42LBAR
Service Bulletin Details
Public Details for: 42LBAR
Summary to be provided on a future date.
- 2007 -
Models from 2007
2007 VOLKSWAGEN BEETLE |
2007 VOLKSWAGEN EOS |
2007 VOLKSWAGEN GOLF |
2007 VOLKSWAGEN GTI |
2007 VOLKSWAGEN JETTA |
2007 VOLKSWAGEN PASSAT |
2007 VOLKSWAGEN RABBIT |
2007 VOLKSWAGEN TOUAREG |
2007 FLUID CAPACITY CHART updated July 23, 2013 1 Vehicle Touareg US Only Engine Oil approx. qty. w/filter change 4.2L (BAR) 9.1L (9.6 qt) 5.0L (BWF) 11.5L (12.1 qt) US & Canada 3.6L (BHK) 6.9L (7.3 qt) Manual Trans N/A Automatic 2 Trans O9D (6 spd AWD) Approx. 9.0L (9.5 qt) See RM for filling after repairs Differential Automatic 3 Trans OAA Front Final Dr. 1.0L (1.1 qt) Cooling 4 System Power 5 Steering Windshield Washer 9.0L (9.5 qt) Fluid Capacity N/A 6.0L (6.3 qt) OAD Transfer Box 0.85L (0.9 qt) A/C Refrigerant R134a Dual Zone 700+50 g (24.7 + 1.8 oz) Four Zone 1050 + 50g (37 + 1.8 oz) A/C Refrigerant 6 Oil (See RM for oils) Denso Dual Zone 140cc ± 10cc (4.7 ± .34 fl oz) Four Zone 240cc (8.1 oz) OAB/OAC Rear Final Dr. GLR 1.25L (1.3 qt) HLV 1.6L (1.7 qt) 1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. TDI-PD: Use only oil meeting VW oil quality standard VW 504 00 / 507 00 low ash oil. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger. 2) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM for details for refills. 3) Differential Automatic Trans: See ETKA for fluid specifics. Lifetime fill (new fill) quantity for reference only. Only replace after repair. See RM for new fill capacity - varies by differential code/engine. 4) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12 (pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to o o o o approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up o o to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness will be reduced. 5) Power Steering: Hydraulic oil G 002 000. Do not use ATF. 6) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 300 A2, with R-134a w/Denso compressor. Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information. Page 1 of 6 © 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. 2007 FLUID CAPACITY CHART updated July 23, 2013 1 Vehicle Eos Engine Oil approx. qty. w/filter change 2.0T (BPY) 4.6L (4.9 qt) 3.2L (BUB) 5.5L (5.8 qt) Manual Trans 2.0T (BPY) O2Q 2.3L (2.4 qt) 2 Automatic 3 Trans BPY/BUB 02E New fill: 7.2L (7.6 qt) Re-fill: Approx: 5.2L (5.5 qt) Differential Automatic Trans With 02E Capacity included w/auto transmission Cooling 4 System Power Steering 2.0 (BPY) 8.6L (9.1 qt) Electromechanical (no fluid) Brake Fluid 5 1.0L (1.1 qt) A/C Refrigerant R-134a Zexel 525 + 25 g (18.5 + 0.9 oz) A/C Refrigerant 6 Oil (See RM for oils) Zexel 120 cc + 15 cc (4.1 + 0.5 fl oz) 3.2L (BUB) N/A See RM for filling after repairs 1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger. 2) Manual Trans: 02Q: Use synthetic oil, SAE 75W90, Part No. G 052 171 A2 3) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM for details for refills. 02E: Use G 052 182 A2. 4) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12 (pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to o o o o approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up o o to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness will be reduced. 5) Brake Fluid: Use the NEW brake fluid VW Standard VW 501 14 Part No. B 000 750 M3. 6) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 200 A2, with R-134a w/Zexel compressor. Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information. Page 2 of 6 © 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. 