PI0909B

File in Section:
Service Bulletin
Bulletin No.:
Date:
PI0909B
August, 2013
PRELIMINARY INFORMATION
Subject:
Diagnostic Tips for Low Oil Pressure Light On at Idle
Models:
2013-2014 Buick Encore
2009-2011 Chevrolet Aveo
2011-2014 Chevrolet Cruze
2012-2014 Chevrolet Sonic
2013-2014 Chevrolet Trax (Canada Only)
2009-2010 Pontiac G3, Wave
2008-2009 Saturn Astra
Equipped with Engine RPOs LUJ, LUV, LUW, LWE, LXV, 2H0
This PI has been revised to add models and engine RPOs. Please discard PI0909A.
Condition/Concern
Some customers may comment on the low oil pressure light coming on or flashes on and off at idle.
This may be caused by oil pressure being bled off due to debris in the oil drain check valve and/or a smashed oil
filter.
3283232
During an oil change, it is possible for the tabs on the oil filter, as shown in the illustration above, to break off and fall
into the oil filter housing.
3283221
This piece may become lodged under the oil filter housing drain check valve, causing it to remain open when the
new filter is installed as shown in the illustration above. This will allow oil to drain back into the oil pan and reduce the
pressure allowed to the engine.
3512218
3512219
Shown in the illustrations above is an oil filter that was installed improperly, which caused the oil filter to be smashed
and cannot close the oil filter drain check valve.
Recommendation/Instructions
Use a manual pressure gauge to check oil pressure. If the pressure is low, remove the oil filter and confirm proper
operation of the oil filter drain check valve.
If the valve does not seal or it is held open, repair as necessary and recheck oil pressure.