to the time that such corrosion would normally be expected.
  dealers will inspect the rear suspension lower link bracket area. For vehicles in which little or no corrosion is found, the area will be treated with an anti-corrosive compound. For vehicles in which corrosion has damaged the rear suspension lower link bracket and affected its connection to the vehicle frame, a reinforcement bracket will be installed. In the rare event the corrosion is so severe that the reinforcement bracket remedy would not be appropriate, a repurchase offer will be extended to the vehicle's owner. All inspections and remedies will be provided free of charge for vehicles that are 10 years old or less. For vehicles older than 10 years, isuzu will offer a free remedy, but only if the vehicle is presented to an isuzu service facility, or honda dealer (as applicable), dealer within 12 months of when owner notifications were issued. The safety recall began on december 10, 2010. Isuzu owners may contact isuzu at 1-800-255-6727. Honda owners may contact honda at 1-800-999-1009.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 880 [USA]: in the event of a crash, the air bag will not inflate properly or sufficiently resulting in an increased risk of injury to the seat occupant.
  On certain sport utility vehicles, the passenger-side air bag inflator modules were manufactured and shipped without a necessary component known as a check valve pin.
  dealers will replace the passenger side air bag. Owner notification began august 7, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact honda at 1-800-999-1009.
  customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 5430 [USA]: In the event of a crash that would trigger a passenger air bag deployment, too much generant can cause the inflator module to explode. if the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupants.
  Vehicle description: certain sport utility vehicles were built with the inflators in the passenger side air bag modules having the wrong amount of generant.
  dealers will replace the passenger side air bag unit.
  all vehicles involved has been corrected.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Fuel tank retention failure investigation # DP18001

  On april 10, 2018, nhtsa received a petition from mr. Kevin byrne (the "petitioner") requesting that the agency “undertake a defects investigation” of “rust-related detachment of isuzu rodeo fuel tanks” (nhtsa id 11091788). The petitioner experienced a partial fuel tank detachment in his model year (my) 2004 isuzu rodeo in july 2017. On may 23, 2018, odi opened dp18-001 to evaluate the petitioner’s request for a defect investigation. Odi sent information request letters to isuzu and honda requesting production, design history and field data related to fuel tank retention failures in my 2001-2004 isuzu rodeo, my 2002-2004 isuzu axiom and my 2001-2002 honda passport vehicles equipped with the same fuel tank shield part number as the petitioner’s vehicle (the “subject vehicles”). Odi notes that isuzu manufactured the subject passport vehicles for honda. Isuzu implemented a change to the tank shield corrosion protection system as a running change in early my 2002 production. Isuzu and honda sold approximately 172,000 subject vehicles in the united states. Fifty-eight (58) percent of the subject vehicles were produced prior to the shield change (99,000) and 42 percent after the change (73,000).Odi’s analysis of field data identified 19 incidents of partial fuel tank detachments in the subject vehicles. The incidents all occurred in states with high road salt usage in winter months ("salt states") and involved older vehicles beyond 10-years in service. On average, the failures occurred in the vehicle’s 13th year-in-service. Evidence of severe general corrosion in multiple undercarriage components was also noted in 13 of the 19 vehicles that experienced partial fuel tank detachments. None of the incidents resulted in fuel leakage or fire. Aside from the petitioner’s vehicle, odi has not identified any other incidents of complete or partial fuel tank detachment in the my 2002-2004 subject vehicles equipped with the modified retention shield.In addition, odi reviewed 24 nhtsa complaints alleging corrosion concerns with the fuel tank retention system in the subject vehicles that did not result in fuel tank detachment. Twenty-three (23) of these complaints involve subject vehicles built prior to the shield change. Like the vehicles reporting fuel tank detachments, these vehicles are also all from salt states and, in most cases (20 of the 24 complaints), the vehicles also experienced severe corrosion concerns in other undercarriage components. Half (12 of the 24 complaints) of the vehicles show prior accident damage in their service histories.Based on these analyses, odi has not identified evidence of a defect trend for premature corrosion-related fuel tank detachments in the my 2004 isuzu rodeo or similarly equipped vehicles. The damage that may result in tank retention concerns appears to occur progressively over many years with ample opportunity for detection and repair. Furthermore, odi has not identified any crashes, fires, injuries, or fuel leaks associated with fuel tank retention failures in a population of vehicles that currently range from 16 to 19 years old.Accordingly, the agency is denying the petition.A summary of odi’s analysis of this petition will be published in the federal register and is also available in the investigative file for this action.The nhtsa consumer complaints counted in the closing resume for dp18-001 can be reviewed at www.Nhtsa.Gov under the following odi identification numbers (voqs in parentheses denote duplicate records): allegations of fuel tank retention failure: 11084098 (11091788), 10532845, 10486109. Allegations of fuel tank retention component corrosion: 11138931, 10992150, 10845523, 10824247 (10824308), 10597729, 10594770, 10558538, 10550870, 10544001, 10436344, 10424477,10399930, 10393933, 10393246, 10386578, 10374811, 10356153, 10339599, 10329133, 10322095, 10316008, 10296208, 10283640, 10275653.
  

