TSB-ENG160R1

GROUP
ENG
NUMBER
160 (Rev 1, 11/15/2016)
MODEL
2012~2015MY Optima (QF)
2012~2015MY Sorento (XMa)
2011~2015MY Optima (TF)
2014~2016MY Sportage (SL)
w/2.4 GDI Engine
DATE
October 2016
TECHNICAL SERVICE BULLETIN
SUBJECT:
ECU UPGRADE – MIL ON WITH DTC(s) P0420/P0171
 NOTICE
This bulletin has been revised to include additional information. New/revised
sections of this bulletin are indicated by a black bar in the margin area.
This bulletin provides information related to the ECU software upgrade for some 2012~2015MY
Optima (QF) vehicles, produced from August 12, 2011 to October 2, 2015, some
2012~2015MY Sorento (XMa) vehicles, produced from April 19, 2011 to December 11, 2014,
some 2011~2015MY Optima (TF) vehicles, produced from August 12, 2010 to July 23, 2015,
and some 2014~2016MY Sportage (SL) vehicles, produced from September 30, 2013 to
November 16, 2015, which may experience a malfunction indicator lamp (MIL) illuminated with
the Electronic Control Unit (ECU) system-related DTC(s): P0420 and possibly P0171. This
concern occurs most commonly during prolonged engine braking while descending a steep
grade.
To correct this condition, first inspect the warm-up catalytic converter function using GDS/KDS,
as outlined in the procedure below. If inspection confirms warm-up catalytic converter (WCC)
function is outside of normal operating parameters, replace the exhaust manifold, inspect, and if
necessary, replace the under-floor catalytic converter (UCC), and reprogram the ECU using the
GDS/KDS download, as described in this bulletin. If inspection reveals no abnormalities in the
WCC or UCC, reprogram the ECU ONLY. For confirmation that the latest reflash has been
done to a vehicle you are working on, verify ROM ID using the tables in this TSB.
P0420: Catalyst System Efficiency below Threshold (Bank 1)
P0171: System Too Lean (Bank 1)
Global Diagnostic System (GDS)
File Under: 
Kia Diagnostic System (KDS)
x Parts Manager
x General Manager
x Service Manager



x Technician(s) 
x Body Shop Manager 
x Service Advisor(s)
x Fleet Repair


Circulate To:
Page 2 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCS P0420/P0171
Inspection/Replacement Procedure:
1.
Scan and confirm DTC P0420 with
possible DTC P0171 using GDS/KDS.
2.
After the vehicle has reached normal
operating temperature, with the engine
at idle, access Data Analysis and view
the downstream O2 sensor signals.
3.
If the O2 sensor signals are abnormal or
erratic, as shown, proceed to the
Service Procedure on Page 3. NOTE:
After exhaust manifold replacement,
proceed to ECU upgrade on Page 4.
4.
If the O2 sensor signals are normal, as
shown, proceed to the ECU Upgrade
Procedure on Page 4.
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 3 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCs P0420/P0171
Service Procedure:
1.
Refer to the “Exhaust Manifold →
Removal” section in the applicable
Workshop Manual on KGIS, to replace
the exhaust manifold.
 NOTICE
Before installing the new exhaust
manifold, see step 2 below and
inspect the under-floor catalytic
converter for debris.
2.
With exhaust manifold removed, inspect
the under-floor catalytic converter.
 NOTICE
If debris in the under-floor catalytic
converter is excessive and cannot
be removed, replacement of the
under-floor catalytic converter is
necessary
to
ensure
proper
operation of the catalytic converter.
If debris in the under-floor catalytic
converter is minimal, remove
debris and proceed to the ECU
Upgrade Procedure on page 4.
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 4 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCS P0420/P0171
ECU Upgrade Procedure:
To correct this condition, the ECU should be reprogrammed using the GDS/KDS
download, as described in this bulletin.
UPGRADE EVENT NAME
271.QF 2.4GDI DTC P0171,P0420 LOGIC IMPROVEMENT
272.XMA 2.4GDI DTC P0171,P0420 LOGIC IMPROVEMENT
273.TF 2.4GDI DTC P0171,P0420 LOGIC IMPROVEMENT
274.SL 2.4GDI DTC P0171,P0420 LOGIC IMPROVEMENT
 NOTICE







A fully charged battery is necessary before ECU upgrade can take place. It is
recommended that the Midtronics GR8-1299 system be used in ECU mode during
charging. DO NOT connect any other battery charger to the vehicle during ECU
upgrade.
