Jayco Jay Flight Slx 2019

• Recall 230193 [USA]: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.
  Jayco, inc. (jayco) is recalling certain 2017-2018 jayco designer, 2017-2021 eagle ht, eagle, jay feather, jay flight slx, jay flight, north point, octane superlite, pinnacle, white hawk, 2017-2020 eagle ht, 2018-2021 jay flight bungalow, 2017-2019 octane, and 2019-2020 eagle htx travel trailers and fifth wheels equipped with a winntec model 6020 two-stage propane regulator. The regulator may fail, causing an increase in propane pressure.
  dealers will replace the regulator and test the propane system for leaks, free of charge. Owner notification letters were mailed august 3, 2021. Owners may contact jayco customer service at 1-800-283-8267.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.

  Show Content

• Recall 184573 [USA]: A gas leak can increase the risk of a fire.
  Jayco, inc. (jayco) is recalling certain 2019-2020 jayco white hawk, jay flight slx, jay feather, and jay flight travel trailers equipped with dometic 3 burner cooking stoves. The saddle valve securing bolt may be overtightened, possibly damaging the o-ring seal and causing a continuous gas leak.
  jayco will notify owners, and dometic service centers will install a remedy kit of gaskets, washers, thread locker bolts, and two round orange labels, free of charge. Owner notification letters were mailed on may 3, 2021. Owners may contact jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9901566.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 146804 [USA]: A detached water tank would be a road hazard, increasing the risk of crash.
  Jayco, inc. (jayco) is recalling certain 2019 jay flight tf travel trailers, model 32rlok. The supports for the fresh water tank may be too thin, resulting in the brackets breaking and the tanks detaching from the trailer.
  jayco has notified owners, and dealers will install a threaded rod in the center of the water tank support apparatus to provide additional support, free of charge. The recall began may 9, 2019. Owners may contact jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901433.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 139601 [USA]: If the bearings overheat, the hub may fail, affecting handling and increasing the risk of a crash.
  Jayco, inc. (jayco) is recalling certain 2019 jayco white hawk, jay flight slx, and jay feather travel trailers. The inner wheel hub bearings may not have been sufficiently greased, which can cause the bearings to overheat and fail.
  jayco will notify owners, and dealers will inspect and repair the hubs and bearings, as necessary, free of charge. The recall began december 21, 2018. Owners may contact jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901422.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 129492 [USA]: If the rear turn signals and brake lights do not operate as intended, other drivers will not be properly notified of stopping or turning, increasing the risk of a crash.
  Jayco, inc. (jayco) is recalling certain 2019 jayco jay flight travel trailers. The turn signal and brake lights were wired incorrectly causing the lights to work intermittently, preventing other drivers from knowing the intentions of the vehicle. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 108, "lamps, reflective devices, and associated equipment."
  jayco has notified owners, and dealers will correctly wire the rear turn signals and brake lights to the 7-way trailer cord, free of charge. The recall began october 15, 2018. Owners may contact jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901408.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 132675 [USA]: The missing bearing race may cause premature hub bearing failure, possibly resulting in a separation of the hub from the axle, thereby increasing the risk of a crash.
  Jayco, inc. (jayco) is recalling certain 2019 jayco white hawk, jay flight, and jay flight slx travel trailers. The axles may be missing inner bearing races on the hubs, which can cause the bearing to burnout or cause the hub to overheat.
  jayco will notify owners, and dealers will replace the defective hubs with new hubs or replace the axles, free of charge. The recall began october 18, 2018. Owners may contact jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901410.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 2021367 [Canada]: Accessories
  Issue: on certain rv trailers, the propane (lp) regulator could fail. If this happens, high-pressure propane could reach the appliances. Note: this recall only affects trailers equipped with a winntec model 6020 propane regulator. Safety risk: unregulated propane pressure can create the risk of an appliance fire. Corrective action: jayco will notify owners by mail and instruct you to take your trailer to a dealer to replace the propane (lp) regulator.

  Show Content

• Recall 2021180 [Canada]: Accessories
  Issue: on certain travel trailers equipped with a dometic propane gas stove, there could be an odour of propane gas after a short period of use. If a user attempts to tighten the bolt for the stove's valve in order to stop the smell, they could over-tighten the bolt and cause damage to a seal. This can result in a constant gas leak. Safety risk: a propane gas leak could create the risk of a fire or explosion. Corrective action: jayco will notify owners by mail and instruct you to take your trailer to a dealer to replace the defective hardware and perform a leak test. To reduce the safety risk, jayco recommends that you should not use the propane system or any propane appliance in the trailer until the recall repairs have been completed.

  Show Content

• Recall 2018686 [Canada]: Suspension
  On certain travel trailers, the axles may not have enough grease on the inner hub bearings. This could cause the bearings to overheat and fail, potentially resulting in wheel lockup or separation. This may result in a loss of control causing a crash. In addition, a loose wheel assembly could strike another vehicle, stationary object, or bystander, causing injury and/or property damage. Correction: dealers will inspect all hub assemblies. If there is insufficient grease and the bearings are in new condition, the bearings will be repacked, and the hubs reinstalled. If the bearings show any signs of wear, the hubs and bearings will be replaced. If the axle beam shows any damage, it will also be replaced.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

We have a dometic range top/oven stove in our jayco camper. While camping for two days i went to light the manual pilot light in our oven. I put the oven dial over to pilot and attempted to both put the match near the pilot outlet and push in the dial to activate the pilot gas flow. I could not do both so i went outside to get a helper. While outside it was decided to cook dinner on the camp fire. I forgot to go back inside and to turn the oven nob from pilot to off. Awhile later my wife went into the camper and it was "full" of propane gas. She opened a window and the door along with turning on the microwave vent fan to air out the camper. It seems to me that the safty gas valve should not leak propane while just in the pilot position.