2007 FLUID CAPACITY CHART updated July 23, 2013 1 Vehicle Passat Passat Wagon Engine Oil approx. qty. w/filter change 2.0T (BPY) 4.6L (4.9 qt) 3.6L (BLV) 5.5L (5.8 qt) Manual Trans BPY 6 Spd FWD 02Q 2.3L (2.4 qt) 2 Automatic 3 Trans BPY 6 Spd FWD 09G New fill: 7.2L (7.6 qt) Re-fill: Approx: 5.2L (5.5 qt) Differential Automatic Trans With 09G/09M Capacity included w/auto transmission Cooling 4 System Power Steering 2.0T (BPY) 7.2L (7.6 qt) Electromechanical (no fluid) 3.6L (BLV) 8.0L (8.5 qt) See RM for filling after repairs Brake Fluid 5 1.15L (1.2 qt) A/C Refrigerant R-134a 600 +25 g (21 + 0.9 oz) A/C Refrigerant 6 Oil (See RM for oils) Sanden 110 cc + 10 cc (4.1 + 0.5 fl oz) Zexel 120 cc + 15 cc (4.1 + 0.5 fl oz) BLV 6 Spd AWD 09M New fill: 7.0L (7.4 qt) 1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger. 2) Manual Trans: See ETKA for fluid specifics. Use Part No. G 052 171 A2. 3) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM for details for refills. 09G/09M: Use G 055 025 A2. 4) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12 (pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to o o o o approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up o o to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness will be reduced. 5) Brake Fluid: Use only the NEW brake fluid VW 501 14 B 000 750 (meeting spec TL 766-Z DOT4). Current brake fluid B 000 700 A must NOT be filled in the Passat brake system. 6) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 154 A2 with R-134a w/Sanden compressor and G 052 200 A2 with Zexel compressor. Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information. Page 3 of 6 © 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. 2007 FLUID CAPACITY CHART updated July 23, 2013 1 Vehicle Rabbit GTI City Golf Canada Only Engine Oil approx. qty. w/filter change 2.5L (BGP/BGQ) 5.5L (5.8 qt) Manual Trans 0A4 5 Speed 1.9L (2.0 qt) 2.0T (BPY) 4.6L (4.9 qt) 02Q 6-Spd AWD 2.3L (2.4 qt) 2.0L (BEV) 4.2L (4.4 qt) 02J 5 Speed 2.0L (2.1 qt) 2 Automatic 3 Trans 09G 6 Speed 7.0L (7.4 qt) 02E 6-Spd FWD New fill: 7.2L (7.6 qt) Re-fill: Approx: 5.2L (5.5 qt) 01M 4 Speed 5.3 L (5.6 qt) Differential Automatic 4 Trans 09G Capacity included w/auto transmission See RM for filling after repairs Cooling 5 System Power 6 Steering Windshield Washer 9.5L (10 qt) Electromechanical (no fluids) 3.0L (3.2 qt) A/C Refrigerant R-134a 525 + 25 g (18.5 + 0.9 oz) A/C Refrigerant 7 Oil (See RM for oils) Denso 140cc ± 10cc (4.7 ± 0.3 fl oz) Sanden 110cc ± 10cc (3.7 ± 0.3 fl oz) 02E Capacity included w/auto transmission 7.6L (8.0 qt) 01M Final Drive 0.75L (0.79 qt) 5.0L (5.3 qt) Zexel 120cc ± 10cc (4.7 ± 0.3 fl oz) 750 + 50 g (26 + 1.8 oz) Zexel 135cc ± 15cc (4.6 ± 0.5 fl oz) 1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger. 2) Manual Trans: 02Q: Use synthetic oil, SAE 75W90, Part No. G 052 911 A1. 0A4: See ETKA for fluid specifics. 3) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM for details for refills. 02E: Use G 052 182 A2. 09G: Use G 052 025 A2. 4) See ETKA for fluid specifics. Lifetime fill (new fill) quantity for reference only. Only replace after repair. See RM for new fill capacity - varies by differential code/engine. 5) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12 (pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to o o o o approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up o o to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness will be reduced. 6) Power Steering: Hydraulic oil G 002 000. Do not use ATF. 7) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 154 A2 with R-134a w/Sanden compressor; G 052 200 A2 with Zexel; G 052 300 A2 with Denso. Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information. Page 4 of 6 © 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. 