All ECU upgrades must be done with the ignition key in the ‘ON’ position.
Be careful not to disconnect any cables connected to the vehicle or GDS during
the ECU upgrade procedure.
DO NOT start the engine during ECU upgrade.
DO NOT turn the ignition key ‘OFF’ or interrupt the power supply during ECU
upgrade.
When the ECU upgrade is completed, turn the ignition ‘OFF’ and wait 10 seconds
before starting the engine.
ONLY use approved ECU upgrade software designated for the correct model,
year.
CAUTION
Before attempting an ECU upgrade on any Kia model, make sure to first determine
whether the particular model is equipped with an immobilizer security system.
Failure to follow proper procedures may cause the PCM to become inoperative after
the upgrade and any claims associated with this repair may be subject to
chargeback.
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 5 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCs P0420/P0171
Upgrade event #271 (QF)
Model
MY
IMMO
IMMO
ECU P/N
6AT
ROM ID
6MT
IMMO
IMMO
39111-2G862
39112-2G862
39111-2G877
-
39111-2G867
-
39111-2G874
39112-2G874
39111-2G864
39112-2G864
39111-2G879
-
39111-2G869
-
39108-2GBJ0
39118-2GBJ0
TEC4RH2A
TEC4RH2B
39108-2GBH0
39118-2GBH0
TEC4MH2A
TEC4MH2B
39108-2GBJ5
-
TES4RH2A
TES4RH2B
39108-2GBH5
-
TES4MH2A
TES4MH2B
39118-2GBJ1
TFC4RH4A
TFC4RH4B
39118-2GBH1
TFC4MH4A
TFC4MH4B
-
TFS4RH4A
TFS4RH4B
-
TFS4MH4A
TFS4MH4B
13MY(ULEV)
NON IMMO
IMMO
QF
2.4 GDI
13MY(SULEV)
NON IMMO
IMMO
NEW
39112-2G872
12MY(SULEV)
NON IMMO
TCC4RB3A
TCC4REAA
TCC4REAB
TCC4MB3A
TCC4MEAA
TCC4MEAB
TCS4RB3A
TCS4REAA
TCS4REAB
TCS4MB3A
TCS4MEAA
TCS4MEAB
TDC4REAA
TDC4RF0A
TDC4RF3A
TDC4RF3B
TDC4MEAA
TDC4MF0A
TDC4MF3A
TDC4MF3B
TDS4REAA
TDS4RF0A
TDS4RF3A
TDS4RF3B
TDS4MEAA
TDS4MF0A
TDS4MF3A
TDS4MF3B
39111-2G872
12MY(ULEV)
NON IMMO
OLD
TCC4REAC
TCC4MEAC
TCS4REAC
TCS4MEAC
TDC4RF3C
TDC4MF3C
TDS4RF3C
TDS4MF3C
14MY(ULEV)
NON IMMO
IMMO
14MY(SULEV)
NON IMMO
IMMO
15MY(ULEV)
NON IMMO
IMMO
15MY(SULEV)
NON IMMO
39108-2GBJ1
39108-2GBJ2
39108-2GBH1
39108-2GBH2
39108-2GBJ6
39108-2GBJ7
39108-2GBH6
39108-2GBH7
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 6 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCS P0420/P0171
Upgrade event #272 (XMa)
Model
MY
IMMO
ECU P/N
6AT
Rom ID
6MT
39113-2G770
-
IMMO
39114-2G770
12MY
39113-2G760
NON IMMO
39114-2G760
39113-2G771
-
IMMO
39114-2G771
13MY
39113-2G761
XMa
2.4GDI
NON IMMO
39114-2G761
39113-2GBK5
-
IMMO
39113-2GBL5
14MY
39113-2GBK0
NON IMMO
39113-2GBL0
IMMO
15MY
NON IMMO
39113-2GBK6