The contact owns a 2019 jayco jay flight slx travel trailer equipped with a dometic cooking stove with part number: 31731 - bbpfbr. The contact received notification of nhtsa campaign number: 21v184000 (equipment). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue but informed the contact that parts were not yet available. The manufacturer was made aware of the issue and informed the contact to contact a dealer. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2019 jayco jay flight slx travel trailer. The contact stated the kitchen faucet had been leaking from the time of purchase. The vehicle was taken to the dealer, where it was diagnosed with a fitting faucet needing to be replaced. However, the faucet started leaking again from underneath the countertop causing it to be swollen and soaked. The contact also stated water was leaking behind the shower trim, down into the insulation, and damaging the floor of the trailer. The vehicle was not taken back to the dealer for diagnosis or repairs. The manufacturer was not made aware of the failure.

On may 24, 2021 we received a notification from dometic corporation in reference to a problem with the stove in our rv. There is a gas leak in the stove and a remedy kit needs to be attained. The customer has to do pretty much all of the leg work. The stove has to be taken apart to attain the model and serial numbers to see if they match from list given. A picture of the information needs to be emailed along with a form to attained a remedy kit. Info has to be received from the dealer where the work is to be performed and listed on the form .Propane gas can not be used in the rv for other components, such as the refrigerator, water heater and furnace. One of the forms received was dated november 13, 2020. According to dometic, this is when the problem arose, so we were not notified until 6 and a half months later. In the meantime, we were using our camper. When asked what compensation will be provide to the customer and the response was "none." when i stated that the customer is doing all the legwork, the response from dometic was: no, all you have to do is bring it there. This situation has been handled very poorly. It took dometic 6 and a half months to notify customers because they did not have the parts in stock to fix the issue. Too long !!! And now, according to dometic, it will be a month beofre the remedy kit is sent to the dealer. Again...Too long !!!

The trailer propane regulator/tank switch mounted on the front of the trailer between the two propane tanks started venting propane. The regulator is a winntec model 6020, p1.0-15.6, q6.R280. Our camping neighbors said they could smell a very strong odor of propane. Propane being heavier than air will tend to pool in any low spots on the ground in a campsite and then could be ignited by many sources of spark or static electricity, causing a fire that could engulf our trailer and possibly our neighbor’s trailers. It took a while with soapy water to narrow down where the leak was coming from.

Tl* the contact owns a 2019 jayco jay flight. The contact received notification of nhtsa campaign number: 21v184000 (equipment) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2019 jayco jay flight trailer. The contact received notification of nhtsa campaign number: 21v179000 (equipment). The dealer was made aware of the recall and informed the contact that the part needed to be ordered for the recall repair. The parts department was not aware if the part was ordered for the recall repair. The contact had not experienced a failure but was concerned about a possible gas leak. The manufacturer was made aware of the issue. Parts distribution disconnect.

There have been so many issues with our camper. We bought it brand new in may of 2019, it started having problems while stationary in august of 2019 when water started leaking through the roof, damaging the light fixtures, soaking our recliner, and the carpet/floor next to the recliner. We took it to ocean grove and it was there for 1 month. Then shortly after that the shower started leaking through the floor, multiple times. Every time they sent someone out, it would be fixed for a few days, then we'd have to call them back to fix it. This went on and on until the water damage was so severe that it had damaged the fuze box. Rv-one (who bought out ocean grove) came out to fix it along with the front door that, now, wasn't shutting or staying closed. The carbon monoxide detector went off in february of 2020 to add to all the other troubles. They told us to bring it in on feb. 3rd, 2020. We brought the camper up to them and they said they would order the parts asap. On the warranty claims it says the order wasn't placed until march 3rd. Then covid-19 started hitting, which delayed them from getting parts. Rv1 had our camper for 5 1/2 months. They called us maybe once or twice for updates, but other than that we were constantly calling them and hearing the same thing over again "your parts are being shipped". We got it back beginning of july and they are a huge scratch on the side and actually tore up one of the tire covers and didn't even say anything. We noticed a few days after bringing it home.

There have been so many issues with our camper. We bought it brand new in may of 2019, it started having problems while stationary in august of 2019 when water started leaking through the roof, damaging the light fixtures, soaking our recliner, and the carpet/floor next to the recliner. We took it to ocean grove and it was there for 1 month. Then shortly after that the shower started leaking through the floor, multiple times. Every time they sent someone out, it would be fixed for a few days, then we'd have to call them back to fix it. This went on and on until the water damage was so severe that it had damaged the fuze box. Rv-one (who bought out ocean grove) came out to fix it along with the front door that, now, wasn't shutting or staying closed. The carbon monoxide detector went off in february of 2020 to add to all the other troubles. They told us to bring it in on feb. 3rd, 2020. We brought the camper up to them and they said they would order the parts asap. On the warranty claims it says the order wasn't placed until march 3rd. Then covid-19 started hitting, which delayed them from getting parts. Rv1 had our camper for 5 1/2 months. They called us maybe once or twice for updates, but other than that we were constantly calling them and hearing the same thing over again "your parts are being shipped". We got it back beginning of july and they are a huge scratch on the side and actually tore up one of the tire covers and didn't even say anything. We noticed a few days after bringing it home.