TSBSC114R1

GROUP
Service Campaign
MODEL
2012~2014MY
Sorento (XMa)
2012~2013MY
Optima (TF/QF)
2012~2013MY
Sportage (SL)
NUMBER
SC 114 (Rev 1, 02/27/2015)
DATE
February 2015
VOLUNTARY SERVICE CAMPAIGN
SUBJECT:
ECM UPGRADE –MIL ON WITH DTC P0087 (SC114)
 NOTICE
This bulletin has been revised to include additional information. New/revised
sections of this bulletin are indicated by a black bar in the margin area.
This bulletin provides information related to an ECM software update for the Engine Control
Unit (ECU) in certain 2012~2014MY Sorento, 2012~2013MY Optima, and 2012~2013MY
Sportage vehicles equipped with the 2.4L and 2.0L Turbo GDI engines. The subject vehicle’s
engines are equipped with a Gasoline Direct Injection (GDI) system that utilizes a Flow
Control Valve (FCV) to control the supply of fuel. The FCV needle may experience excessive
wear, eventually resulting in impairment of fuel flow. If that happens, and to protect the
engine, the ECU may reduce engine acceleration while illuminating the “Check Engine” or
Malfunction Indicator Lamp (MIL). The ECU update will improve the durability and operation
of the FCV needle.
 NOTICE
To assure complete customer satisfaction, always remember to refer to WebDCS
Warranty Coverage (validation) Inquiry Screen (Service > Warranty Coverage
>Warranty Coverage Inquiry) for a list of any additional campaigns that may need
to be performed on the vehicle before returning it to the customer.
File Under: 
Circulate To:
x General Manager

x Service Advisor(s)

x Service Manager

x Parts Manager

x Technician(s) 
x Body Shop Manager 
x Fleet Repair

Page 2 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
ECM Upgrade Procedure:
To correct this condition, the ECM should be reprogrammed using the GDS
download as described in this bulletin.
UPGRADE EVENT NAME
241.XMA 2.4GDI DTC(P0087) LOGIC IMPROVEMENT
242.QF 2.0TGDI/2.4GDI DTC(P0087) LOGIC IMPROVEMENT
243.SL 2.0TGDI DTC(P0087) LOGIC IMPROVEMENT
244.TF 2.0TGDI/2.4GDI DTC(P0087) LOGIC IMPROVEMENT
 NOTICE







A fully charged battery is necessary before ECM upgrade can take place. It is
recommended that the Midtronics GR8-1299 system be used in ECM mode during
charging. DO NOT connect any other battery charger to the vehicle during ECM
upgrade.
All ECM upgrades must be done with the ignition key in the ‘ON’ position.
Be careful not to disconnect any cables connected to the vehicle or GDS during the
ECM upgrade procedure.
DO NOT start the engine during ECM upgrade.
DO NOT turn the ignition key ‘OFF’ or interrupt the power supply during ECM
upgrade.
When the ECM upgrade is completed, turn the ignition ‘OFF’ and wait 20 seconds
before starting the engine.
ONLY use approved ECM upgrade software designated for the correct model, year.
CAUTION
Before attempting an ECM upgrade on any Kia model, make sure to first determine
whether the particular model is equipped with an immobilizer security system.
Failure to follow proper procedures may cause the PCM to become inoperative after
the upgrade and any claims associated with this repair may be subject to
chargeback.