39113-2GBK7
39113-2GBL6
39113-2GBL7
39113-2GBK1
39113-2GBK2
39113-2GBL1
39113-2GBL2
-
-
OLD
XCC4RB3A
XCC4RB3C
XCC4RB3D
XCC4RB3E
XCC4MB3A
XCC4MB3C
XCC4MB3D
XCC4MB3E
XDC4RE0A
XDC4REAA
XDC4REAB
XDC4REAC
XDC4REAE
XDC4READ
XDC4REAF
XDC4ME0A
XDC4MEAA
XDC4MEAB
XDC4MEAC
XDC4MEAE
XDC4MEAD
XDC4MEAF
FDC4RF3A
FDC4RG0A
FDC4RG0B
FEC4RH2A
FDC4MF3A
FDC4MG0A
FDC4MG0B
FEC4MH2A
FFC4RH2A
FFC4RH2A
FFC4RHAA
FFC4MH2A
FFC4MH2A
FFC4MHAA
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
NEW
XCC4RB3F
XCC4MB3F
XDC4REAG
XDC4REAH
XDC4MEAG
XDC4MEAH
FEC4RG0C
FEC4RH2B
FEC4MG0C
FEC4MH2B
FFC4RHAB
FFC4MHAB
Page 7 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCs P0420/P0171
Upgrade event #273 (TF)
Model
MY
IMMO
ECU P/N
ROM ID
6AT
6MT
39111-2G870
39112-2G870
39111-2G871
39112-2G871
39111-2G860
39112-2G860
39111-2G861
39112-2G861
39111-2G875
-
39111-2G876
-
39111-2G865
-
39111-2G866
-
39111-2G873
39112-2G873
39111-2G863
39112-2G863
IMMO
11MY(ULEV)
NON IMMO
TF
2.4 GDI
IMMO
11MY(SULEV)
NON IMMO
IMMO
12MY(ULEV)
NON IMMO
OLD
TBC4R85A
TBC4R86A
TBC4R86B
TBC4R86C
TBC4R88A
TBC4R88B
TBC4RB3A
TBC4RB3B
TBC4M85A
TBC4M86A
TBC4M86B
TBC4M86C
TBC4M88A
TBC4M88B
TBC4MB3A
TBC4MB3B
TBS4R85A
TBS4R86A
TBS4R86B
TBS4RF3E
TBS4R86C
TBS4R88A
TBS4R88B
TBS4RB3A
TBS4RB3B
TBS4RF3F
TBS4M85A
TBS4M86A
TBS4M86B
TBS4MF3E
TBS4M86C
TBS4M88A
TBS4M88B
TBS4MB3A
TBS4MB3B
TBS4MF3F
TCC4RB3K
TCC4REAK
TCC4REAL
TCC4MB3K
TCC4MEAK
TCC4MEAL
NEW
TBC4R86D
TBC4RB3C
TBC4M86D
TBC4MB3C
TBS4RF3G
TBS4RF3H
TBS4MF3G
TBS4MF3H
TCC4REAM
TCC4MEAM
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 8 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCS P0420/P0171
Upgrade event #273 (TF) Continued
Model
MY
IMMO
ECU P/N
ROM ID
6AT
6MT
39111-2G878
-
39111-2G868
-
39111-2G902
39112-2G902
39111-2G900
39112-2G900
39101-2G903
-
NON IMMO
39111-2G901
-
14MY(ULEV)
IMMO
NON IMMO
14MY(SULEV)
IMMO
NON IMMO
39108-2GBF0
39108-2GBE0
39108-2GBF5
39108-2GBE5
39108-2GBF1
39108-2GBE1
39108-2GBE6
39118-2GBF0
39118-2GBE0
39118-2GBE1
-
IMMO
12MY(SULEV)
NON IMMO
IMMO
13MY(ULEV)
TF
2.4 GDI
NON IMMO
IMMO
13MY(SULEV)
TF F/L
2.4 GDI
15MY(ULEV)
15MY(SULEV)
IMMO
NON IMMO
NON IMMO
OLD
TCS4RB3K
TCS4REAK
TCS4REAL
TCS4MB3K
TCS4MEAK
TCS4MEAL
TDC4REAK
TDC4RF0K
TDC4RF3K
TDC4RG1K
TDC4RG1L
TDC4MEAK
TDC4MF0K
TDC4MF3K
TDC4MG1K
TDC4MG1L
TDS4REAK
TDS4RF0K
TDS4RF3K
TDS4RG1K
TDS4RG1L
TDS4MEAK
TDS4MF0K
TDS4MF3K
TDS4MG1K
TDS4MG1L
TEC4RH2K
TEC4MH2K
TES4RH2K
TES4MH2K
TFC4RH4K
TFC4MH4K
TFS4MH4K
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
NEW
TCS4REAM
TCS4MEAM
TDC4RG1M
TDC4MG1M
