Jayco Designer Legacy 2004
Vehicle Details: Recalls, Investigations, Consumer Complaints, Service Bulletins
Below you will find all available information on the 2004 JAYCO Designer Legacy.
Manufacturer | Known WMI(s) | Fuel Type |
---|---|---|
JAYCO |
Use the box here to look up VINs from JAYCO as well as other manufacturers
-
Are there recalls for the 2004 JAYCO Designer Legacy?
- There are 2 recall(s) for the 2004 JAYCO Designer Legacy, additional information is below.
Recall 127448 [USA]: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Recall 33228 [USA]: An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.
To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.
Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.
- INC 22-067 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Jayco and entegra coach storage tips. Instructions for storing jayco and entegra coach diesel pushers.
Wheel separations investigation # EA04019
Jayco is conducting campaign 04v-364 to address 742 vehicles equipped with "six lug" aluminum wheels.Odi is initiating a recall query to further investigate vehicles equipped with "eight lug" aluminum wheels since these vehicles exhibit a small but persistent rate of wheel separations.
Wheel separation investigation # PE04016
In response to odis june 1, 2004 pe inquiry,jayco advised odi of 58 wheel separation incidents that have occurred in jayco products.Three (3) are model year 2002-2003 travel trailersand fifty-five (55) are model year 2001-2004 fifth wheel towable rvs equipped with aluminum wheels.Jayco has also advised odi that an additional two (2) wheel separations occurred during june, 2004, for an overall total of sixty. Odi conducted a field inspection of the jayco vehicle that "lost" a wheel on june 11, 2004.The inspection found evidence of coating material between thehub and wheel mounting faces.Foreign material such as coatings in the wheel mounting joint can compromise the ability of the nuts to maintain clamp and lead to nut loosening and/or stud breakage and could result in a wheel separation.A wheel that separates from a vehicle at highway speeds poses a hazard to other users of the roadway and can affect the stability and safety of the affected rv.This pe is being upgraded to an engineering analysis for further investigation.
Crash | Fire | Towed | Injured | Deaths | Failure Date |
---|
No | No | N | None | None | 20080927 |
Tl*the contact owns a 2004 jayco designer fifth wheel travel trailer. The vehicle has goodyear marathon tires. The contact stated that the tread separated and blew out the sidewall while driving 65 mph. She heard a loud boom and noticed that the rear passenger side tire had blown; however, the stability of the vehicle did not change. The failure and current mileages were less than 2,000.
No | No | N | None | None | 20041126 |
Dt: the consumer stated the valve stems ruptured. The consumer caught some of the tires before they blew out. The faulty valve stems caused the tires to go flat. There are only 2,800 miles on the tires on this 2004 jayco 5th wheel designer trailer. The consumer has contacted jayco through his dealer. Jayco said they contacted the stem manufacturer and it was normal wear and tear of the tire, and jayco can not do anything about it. This is the first incident with these tires and it was a total of 6 wheels on all locations, four tires went at once. The owner just so happened to be pulling in to a campground when he noticed a problem. The consumer heard the air leaking out from the tires. The consumer then contacted road assistance for help, but has not driven on the tires since returning home. The consumer does plan on replacing these with steel valve stems. *nm