  Show Content

• Rear suspension lower link detachment investigation # EA09018

  On september 22, 2010, isuzu manufacturing services of america, inc (isuzu) submitted a defect information report (nhtsa recall 10v-436) to the national highway traffic safety administration affecting approximately 120,000 model year (my) 1998-2002 isuzu rodeo and honda passport vehicles and my 2002 isuzu axiom vehicles originally sold, or currently operated, in the following states:connecticut, delaware, the district of columbia, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia and wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, isuzu will offer a free remedy provided the vehicle is presented to an isuzu service facility or a honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The office of defects investigation (odi) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzus recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on isuzus safety recall, this engineering analysis is closed.A copy of the recall may be assessed on nhtsas website using the reference number above.
  

  Show Content

• Rear suspension lower link failure investigation # PE09030

  During preliminary evaluation pe09-030, isuzu motors america, inc (isuzu) noted two primary differences once the rear suspension lower link separation occurs between the alleged defect (separation of the lower link from the frame) of this investigation and a safety defect involving lower link separation from the rear axle addressed by isuzu in safety recall 00v-058.In the case of the defect condition identified in recall 00v-058, isuzu stated that the attachment bolt could detach fully, causing separation of the lower link from the rear axle possibly creating a loss of vehicle control. Isuzu also stated that this condition occurs early in the service life of the vehicle.In this investigation isuzu noted lower link separation from the frame is a progressive corrosion issue with prior warning to consumers.Isuzu also stated that in the event of a lower link separation from the frame, the vehicle is still controllable and can be safely stopped. The office of defect investigation (odi) analyzed complaint data provided by isuzu and america honda motor company, inc (honda), as well as vehicle owner questionnaires submitted to odi from consumers.In total, there were 60 unique reports of lower link separations from the frame including 1 alleged crash and 7 loss of vehicle control incidents that may be related to the alleged defect.Most of these complaints indicated that there was no warning prior to the link separation.This preliminary evaluation has been upgraded to an engineering analysis (ea09-018) to further assess the scope, frequency and risk to motor vehicle safety of the alleged defect in the subject vehicles.
  

  Show Content

Recall

Recall

It's a recall on my honda passport 2001 10v436000-bracket corrodes and detaches pearson honda said they didn't see a recall in there system they have 3 recalls

Tl* the contact owns a 2001 honda passport. The contact stated that her son discovered corrosion forming around the axle and the suspension of the vehicle. The contact called pearson honda (14001 hull street rd, midlothian, va 23112, (804) 745-0300) and was informed that the vehicle was not included in a recall. The contact discovered nhtsa campaign number: 10v436000(suspension), which she linked to the failure. The vehicle had not been repaired. The manufacturer was not contacted. The failure mileage was 97,000.

Tl* the contact owns a 2001 honda passport. The contact called on behalf of the driver. While driving at an unknown speed, the driver noticed that the rear of the vehicle was swaying. The driver coasted over to the side of the road and noticed that the rear suspension bracket was detached and the subframe was corroded through. The driver was able to drive the vehicle home. The vehicle was later taken to an independent mechanic, but was not diagnosed or repaired. The contact called baron honda at (631) 714-2094, 17 medford ave, patchogue, ny 11772) where an appointment was scheduled for diagnostic testing. The manufacturer was notified of the failure and did not assist. The approximate failure mileage was 100,000.

I was changing the tires and noticed a huge whole on the bottom frame extreme corrosion... Afraid to drive

Got into vehicle and started it up. Put into reverse and the engine revved up and shot backwards very fast. While applying pressure to the brake it had no effect until slamming into the house that was across the street.

All rusty inreparable frame

Frame rusted out and fuel tank mounting bracket rusted through.

Common OBD-II Error Codes

• C0282 [1] C0282
• C0285 [1] C0285
• C1999 [1] C1999
• C0265 [2] C0265
• P0440 [1] Evaporative Emission Control System Malfunction
• P0442 [1] Evaporative Emission Control System Leak Detected (small leak)