TDS4RG1M
TDS4MG1M
TEC4RH2L
TEC4MH2L
TES4RH2L
TES4MH2L
TFC4RH4L
TFC4MH4L
TFS4MH4L
Page 9 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCs P0420/P0171
Upgrade event #274 (SL)
Model
MY
IMMO
ECU P/N
6AT
6MT
39107-2GCD0
39117-2GCD0
39107-2GCE0
39117-2GCE0
39107-2GCD5
39117-2GCD5
IMMO
14MY(ULEV)
NON IMMO
39107-2GCE5
IMMO
39117-2GCE5
39107-2GCG0
-
39107-2GCG5
-
14MY(SULEV)
NON IMMO
SL
2.4 GDI
IMMO
15MY(ULEV)
NON IMMO
IMMO
15MY(SULEV)
NON IMMO
IMMO
16MY(ULEV)
NON IMMO
16MY(SULEV)
IMMO
NON IMMO
39107-2GCD1
39107-2GCD2
39107-2GCE1
39107-2GCE2
39107-2GCD6
39107-2GCD7
39107-2GCE6
39107-2GCE7
39107-2GCG1
39107-2GCG2
39107-2GCG6
39107-2GCG7
39107-2GCD3
39107-2GCE3
39107-2GCD8
39107-2GCE8
39107-2GCG3
39107-2GCG8
ROM ID
OLD
SEC4RH2A
SEC4RH2B
SEC4RH2C
SEC4MH2A
SEC4MH2B
SEC4MH2C
SES4RH2A
SES4RH2B
SES4RH2C
SES4MH2A
SES4MH2B
SES4MH2C
NEW
SEC4RH2D
SEC4MH2D
SES4RH2D
SES4MH2D
39117-2GCD1
SFC4RH4A
SFC4RH4B
SFC4MH4A
SFC4MH4B
-
SFS4RH4A
SFS4RH4B
-
SFS4MH4A
SFS4MH4B
39117-2GCD3
39117-2GCE3
39117-2GCD8
39117-2GCE8
-
SGC4RH4A
SGC4RH4B
SGC4MH4A
SGC4MH4B
SGS4RH4A
SGS4MH4A
SGS4RH4B
SGS4MH4B
39117-2GCE1
39117-2GCD6
39117-2GCE6
To verify the vehicle is affected, be sure to check the Calibration Identification of the vehicle's ECU
ROM ID and reference the Information Table as necessary.
 NOTICE
If performing this TSB using KDS, refer to TSB SST 037 for detailed information.
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 10 of 15
SUBJECT:
1.
ECU UPGRADE – MIL ON WITH DTCS P0420/P0171
Connect the power supply cable to the GDS.
 NOTICE
If attempting to perform the ECU upgrade with the power supply cable
disconnected from the GDS, be sure to check that the GDS is fully charged
before ECU upgrade. If the GDS is not fully charged, failure to perform the ECU
upgrade may occur. Therefore, it is strongly recommended that the power supply
connector be connected to the GDS.
2.
Connect the USB cable between the VCI and the GDS.
 NOTICE
When performing the ECU upgrade using the GDS, wireless communication
between the VCI and GDS is not available. Therefore, be sure to connect the USB
cable between the VCI and the GDS.
3.
Connect the Main 16-pin DLC cable (GHDM – 241000) to the VCI.
4.
Connect the Main 16-pin DLC cable
(GHDM – 241000) to the OBD-II
connector, located under the driver's
side of the instrument panel.
5.
With the ignition key ON, turn ON the VCI and GDS. Access the GDS vehicle identification
number (VIN) screen and configure the vehicle using the VIN AUTO DETECT Function.
