T-SB-0086-14
Service Bulletin Details
Public Details for: T-SB-0086-14
Summary to be provided on a future date.
- 2014 -
Models from 2014
2014 TOYOTA COROLLA |
®TOYOTA Technical Service B ullet in August 11 , 2014 T-SB-0086-14 Intermittent Poor A/C Cooling at Idle Service Category Vehicle Interior Section Heating/Air Conditioning Market Toyota Supports ~ ASE Certification~ USA Applicability YEAR(S) MODEL(S) 2014 Corolla ADDITIONAL INFORMATION Introduct ion Some 2014 model year Corolla vehicles may exhibit a condition where the A/C system blows warm air intermittently while the vehicle is at idle. An updated A/C compressor is available to address this condition. Prod uction Change Information T his bulletin applies to vehicles produced BEFORE the Production Change Effective V INs shown below. MODEL Corolla PLANT PRODUCTION CHANGE EFFECTIVE VIN TMMC 2T1 BURHE#EC217552 TMMMS 5YFBURHE#EP171965 Parts Information PART NUMBER PREVIO US NEW 88310-02850 88310-02851 PART NAME QTY Compressor, Assembly 1 Warra nty Info rm ati on OP CODE DESC RIPTION TIME OFP T1 T2 AC1400 Compressor w/ Magnetic Clutch Assembly 2.9 88310-02850 72 50 APPLICABLE WARRANTY • This repair is covered under the Toyota Basic Warranty. This warranty is in effect for 36 months or 36,000 miles, whi chever occ urs first, from the vehicle's in-service date . • Warranty application is limited to occurrence of the spec ified condition described in th is bulletin . © 2014 Toyota Motor Sales, USA Page 1 of 4 @TOYOTA T-SB-0086-14 August 11 , 2014 Page 2 of 4 Intermittent Poor A/C Cooling at Idle Required Tools & Equipmen t REQUIRED EQUI PMENT SUPPLIER Techstream 2.0* Techstream Lite PART NUMBER QTY TS2UNIT ADE 1 TSLITEPDLR01 · Essential SST NOTE • Only ONE of the Techstream units listed above is required. • Software version 9.10.037 or later is required . • Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at 1-800-368-6787. Repair Proced ure 1. Co nnect Techstream and navigate to the A/C System Data List. 2. With the vehicle at idle, cycle the A/C button and watch the Regulator Control Current, Regulator Pressure Sensor, and Evaporator Fin Thermistor Data List graphs. © 2014 Toyota Motor Sales, USA @TOYOTA August 11 , 2014 T-SB-0086-14 Page 3 of 4 Intermittent Poor A/C Cooling at Idle Repair Procedure (Continued) 3. When the condition is occurring the following data will be seen : • Regulator Control Current: "0.7" "A" or higher • Regulator Pressure Sensor: Low pressure and not increasing • Evaporator Fin Thermistor: Higher than normal and increasing Figure 1. Ambient Temp Sensor Adjusled Ambienl Temp Engine Coolant Tern Electric Heater Count E lectric Heater Active Level Refrigerant Short a e Check NC Cutoff Signal Refrigeranl Gas T pe Number of Trouble 221 73 . 84.27 F 194.99 F 2 0 - - I =I ON OFF R134a 0 Can the concern be duplicated? • YES - Co ntinue to step 4. • NO - This bulletin does NOT apply. Continue diagnosis using Problem Symptoms table in the applicable Repair Manual. © 2014 Toyota Motor Sales, USA @TOYOTA August 11, 2014 T-SB-0086-14 Intermittent Poor A/C Cooling at Idle Repair Procedure (Continued) 4. Remove and replace the A/C compressor. Refer to the Technical Information System (TIS), applicable model and model year Repair Manual: • 2014 Corolla (2ZR-FE) : Vehicle Interior - Heating/Air Conditioning - "Compressor (for 2ZR-FE) : Removal I Installation" • 2014 Corolla (2ZR-FAE) : Vehicle Interior - Heating/Air Conditioning - "Compressor (for 2ZR-FAE): Removal I Installation" 5. Verify that the intermittent warm air condition is no longer present. © 2014 Toyota Motor Sales, USA Page 4 of 4