LTB00846NAS1

Service Bulletin Details

Public Details for: LTB00846NAS1

"situation: the front and/or rear door interior trim panel(s) may become detached from the door. Cause: this may be caused when the load applied to the door trim during door closure exceeds the existing clip capability, causing the door t


- 2016 - 2015 -

Models from 2016
2016 LAND ROVER DISCOVERY SPORT
Models from 2015
2015 LAND ROVER DISCOVERY SPORT 
Page 1 of 5
TECHNICAL BULLETIN
LTB00846NAS1
25 NOV 2015
© Jaguar Land Rover North America, LLC
NOTE: The information in Technical Bulletins is intended for use by trained, professional Technicians with the knowledge,
tools, and equipment required to do the job properly and safely. It informs these Technicians of conditions that may occur on
some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by
'do-it-yourselfers'. If you are not a Retailer, do not assume that a condition described affects your vehicle. Contact an
authorized Land Rover service facility to determine whether this bulletin applies to a specific vehicle.
SECTION: 501-05
Front/Rear Door Interior Trim Panel Detached
AFFECTED VEHICLE RANGE:
Discovery Sport (LC)
Model Year:
2015-2016
VIN:
500429-554300
Manufacturing Plant: Halewood
Discovery Sport (LC)
Model Year:
2015-2016
VIN:
500429-566509
Manufacturing Plant: Halewood
MARKETS:
NAS
CONDITION SUMMARY:
Situation: The front and/or rear door interior trim panel(s) may become detached from the door.
Cause: This may be caused when the load applied to the door trim during door closure exceeds the existing
clip capability, causing the door trim panel to become detached. Lantern clip part number LR044885 has a
higher retention value and is to be fitted to the areas where the extra pull of force is exerted.
Action: Should a customer express this concern, follow the appropriate Service Instruction (A or B) below.
Complete this action on all vehicles exhibiting this issue within the Vehicle Identification Number (VIN) range
and on all vehicles, also in the VIN range, that have had the door trim panel removed.
PARTS:
LR044885
Lantern Clip
Quantity: 2
LR013135
Trim Clip
Quantity: 20
TOOLS:
Refer to Workshop Manual for any required special tools.
WARRANTY:
6
NOTE: Repair procedures are under constant review, and therefore times are subject to
change; those quoted here must be taken as guidance only. Always refer to TOPix to obtain the
latest repair time.
6 ,NOTE: DDW requires the use of causal part numbers. Labor only claims must show the causal
part number with a quantity of zero.
DESCRIPTION
SRO
TIME
(HOURS)
CONDITION
CODE
CAUSAL
PART
Trim panel - Front door - Lelt - Renew
76.34.01
0.4
07
LR064207
http://topix.landrover.jlrext.com/topix/service/document/599722
12/3/2015
Page 2 of 5
Trim panel - Front door - Right Renew
76.34.17
0.4
07
LR064207
Trim panel - Rear door - Renew
76.34.04
0.3
07
LR064207
6 ,NOTE: Normal Warranty procedures apply.
COMPONENT LOCATION
1Component location.
E.185 5 92
SERVICE INSTRUCTION A
SERVICE INSTRUCTION 'A' applicable to front doors on vehicles within the VIN range 500429-554300
only.
1Remove the front right door interior trim panel (see TOPix Workshop Manual section: 501-05: Interior Trim
and Ornamentation).
2~
NOTE: front right door interior trim
panel shown; front left door interior trim
panel similar.
Remove and discard the lantern clip.
• Install the new 'orange' clip.
http://topix.landrover.jlrext.com/topix/service/document/599722
12/3/2015
Page 3 of 5
3~
NOTE: front right door interior trim
panel shown; front left door interior trim
panel similar.
Remove and discard the 10 remaining clips from
the door trim.
t:184 7 64
4 6 .NOTE: front right door interior trim
panel shown; front left door interior trim
panel similar.
Fit the 10 new clips to the door trim.
http://topix.landrover.jlrext.com/topix/service/document/599722
12/3/2015
Page 4 of 5
5Install the front right door interior trim panel (see TOPix Workshop Manual Section: 501-05: Interior Trim
and Ornamentation).
6Repeat Steps 1-5 front left door interior trim panel.
SERVICE INSTRUCTION B
SERVICE INSTRUCTION 'B' applicable to rear doors on vehicles within the VIN range 500429-566509
only.
1Remove the rear right door interior trim panel (see TOPix Workshop Manual, section: 501-05: Interior Trim
and Ornamentation).
2~
NOTE: rear right door trim panel shown;
rear left door trim panel similar.
Remove and discard the lantern clip and install
the new 'orange' clip.
E:185593
http://topix.landrover.jlrext.com/topix/service/document/599722
12/3/2015
Page 5 of 5
3Remove and discard the nine remaining clips from
the door trim.
t:1855 94
4Fit the nine new clips to the door trim.
E:1855 95
Sinstall the rear right door trim panel (see TOPix Workshop Manual, section: 501-05: Interior Trim and
Ornamentation).
6Repeat Steps 1-5 on the rear left door trim panel.
http://topix.landrover.jlrext.com/topix/service/document/599722
12/3/2015

© dot.report 2024

Use of this information constitutes acceptance for use in an AS IS condition. There are NO warranties, implied or otherwise, with regard to this information or its use. Any use of this information is at the user's risk. It is the responsibility of user to evaluate the accuracy, completeness or usefulness of any information, opinion, advice or other content. EACH USER WILL BE SOLELY RESPONSIBLE FOR ANY consequences of his or her direct or indirect use of this web site. ALL WARRANTIES OF ANY KIND ARE EXPRESSLY DISCLAIMED. This site will NOT BE LIABLE FOR ANY DIRECT, INDIRECT or any other kind of loss.