6.
Select ENGINE system and click OK.
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 11 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCs P0420/P0171
Image shown is for reference only purposes and will vary by model.
7.
Select ECU Upgrade from the bottom right-hand corner. Next select Auto Mode, and
then Engine. Perform the ECU upgrade in accordance with normal GDS ECU upgrade
procedure.
8.
Check for Diagnostic Trouble Codes using the GDS and erase any DTCs stored such as
EPS, ESC, and TPMS that may have been set during reprogramming.
9.
Start the engine to confirm proper operation of the vehicle.
CAUTION
Before attempting an ECU upgrade on any Kia model, make sure to first determine
whether the particular model is equipped with an immobilizer security system.
Failure to follow proper procedures may cause the PCM to become inoperative after
the upgrade and any claims associated with this repair may be subject to
chargeback.
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 12 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCS P0420/P0171
Manual Mode ECU Upgrade Procedure:
 NOTICE
Do NOT attempt to perform a Manual Mode upgrade unless Auto Mode fails. Always
follow the instructions given on the GDS in either Auto or Manual mode. See table
for Manual Mode passwords.
MANUAL MODE ECU UPGRADE PASSWORDS:
Model
QF
2.4 GDI
Menu
QF 12MY 2.4GDI ULEV -IMMO : 39111-2G862
QF 12MY 2.4 GDI ULEV +IMMO/SMK : 39111/2-2G872
QF 12MY 2.4GDI SULEV -IMMO : 39111-2G867
QF 12MY 2.4GDI SULEV +IMMO/SMK : 39111-2G877
QF 13MY 2.4GDI ULEV -IMMO : 39111/2-2G864
QF 13MY 2.4GDI ULEV +IMMO/SMK : 39111/2-2G874
QF 13MY 2.4GDI SULEV -IMMO : 39111-2G869
QF 13MY 2.4GDI SULEV +IMMO/SMK : 39111-2G879
QF 14MY 2.4GDI ULEV -IMMO : 39108/18-2GBH0
QF 14MY 2.4GDI ULEV +IMMO/SMK : 39108/18-2GBJ0
QF 14MY 2.4GDI SULEV -IMMO : 39108-2GBH5
QF 14MY 2.4GDI SULEV +IMMO/SMK : 39108-2GBJ5
QF 15MY 2.4GDI ULEV -IMMO : 39108-2GBH1/2,39118-2GBH1
QF 15MY 2.4GDI ULEV +IMMO/SMK : 39108-2GBJ1/2,39118-2GBJ1
QF 15MY 2.4GDI SULEV -IMMO : 39108-2GBH6/7
QF 15MY 2.4GDI SULEV +IMMO/SMK : 39108-2GBJ6/7
Password
2862
2872
2867
2877
2864
2874
2869
2879
0820
0821
0825
0826
1821
1822
0827
0828
Model
Menu
Password
XMa
2.4 GDI
XMA 12MY 2.4GDI -IMMO : 39113/4-2G760,39113-2G765
XMA 12MY 2.4GDI +IMMO/SMK : 39113/4-2G770,39113-2G775
XMA 13MY 2.4GDI -IMMO : 39113/4-2G761[XDC4ME0A/AA/AB/AC/AE]
XMA 13MY 2.4GDI -IMMO : 39113/4-2G761[XDC4MEAD/AF]
XMA 13MY 2.4GDI +IMMO/SMK : 39113/4-2G771[XDC4RE0A/AA/AB/AC/AE]
XMA 13MY 2.4GDI +IMMO/SMK : 39113/4-2G771[XDC4READ/AF]
XMA 14MY 2.4GDI -IMMO : 39113-2GBK0/L0,39114- 2GBK0[FDC4MF3A/G0A/G0B]