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 3 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
ROM ID INFORMATION TABLES :
Upgrade event #241 (XMa)
ROM ID
MY
T/M
2WD/4WD
IMMO
2012MY
ECM P/N
39113 2G770
Yes (+)
2013MY
39113 2G771
PREVIOUS
NEW
XCC4RB3C
XCC4RB3D
XCC4RB3E
XDC4RE0A
XDC4REAA
XDC4REAB
XDC4REAC
XDC4REAE
XDC4READ
XDC4REAF
XCC4MB3C
XCC4MB3D
XCC4MB3E
XDC4ME0A
XDC4MEAA
XDC4MEAB
XDC4MEAC
XDC4MEAE
XDC4MEAD
XDC4MEAF
XCC4RB3C
XCC4RB3D
XCC4RB3E
XDC4RE0A
XDC4REAA
XDC4REAB
XDC4REAC
XDC4REAE
XDC4READ
XDC4REAF
XCC4MB3C
XCC4MB3D
XCC4MB3E
XDC4ME0A
XDC4MEAA
XDC4MEAB
XDC4MEAC
XDC4MEAE
XDC4MEAD
XDC4MEAF
2WD
2012MY
39113 2G760
No (-)
2013MY
39113 2G761
A/T
2012MY
39114 2G770
Yes (+)
2013MY
39114 2G771
4WD
2012MY
39114 2G760
No (-)
2013MY
39114 2G761
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 4 of 13
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
SUBJECT:
Upgrade event #241 (XMa) (Cont’d)
MODEL
T/M
2WD/
4WD
IMMO
ROM ID
ECU P/N
PREVIOUS
NEW
39113 2GBK5
FDC4RF3A
FDC4RG0A
FDC4RG0B
39113 2GBK0
FDC4MF3A
FDC4MG0A
FDC4MG0B
39113 2GBL5
FDC4RF3A
FDC4RG0A
FDC4RG0B
39113 2GBL0
FDC4MF3A
FDC4MG0A
FDC4MG0B
39114 2GBK5
FDC4RF3A
FDC4RG0A
FDC4RG0B
39114 2GBK0
FDC4MF3A
FDC4MG0A
FDC4MG0B
Yes (+)
2WD
No (-)
AT
Yes (+)
2014MY
4WD
No (-)
Yes (+)
MT
2WD
No (-)
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 5 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
Upgrade event #242 (QF)
MODEL
T/M
IMMO
MY
PREVIOUS
TCC0RC0A
TCC0RC0B
TCC0RC0C
NEW
TDC0RF3B
39111 2G893
TDC0RE3A
TDC0RE5A
TDC0REAA
TDC0RF3A
39111 2G895
TDC0RG1A
TDC0RG1B
39111 2G881
TCC0MC0A
TCC0MC0B
TCC0MC0C
TDC0MF3B
39111 2G883
TDC0ME3A
TDC0ME5A
TDC0MEAA
TDC0MF3A
39111 2G885
TDC0MG1A
TDC0MG1B
12MY
39111 2G877
TCS4RB3A
TCS4REAA
TCS4REAB
13MY
39111 2G879
TDS4REAA
TDS4RF0A
TDS4RF3A
TDS4RF3B
12MY
39111 2G867
TCS4MB3A
TCS4MEAA
TCS4MEAB
13MY
39111 2G869
TDS4MEAA
TDS4MF0A
TDS4MF3A
TDS4MF3B
12MY
39111 2G877
TCS4RB3A
TCS4REAA
TCS4REAB
13MY
39111 2G879
TDS4REAA
TDS4RF0A
TDS4RF3A
TDS4RF3B
12MY
39111 2G867
TCS4MB3A
TCS4MEAA
TCS4MEAB
13MY
39111 2G869
TDS4MEAA
TDS4MF0A
TDS4MF3A
TDS4MF3B
12MY
39111 2G872
TCC4RB3A
TCC4REAA
TCC4REAB
13MY
39111 2G874
TDC4REAA
TDC4RF0A
TDC4RF3A
TDC4RF3B
12MY
39111 2G862
TCC4MB3A
TCC4MEAA
TCC4MEAB
13MY
39111 2G864
TDC4MEAA
TDC4MF0A
TDC4MF3A
TDC4MF3B
12MY
39111 2G891
Yes (+)
13MY
QF TGDI
(ULEV)
AT
12MY
No (-)
13MY
Yes (+)
QF GDI
(SULEV)
No (-)
Yes (+)
QF GDI
(SULEV)
AT
No (-)
Yes (+)
QF GDI
(ULEV)
ROM ID
