FSB 395-001, Rad

Field Service Bulletin
Trucks
Volvo Trucks North America
Greensboro, NC USA
Date
This Field Service Bulletin replaces bulletin “PV729–FSB385–
001_V, Radio Antenna Filter, Installation” (USA77507) dated
6.2016.
9.2016
Group
No.
Release
395 001 02
Page
1(9)
Radio Antenna Filter, Installation
VAH, VHD, VN
FSB 395-001, Radio Antenna Filter, Installation
(September 2016)
On some Volvo Trucks built between August 19, 2014 and August 19, 2016 possible audible
feedback may occur while using the AM/FM bands when the CB microphone is keyed.
Keying the microphone could also cut the volume of the radio when using the AM/FM bands.
This issue has been caused by a filtering problem inside the radio. To correct the issue a
filter should be installed using the following procedure.
Service personnel: Please circulate, read and initial
Service
Manager
Warranty
Administrator
PV729-FSB395-001_V
Workshop
Foreman
Service Technicians
USA79382
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
W3113665
Required Parts Radio Antenna Filter, Install
Item
Description
Part Number
Qty
1
Antenna Filter
22910138
1
Decommissioning the Truck for Repair
You must read and understand the precautions and guidelines in Service Information,
group 30, "General Safety Practices, electrical" before performing this procedure. If you
are not properly trained and certified in this procedure, ask your supervisor for training
before you perform it.
NOTE: Information is subject to change without notice. Illustrations are used for reference
only and can differ slightly from the actual vehicle being serviced. However, key
components addressed in this information are represented as accurately as possible.
1 Park the vehicle on a flat and level surface.
2 Apply the parking brake.
3 Place the transmission in neutral or park.
4 Install the wheel chocks on the front wheels.
W7086748
Page
2(9)
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
5 Disconnect the cable from the battery’s negative terminal.
W3086747
Radio Antenna Filter, Installation
1 Remove the screws holding the access panel in place and remove the top access panel.
W8113747
Page
3(9)
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
2 Remove the screws holding the FRC and position it to allow access to the LCM..
W3113764
3 Disconnect the connectors, remove the screws, and remove the LCM..
W3113767
Page
4(9)
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
4 Disconnect the radio antenna cable connector.
W3113736
5 Connector the radio antenna filter to the antenna cable.
W3113733
Page
5(9)
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
6 Connect the antenna filter to the radio.
W3113792
7 Use cable ties to secure the radio antenna filter as necessary.
W0113768
Page
6(9)
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
8 Install the LCM, connect the connectors, and install and tighten the screws using hand
tools.
W3113767
9 Install the FRC and screws, then torque tighten the screws using hand tools..
W3113764
Page
7(9)
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
10 Install the access panel and install the access panel screws using hand tools..
W8113747
Commissioning the Truck for Operation
1 Connect the battery cable to the negative (ground) terminal.
W3086758
Page
8(9)
Volvo Trucks North America
Field Service Bulletin
Date
9.2016
Group
No.
Release
395
001
02
2 Remove the wheel chocks.
W7086759
Reimbursement
This repair may be eligible for reimbursement if a
product failure was experienced within time and mileage
limits of the applicable Warranty coverage.
Reimbursement is obtained via the normal claim
handling process.
UCHP
Reimbursement
Claim Type (used only when uploading from the Dealer
Bus. Sys.)
W
Labor Code
Primary Labor Code (Radio Antenna Filter, Installation)
3952–02–09–01
0.5 hrs.
Causal Part
22659647, 22659648,
22659649, 22659650,
22659651
VOLVO Trucks North America reserves the right to make any changes in design or to make
additions to or upon its products without incurring any obligations to install the same on
vehicles previously built.
Page
9(9)