XMA 14MY 2.4GDI -IMMO : 39113-2GBK0/L0,39114-2GBK0[FEC4MH2A]
XMA 14MY 2.4GDI +IMMO/SMK : 39113-2GBK5/L5,391142GBK5[FDC4RF3A/G0A/G0B]
XMA 14MY 2.4GDI +IMMO/SMK : 39113-2GBK5/L5,39114-2GBK5[FEC4RH2A]
XMA 15MY 2.4GDI -IMMO : 39113-2GBK1/K2/L1/L2
XMA 15MY 2.4GDI +IMMO/SMK : 39113-2GBK6/K7/L6/L7
2765
2775
2761
2762
2771
2772
1420
1421
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
1425
1426
1322
1327
Page 13 of 15
SUBJECT:
Model
TF
2.4 GDI
Model
SL
2.4 GDI
ECU UPGRADE – MIL ON WITH DTCs P0420/P0171
Menu
Password
TF 11MY 2.4GDI ULEV -IMMO : 39111/2-2G860
TF 11MY 2.4GDI ULEV +IMMO/SMK : 39111/2-2G870
TF 11MY 2.4GDI ULEV -IMMO : 39111/2-2G861
TF 11MY 2.4GDI ULEV +IMMO/SMK : 39111/2-2G871
TF 11MY 2.4GDI SULEV -IMMO : 39111-2G865
TF 11MY 2.4GDI SULEV +IMMO/SMK : 39111-2G875
TF 11MY 2.4GDI SULEV -IMMO : 39111-2G866
TF 11MY 2.4GDI SULEV +IMMO/SMK : 39111-2G876
TF 12MY 2.4GDI ULEV -IMMO : 39111/2-2G863
TF 12MY 2.4GDI ULEV +IMMO/SMK : 39111/2-2G873
TF 12MY 2.4GDI SULEV -IMMO : 39111-2G868
TF 12MY 2.4GDI SULEV +IMMO/SMK : 39111-2G878
TF 13MY 2.4GDI ULEV -IMMO : 39111/2-2G900
TF 13MY 2.4GDI ULEV +IMMO/SMK : 39111/2-2G902
TF 13MY 2.4GDI SULEV -IMMO : 39111-2G901
TF 13MY 2.4GDI SULEV +IMMO/SMK : 39101-2G903
TF F/L 14MY 2.4GDI ULEV -IMMO : 39108/18-2GBE0
TF F/L 14MY 2.4GDI ULEV +IMMO/SMK : 39108/18-2GBF0
TF F/L 14MY 2.4GDI SULEV -IMMO : 39108-2GBE5
TF F/L 14MY 2.4GDI SULEV +IMMO/SMK : 39108-2GBF5
TF F/L 15MY 2.4GDI ULEV -IMMO : 39108/18-2GBE1
TF F/L 15MY 2.4GDI ULEV +IMMO/SMK : 39108-2GBF1
TF F/L 15MY 2.4GDI SULEV -IMMO : 39108-2GBE6
Menu
2860
2870
2861
2871
2865
2875
2866
2876
2863
2873
2868
2878
2900
2902
2901
2903
0820
0821
0825
0826
0822
0823
0827
Password
SL 14MY 2.4GDI ULEV -IMMO : 39107/17-2GCD5/E5
SL 14MY 2.4GDI ULEV +IMMO/SMK : 39107/17-2GCD0/E0
SL 14MY 2.4GDI SULEV -IMMO : 39107-2GCG5
SL 14MY 2.4GDI SULEV +IMMO/SMK : 39107-2GCG0
SL 15MY 2.4GDI ULEV -IMMO : 39107-2GCD6/D7/E6/E7,39117-2GCD6/E6
SL 15MY 2.4GDI ULEV +IMMO/SMK : 39107-2GCD1/D2/E1/E2,39117-2GCD1/E1
SL 15MY 2.4GDI SULEV -IMMO : 39107-2GCG6/7
SL 15MY 2.4GDI SULEV +IMMO/SMK : 39107-2GCG1/2
SL 16MY 2.4GDI ULEV -IMMO : 39107/17-2GCD8/E8
SL 16MY 2.4GDI ULEV +IMMO/SMK : 39107/17-2GCD3/E3
SL 16MY 2.4GDI SULEV -IMMO : 39107-2GCG8
SL 16MY 2.4GDI SULEV +IMMO/SMK : 39107-2GCG3
0725
0720
0726
0721
1726
1721
0727
0722
0728
0723
0729
0724
1.
Within the ECU Upgrade screen, select Manual Mode in the left column, select Engine
and then select Upgrade Event #271, 272, 273, or 274. Select the appropriate control
unit part number by referring to the ROM ID Information Table on Page 5~9, and click OK.