ECM P/N
AT
No (-)
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 6 of 13
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
SUBJECT:
Upgrade event #243 (SL)
MODEL
T/M
2WD/4WD
IMMO
MY
12MY
Yes (+)
13MY
39113 2G870
SCC0RC0B
39113 2G872
SDC0RE3A
SDC0RE5A
SDC0REAA
SDC0RF3A
39113 2G860
12MY
39113 2G861
No (-)
13MY
SL TGDI
(ULEV)
AT
39113 2G862
39113 2G863
12MY
39114 2G870
39114 2G871
Yes (+)
13MY
39114 2G872
39114 2G873
4WD
12MY
39114 2G860
39114 2G861
No (-)
13MY
PREVIOUS
SCC0RB1A
SCC0RB3A
SCC0RC0A
39113 2G871
39113 2G873
2WD
ROM ID
ECM P/N
39114 2G862
39114 2G863
SDC0RG1A
SCC0MB1A
SCC0MB3A
SCC0MC0A
SCC0MC0B
SDC0ME3A
SDC0ME5A
SDC0MEAA
SDC0MF3A
SDC0MG1A
SCC0RB1A
SCC0RB3A
SCC0RC0A
SCC0RC0B
SDC0RE3A
SDC0RE5A
SDC0REAA
SDC0RF3A
SDC0RG1A
SCC0MB1A
SCC0MB3A
SCC0MC0A
SCC0MC0B
SDC0ME3A
SDC0ME5A
SDC0MEAA
SDC0MF3A
SDC0MG1A
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
NEW
SDC0RF3B
SDC0RG1B
SDC0MF3B
SDC0MG1B
SDC0RF3B
SDC0RG1B
SDC0MF3B
SDC0MG1B
Page 7 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
Upgrade event #244 (TF)
MODEL
T/M
IMMO
MY
ECM P/N
ROM ID
PREVIOUS
NEW
TBC0R95C
TBC0R96A
11MY
39111 2G890
TBC0R97A
TBC0R97B
TBC0RB3A
TBC0RC0A
Yes (+)
TCC0MC0K
12MY
39111 2G892
TDC0RF3L
TCC0RC0L
TCC0RC0M
39111 2G892
13MY
TDC0REAK
TDC0RE5K
39111 2G894
TDC0RF3K
39111 2G895
TDC0RG1K
TF TGDI
TDC0RG1L
TBC0M95C
TBC0M96A
11MY
39111 2G880
TBC0M97A
TBC0M97B
TBC0MB3A
TBC0MC0A
AT
No (-)
TCC0MC0L
12MY
39111 2G882
TDC0MF3L
TCC0MC0K
TCC0MC0M
39111 2G882
13MY
12MY
TDC0MEAK
TDC0ME5K
39111 2G884
TDC0MF3K
39111 2G885
TDC0MG1K
39111 2G878
Yes (+)
TCS4RB3K
TCS4REAK
TDC0MG1L
TCS4REAL
TDS4REAK
13MY
39111 2G903
TDS4RF0K
TDS4RF3K
TDS4RG1L
TDS4RG1K
TF GDI
12MY
39111 2G868
TCS4MB3K
TCS4MEAK
TCS4MEAL
TDS4MEAK
No (-)
13MY
39111 2G901
TDS4MF0K
TDS4MF3K
TDS4MG1L
TDS4MG1K
TCC4RB3K
Yes (+)
TF GDI
12MY
39111 2G873
TCC4REAK
TCC4REAL
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 8 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
Upgrade event #244 (TF) (Cont’d)
MODEL
T/M
IMMO
MY
ECM P/N
ROM ID
PREVIOUS
NEW
TDC4REAK
Yes (+)
13MY
39111 2G902
TDC4RF0K
TDC4RF3K
TDC4RG1L
TDC4RG1K
TF GDI
A/T
12MY
39111 2G863
TCC4MB3K
TCC4MEAK
TCC4MEAL
TDC4MEAK
No (-)
13MY
39111 2G900
TDC4MF0K
TDC4MF3K
TDC4MG1L
TDC4MG1K
To verify the vehicle is affected, be sure to check the Calibration Identification of the
vehicle's ECM ROM ID and reference the Information Table as necessary.
1.
Connect the power supply cable to the GDS.