2007 FLUID CAPACITY CHART updated July 23, 2013 1 Vehicle Jetta City Jetta Jetta Canada Only Engine Oil approx. qty. w/filter change 2.0T (BPY) 4.6L (4.9 qt) Manual Trans 02Q 6-Spd AWD 2.3L (2.4 qt) 2 Automatic 3 Trans 2.5L (BGP/BGQ) 6.0L (6.3 qt) 2.0L (BEV) 4.2L (4.4 qt) 0A4 5-Speed 1.9L (2.0 qt) 02E 6-Spd FWD New fill: 7.2L (7.6 qt) Re-fill: Approx: 5.2L (5.5 qt) 09G 6-Speed 7.0L (7.4 qt) 02J 5-Speed 2.0L (2.1 qt) 01M 4-Speed 5.3 L (5.6 qt) 1.9 TDI (BRM) 4.3L (4.5 qt) OA4 (see above) 02E (see above) Differential Automatic 4 Trans 02E Capacity included w/auto transmission 09G Capacity included w/auto transmission BEV 01M Final Drive 0.75L (0.79 qt) Cooling 5 System Power 6 Steering Windshield Washer BPY 8.0L (8.5 qt) Electromechanical (no fluids) 3.0L (3.2 qt) Use concentrated ZVW 177 901/903/904/906 A/C Refrigerant R134a BPY/BGP/BGQ Sanden 525 + 25 g (18.5 + 0.9 oz) A/C Refrigerant 7 Oil (See RM for oils) BPY/BGP/BGQ Sanden 110cc ± 10cc (BGP/BGQ) 9.5L (10 qt) BEV 5.0L (5.3 qt) BEV 750 + 50 g (26 + 1.8 oz) BEV Zexel 135cc ± 15cc (4.6 ± 0.5 fl oz) BRM (see Sanden above) BRM (see Sanden above) BRM 8.0L (8.5 qt) 1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. TDI-PD: Use only oil meeting VW oil quality standard VW 505 01. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger. 2) Manual Trans: 02Q: Use synthetic oil, SAE 75W90, Part No. G 052 911 A1. 0A4: See ETKA for fluid specifics. 3) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM for details for refills. 02E: Use G 052 182 A2. 09G: Use G 052 025 A2. 4) See ETKA for fluid specifics. Lifetime fill (new fill) quantity for reference only. Only replace after repair. See RM for new fill capacity - varies by differential code/engine. 5) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12 (pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to o o o o approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up o o to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness will be reduced. 6) Power Steering: Hydraulic oil G 002 000. Do not use ATF. 7) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 154 A2 with R-134a w/Sanden compressor; G 052 200 A2 with Zexel. Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information. Page 5 of 6 © 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. 2007 FLUID CAPACITY CHART updated July 23, 2013 1 Vehicle New Beetle New Beetle Convertible California Only Engine Oil approx. qty. w/filter change 2.5L (BPS/BPR) 6.0L (6.3 qt) 1.9L (BEW) 4.3L (4.5 qt) Manual Trans 0A4 5-Speed 1.8L (2.0 qt) 2 Automatic 3 Trans 09G 6-Spd FWD 7.0L (7.4 qt) 02E 6-Speed DSG 7.2L (7.4 qt) Differential Automatic 4 Trans 09G/02E Capacity included w/auto transmission Cooling 5 System Power 6 Steering Windshield Washer 9.5L (10.0 qt) Fluid Capacity N/A 2.0L (2.2 qt) 6.0L (6.3 qt) Fluid Capacity N/A A/C Refrigerant R-134a 700 + 50 g (24.7 +1.8 oz) A/C Refrigerant 7 Oil (See RM for oils) 135cc (4.6 fl oz) 1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. TDI-PD: Use only oil meeting VW oil quality standard VW 505 01. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details 2) Manual Trans: 0A4: See ETKA for fluid specifics. 3) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM for details for refills. 02E: Use G 052 182 A2. 4) See ETKA for fluid specifics. Lifetime fill (new fill) quantity for reference only. Only replace after repair. See RM for new fill capacity - varies by differential code/engine. 5) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12 (pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to o o o o approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up o o to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness will be reduced. 6) Power Steering: Hydraulic oil G 002 000. Do not use ATF. 7) A/C Refrigerant Oil: NBC (BPS/BPR): Use PAG oil, Part No. G 052 154 A2 with R-134a w/Sanden compressor. Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information. Page 6 of 6 © 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.