2.
Enter the appropriate password from the table above, and click OK.
3.
Upgrade will begin and the progress of the upgrade will appear on the bar graph.
4.
When the GDS reports that the ECU upgrade has been successfully completed, click OK,
turn OFF the ignition key, and wait at least 10 seconds before attempting to start the
engine.
5.
Check for Diagnostic Trouble Codes using the GDS and erase any DTCs stored such as
EPS, ESC, and TPMS that may have been set during reprogramming.
6.
Start the engine to confirm proper operation of the vehicle.
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 14 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCS P0420/P0171
PARTS INFORMATION:
Model
Part Name
Part Number
Qty.
Warm-Up Catalytic Converter
Optima (QF)
Under-Floor Catalytic Converter
1
Coupled Catalytic Converter
Sorento (XMa)
Warm-Up Catalytic Converter
Under- Floor Catalytic Converter
Warm-Up Catalytic Converter
Optima (TF)
1
Refer to EPC
Under- Floor Catalytic Converter
1
Coupled Catalytic Converter
Sportage (SL)
Warm-Up Catalytic Converter
1
Under- Floor Catalytic Converter
 NOTICE
Refer to EPC for part numbers of related components requiring replacement.
AFFECTED VEHICLE PRODUCTION RANGE:
Model
Production Date Range
Optima (QF)
From August 12, 2011 to October 2, 2015
Sorento (XMa)
From April 19, 2011 to December 11, 2014
Optima (TF)
From August 12, 2010 to July 23, 2015
Sportage (SL)
From September 30, 2013 to November 16, 2015
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016
Page 15 of 15
SUBJECT:
ECU UPGRADE – MIL ON WITH DTCs P0420/P0171
WARRANTY CLAIM INFORMATION:
N CODE: 13T C CODE: ZZ5
Model
Optima
(QF)
Model
Sorento
(XMa)
Model
Optima
(TF)
Model
Sportage
(SL)
Claim
Type
W
Claim
Type
W
Claim
Type
W
Claim
Type
W
Causal
P/N
39108
2GBK8
Causal
P/N
39113
2GBM5
Causal
P/N
39108
2GBE6
Causal
P/N
39107
2GCG8
Qty.
0
Qty.
0
Qty.
0
Qty.
0
Repair
Description
Inspection and
ECU Upgrade
Inspection,
Replacement
of WCC, and
ECU Upgrade
Inspection,
Replacement of
WCC and UCC,
and ECU Upgrade
Repair
Description
Inspection and
ECU Upgrade
Inspection,
Replacement
of WCC, and
ECU Upgrade
Inspection,
Replacement of
WCC and UCC,
and ECU Upgrade
Repair
Description
Inspection and
ECU Upgrade
Inspection,
Replacement
of WCC, and
ECU Upgrade
Inspection,
Replacement of
WCC and UCC,
and ECU Upgrade
Repair
Description
Inspection and
ECU Upgrade
Inspection,
Replacement
of WCC, and
ECU Upgrade
Inspection,
Replacement of
WCC and UCC,
and ECU Upgrade
Labor Op
Code
Time
Replacement
P/N
Qty.
28510F01
0.6 M/H
N/A
0
28510F02
1.2 M/H
Refer to EPC
1
39100F60
1.3 M/H
Refer to EPC
1
Labor Op
Code
Time
Replacement
P/N
Qty.
28510F07
0.6 M/H
N/A
0
28510F08
1.2 M/H
Refer to EPC
1
39100F50
1.3 M/H
Refer to EPC
1
Labor Op
Code
Time
Replacement
P/N
Qty.
28510F05
0.6 M/H
N/A
0
28510F06
1.2 M/H
Refer to EPC
1
39100F80
1.3 M/H
Refer to EPC
1
Labor Op
Code
Time
Replacement
P/N
Qty.
28510F03
0.6 M/H
N/A
0
28510F04
1.2 M/H
Refer to EPC
1
39100F70
1.3 M/H
Refer to EPC
1
TSB: ENG160 (Rev 1) Optima (QF/TF), Sorento (XMa), Sportage (SL) October 2016