 NOTICE
If attempting to perform the ECM upgrade with the power supply cable
disconnected from the GDS, be sure to check that the GDS is fully charged before
ECM upgrade. If the GDS tool is not fully charged, failure to perform the ECM
upgrade may occur. Therefore, it is strongly recommended that the power supply
connector be connected to the GDS.
2.
Connect the USB cable between the VCI and the GDS.
 NOTICE
When performing the ECM upgrade using the GDS, wireless communication
between the VCI and GDS tool is not available. Therefore, be sure to connect the
USB cable between the VCI and the GDS.
3.
Connect the Main 16-pin DLC cable (GHDM – 241000) to the VCI.
4.
Connect the Main 16-pin DLC cable
(GHDM – 241000) to the OBD-II
connector, located under the driver's side
of the instrument panel.
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 9 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
5.
With the ignition key ON, turn ON the VCI and GDS. Access the GDS vehicle identification
number (VIN) screen and configure the vehicle using the VIN AUTO DETECT Function.
6.
Select ENGINE system and click OK.
Image shown is for demonstration ONLY purposes and will vary by model.
7.
Select ECU Upgrade from the bottom right-hand corner. Next select Auto Mode, and then
Engine. Perform the ECM upgrade in accordance with normal GDS ECM upgrade
procedures.
8.
When the GDS reports that the ECM upgrade has been successfully completed, click OK,
turn OFF the ignition key, and wait at least 10 seconds before attempting to start the
engine.
9.
Check for Diagnostic Trouble Codes using the GDS and erase any DTCs stored such as
EPS, ESC, and TPMS that may have been set during reprogramming.
10.
Start the engine to confirm proper operation of the vehicle.
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 10 of 13
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
SUBJECT:
Manual Mode Upgrade:
CAUTION
Before attempting an ECM upgrade on any Kia model, make sure to first determine
whether the particular model is equipped with an immobilizer security system.
Failure to follow proper procedures may cause the PCM to become inoperative after
the upgrade and any claims associated with this repair may be subject to
chargeback.
 NOTICE
Do NOT attempt to perform a Manual Mode upgrade unless Auto Mode fails. Always
follow the instructions given on the GDS in either Auto or Manual mode. See table
for Manual Mode passwords.
* MANUAL MODE ECM UPGRADE PASSWORDS:
* Do NOT perform Manual Mode ECM upgrade unless Auto Mode fails.
Upgrade event #241 Sorento (XMa)
MODEL
XMa
2.4 GDI
MENU
PASSWORD
XMA GDI -IMMO UL : 39113/14-2G760/65
2760
XMA GDI -IMMO UL : 39113/14-2G761[~ME0A,~MEAA,~MEAB,~MEAC]
2761
XMA GDI -IMMO UL : 39113/14-2G761[~MEAD]
2762
XMA GDI +IMMO/SMK UL : 39113/14-2G770/75
2770
XMA GDI +IMMO/SMK UL : 39113/14-2G771[~RE0A,~REAA,~REAB,~REAC]
2771
XMA GDI +IMMO/SMK UL : 39113/14-2G771[~READ]
2772
XMA GDI -IMMO UL : 39113/14-2GBK0/L0
1420
XMA GDI +IMMO/SMK UL : 39113/14-2GBK5/L5
1425
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 11 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
Upgrade event #242 Optima (QF)
MODEL
QF 2.0
T-GDI
QF 2.4 GDI
MENU
PASSWORD
QF TGDI AT -IMMO UL : 39111-2G881/83 2883
2883
QF TGDI AT -IMMO UL : 39111-2G885 2885
2885
QF TGDI AT +IMMO/SMK UL : 39111-2G891/93 2893
