EDITION 104

A PDF of this newsletter and previous ones can be found by logging in to ServiceNet and clicking on the Elsa Newsletter
section in the Technician References menu.
Edition 104: September 22, 2014
Content

Mandatory wiTECH Software
Update: MY2009 Routan

Reminder: VW Google is Now
Available through vwhub.com

Technical Bulletins

Pending Service Solutions

Tech Tips

Campaigns

Updates

Suggestions
Mandatory wiTECH Software Update: MY2009 Routan
MY2009 Routan / WIN Control Module (WCM) programing.
To all VW dealer technicians: The WCM replacement parts was recently superseded to the new
supplier Marquardt.
In order to program the new Marquardt WCM, the wiTECH application software must be
updated to V13.04.15. Please review VSE -14-18 on ServiceNet under Workshop-Equipment>
wiTECH/ StarMobile-Diagnostic-Tool> Service-Information > VSE 14-18 wiTECH Software
Installation Instructions and follow procedure.
Reminder: VW Google is Now Available through
vwhub.com
VW Google, a Google-powered portal for searching selected repair information is now
available as a direct link on vwhub.com. Elsa users can now access VW Google by logging into
vwhub.com and clicking the “VW Google” link just under the ElsaPro link.
The new link will be in addition to the button available in the Technical Assistance section of Elsa.
This link will only work for users with access to ElsaPro. Tips: Searching for TB’s in VW Google
Users can find all Technical Bulletins (TB) on VW Google using the following search methods
(The example TB used is “26-12-07 - Ad Blue Filling at Delivery (2031040/1)”):
- Using the TB group number (26-12-07):
Searching by group number allows the user to browse all the TB’s available for that specific
group, like on ServiceNet. There are three ways to use the group search:
A. By repair group # (26)
B. By Repair Group # + Publishing Year (26-12)
C. By Repair Group # + Year + Publishing # (26-12-07)
Example (Repair Group # + Publishing Year):
- Or the TB title:
- Or the TB instance:
- Or by Key word search:
Back to top
Technical Bulletins
01 14 21 - 2034898 Supersedes T.B. V011411 dated April 21, 2014 to update
2009 Jetta Wagon (1K5) with (CBEA) labor operation in warranty table.
MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM
Fault Memory, Could be accompanied with Fault P2463 DPF Soot
Accumulation
Model(s)
Year
Eng. Code
Trans.
Code
VIN Range
VIN
From
Range To
Jetta, Jetta Wagon
2009
2.0L TDI
(CBEA)
All
All
All
Golf, Jetta Sedan, Jetta
SportWagen, Golf Wagon
2010–
2014
2.0L TDI
(CJAA)
All
All
All
Beetle, Beetle Convertible
2013–
2014
2.0L TDI
(CJAA)
All
All
All
High soot loads prior to regeneration can cause possible restrictions in the EGR
filter.
Production Solution: New software implemented in current production.
91 14 08 - 2038293 Stationary Vehicle Displayed While in Motion (Premium 8
Radio)
Model(s)
Year
Eng. Code
Jetta Hybrid 2013–2014 1.4L (CNLA)
Trans. Code
VIN Range
From
VIN Range
To
All
All
All
The customer may report that while the vehicle is in motion, the display on the
Premium 8 radio displays the “Stationary Vehicle” driving mode. This symptom is
often intermittent and can be temporarily resolved by performing a key cycle.
This condition only affects vehicles equipped with Premium 8 radio.
Production Solution: SW 0011 implemented into production in CW 37/14.
Pending Service Solutions
No new Pending Service Solutions this week.
Back to top
Tech Tips
23-06-28 TDI Pumpe Duse Engine, with Hard Starting
Update to information: September 12, 2014
Model(s)
Year
Eng.Code
Trans.Code
B5/B6 Passat
2004>
2.0 L TDI
All
For long crank/ difficulty starting with the engine hot: Before replacing any
components for this complaint, drain the fuel from the vehicle and replace with
known good diesel fuel from a reputable source. If the complaint still exists, check
fuel pressure and injector timing.
92-14-04 Rear Washer Jet Leaks / Drips After Use
Model(s)
Year
Eng.Code
Trans.Code
A7 Golf/GTI
2015
All
All
For the A7 Golf/GTI with a rear washer nozzle leaking after use (Installed in the
high mount brake lamp housing). An updated washer nozzle is now available.
Replace with the latest part number available in ETKA.
Back to top
Campaigns
No new campaigns this week.
Updates
No new updates this week.
Suggestions
Please send comments or suggestions to: [email protected]
Back to top
© 2014 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest
information available at the time of printing and is subject to the copyright and other intellectual property rights of
Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time
without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by
any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted
to other sites, without the prior expressed written permission of the publisher.