Are there recalls for the 2007 JAYCO Designer?
- There are 7 recall(s) for the 2007 JAYCO Designer, additional information is below.
NHTSA Mandated Recalls
Recall 33117 [USA]: This standard specifies tire and rim selection requirements and rim marking requirements.
Certain fifth wheel travel trailers fail to conform to the requirements of federal motor vehicle safety standard no. 120, 'tire selection and rims for motor vehicles other than passenger cars.' the federal identification label contains the incorrect tire load range and inflation pressures. the incorrect label will be removed and a new correct label will be installed. The recall began on may 15, 2007. Owners may contact jayco at 1-800-283-8267. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.
Recall 45759 [USA]: A person could be injured should the step give way while being used to enter or exit the trailer.
On certain travel and fifth wheel trailers equipped with hickory springs 'big easy triple steps,' an improper engagement of the bottom step pivot arm with the formed stop edge of the middle step support bracket can result in the bottom step rotating to an unsafe downward angle. dealers will inspect the trailers for the manufacturing date sticker to verify the date of production of the step and, if necessary, will weld stock to each side of the lower (triple) step stop edges. The recall began on march 30, 2007. Owners may contact jayco at 1-800-283-8267. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.
Recall 37191 [USA]: This condition, if not addressed, could result in an electrical fire.
On certain fifth wheel trailers, a jumper wire between the two neutral bars is not of adequate gauge. dealers will replace the 12/14 gauge jumper wire with a 6 gauge jumper wire free of charge. The recall began on september 1, 2006. Owners may contact jayco at 1-800-283-8267. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.
Recall 2008076 [Canada]: Label
On certain fifth wheel trailers, the federal identification label do not contain correct tire load range and maximum inflation data. The label indicates tire load range e, with a maximum inflation pressure of 85 psi, but instead should read tire load range d, with a maximum inflation of 65 psi. Over inflating a tire could result in tire failure, increasing the risk of a crash. Correction: dealers will install an updated label.
Recall 2007086 [Canada]: Other
On certain fifth wheel and travel trailers equipped with the big easy tripe steps, an improper engagement of the bottom step pivot arm with the formed stop edge of the middle step support bracket can allow the bottom step to rotate to an unsafe downward angle. Correction: dealers will weld stock to each side of the lower step stop edges.
Recall 2007130 [Canada]: Label
On certain fifth wheel trailers, the certification label contains incorrect tire inflation pressure and load range information. The label indicates an incorrect tire inflation pressure rating of 85 psi instead of 65 psi and load range e instead of d. Correction: dealers will install updated labels.
Recall 2006206 [Canada]: Electrical
On certain trailers, the jumper wire between two neutral bars in the 120 volt load center is not of adequate gauge, which could result in a fire. Correction: dealers will replace the 12/14 wire with a 6 gauge jumper wire.
To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.
Bulletins
Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.
INC 22-067 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Jayco and entegra coach storage tips. Instructions for storing jayco and entegra coach diesel pushers.