2893
QF TGDI AT +IMMO/SMK UL : 39111-2G895 2895
2895
QF GDI AT -IMMO SUL : 39111-2G867 2867
2867
QF GDI AT -IMMO SUL : 39111-2G869 2869
2869
QF GDI AT +IMMO/SMK SUL : 39111-2G877 2877
2877
QF GDI AT +IMMO/SMK SUL : 39111-2G879 2879
2879
QF GDI -IMMO UL : 39111/12-2G862 2862
2862
QF GDI -IMMO UL : 39111/12-2G864 2864
2864
QF GDI +IMMO/SMK UL : 39111/12-2G872 2872
2872
QF GDI +IMMO/SMK UL : 39111/12-2G874
2874
Upgrade event #243 Sportage (SL)
MODEL
SL 2.0 T-GDI
MENU
PASSWORD
SL TGDI AT -IMMO UL : 39113/14-2G860/61/62
2862
SL TGDI AT -IMMO UL : 39113/14-2G863
2863
SL TGDI AT +IMMO/SMK UL : 39113/14-2G870/71/72
2872
SL TGDI AT +IMMO/SMK UL : 39113/14-2G873
2873
Upgrade event #244 Optima (TF)
MODEL
TF 2.0
T-GDI
TF 2.4 GDI
MENU
PASSWORD
TF TGDI -IMMO UL : 39101-2G880/82/84
2884
TF TGDI -IMMO UL : 39111-2G885
2885
TF TGDI +IMMO/SMK UL : 39111-2G890/92/94
2894
TF TGDI +IMMO/SMK UL : 39111-2G895
2895
TF GDI AT -IMMO SUL : 39111-2G868
2868
TF GDI AT -IMMO SUL : 39111-2G901
2901
TF GDI AT +IMMO/SMK SUL : 39111-2G878
2878
TF GDI AT +IMMO/SMK SUL : 39111-2G903
2903
TF GDI +IMMO/SMK UL : 39111/12-2G873
2873
TF GDI +IMMO/SMK UL : 39111/12-2G902
2902
TF GDI -IMMO UL : 39111/12-2G863
2863
TF GDI -IMMO UL : 39111/12-2G900
2900
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 12 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
1.
Within the ECU Upgrade screen, select Manual Mode in the left column, select Engine
Control System and then select Upgrade Event 241, 242, 243 or 244. Select the
appropriate control unit part number by referring to the ROM ID Information Table on
Pages 3~8, and click OK.
2.
Enter the appropriate password from the tables on Pages 10~11. Click on OK.
3.
Upgrade will begin and the progress of the upgrade will appear on the bar graph.
4.
When the GDS reports that the ECM upgrade has been successfully completed, click OK,
turn OFF the ignition key, and wait at least 10 seconds before attempting to start the
engine.
5.
Check if any incidental Diagnostic Trouble Codes (DTC(s)) have been created by the
upgrade process; clear any DTC(s) that may be present.
6.
Start the engine to confirm proper operation of the vehicle.
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015
Page 13 of 13
SUBJECT:
ECM UPGRADE – MIL ON WITH DTC P0087 (SC114)
AFFECTED VEHICLE PRODUCTION RANGE:
Model
Production Date Range
Sorento (XMa)
From November 1, 2011 through August 27, 2013
Optima (QF)
From September 26, 2010 through August 22, 2013
Optima (TF)
From February 20, 2012 through August 23, 2013
Sportage (SL)
From November 24, 2011 through July 11, 2013
WARRANTY CLAIM INFORMATION:
Claim
Type
Causal P/N
Qty.
N
Code
C
Code
39113 2G771
39111 2G893
R
0
39113 2G872
39111 2G890
N99
C99
Repair
Description
Labor Op
Code
(SC 114)
ECM
Upgrade
(XMa)
150A03R0
(SC 114)
ECM
Upgrade
(QF)
150A03R1
(SC 114)
ECM
Upgrade
(SL)
(SC 114)
ECM
Upgrade
(TF)
Time
Related
Parts
Qty.
0.3
M/H
N/A
0
150010R0
150010R1
 NOTICE
To assure complete customer satisfaction, always remember to refer to WebDCS
Warranty Coverage (validation) Inquiry Screen (Service > Warranty Coverage
>Warranty Coverage Inquiry) for a list of any additional campaigns that may need to
be performed on the vehicle before returning it to the customer.
TSB: SC 114 (REV 1) Sorento (XMa), Optima (TF/QF), Sportage (SL) February 2015