TSBENG162

GROUP
ENG
MODEL
2017MY
Multiple Models
(see table on Page 13)
NUMBER
162
DATE
June 2017
TECHNICAL SERVICE BULLETIN
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS
DATA FROM ECU (DC17)
This bulletin provides information related to extracting “in use performance tracking”
emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The
California Air Resources Board (CARB) requires the emissions data from vehicles with a
minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate
collection of this data at the dealer level, KDS screenshots will allow the capture of relevant
parameters.
 NOTICE
If the vehicle meets the criteria below, California dealers must perform this data
collection on vehicles whenever an affected vehicle is in the shop for any
maintenance or repair.
This data collection does not apply to vehicles or dealers operating outside of
California.
Once sufficient data is collected, individual line items per model may be closed
without updates to the TSB. Once a line item is closed on DCS, no further data
collection is required. Data collections initiated after a line item is closed are
subject to chargeback.
For vehicles listed on DCS as requiring this procedure, follow the instructions in this
bulletin after confirming that the following criteria are met:

WebDCS shows this as an open Data Collection code DC17XXXX ( depending
on model; see table on page 13) for the vehicle.

Vehicle has more than 3,000 accumulated miles on its odometer.

Vehicle repair history does not show battery replacement/disconnection/reset or an
ECU update done in the last 3,000 miles, because IUMPR (In Use Monitor
Performance Ratio) data would have been cleared by such an event.

Vehicle does not have the check engine light on.
File Under: 
Circulate To:
X General Manager

X Service Advisors

X Technicians

X Service Manager

X Parts Manager

X Body Shop Manager  Fleet Repair

Page 2 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
 NOTICE
If a vehicle meets the above criteria, collect data prior to any other campaign or
repair-related activities.
KDS Service Procedure:
Open the engine compartment and
1.
locate the Vehicle Emission Control
Information label.
Write down the “Group” number for
later entry into the form.
2.
With the ignition key on, insert the VCI
II into the DLC and swipe down on the
Vehicle Selection area to identify the
vehicle.
 NOTICE
Screens shown in this bulletin
are for demonstration ONLY
purposes
and
will
vary
depending on the vehicle.
TSB: ENG162 Multiple Models June 2017
Page 3 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
3.
Click AUTO VIN, and then click OK.
4.
Once back on the KDS Home Screen,
click OBD-II.
TSB: ENG162 Multiple Models June 2017
Page 4 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
5.
Click In USE Performance Ratio >
Gasoline.
6.
Click the Screen Capture button to
save a screenshot of the data.
7.
Click the Save button to save the
screenshot.
TSB: ENG162 Multiple Models June 2017
Page 5 of 13
SUBJECT:
8.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
The KDS will set up a destination
folder and file name to save the
screenshot.
Change the file name to include the
model/engine, the last 6 digits of the
VIN, and the date (mmddyyyy), as
shown below.
Example: XM33L_576681_06092015
(Model & Eng.) (VIN) (mmddyyyy)
9.
Click OK to save the image.
XM33L_576681_06092015
10
Click the Return Arrow on the screen,
and then click the HOME button to return
to the KDS Home Screen.
 NOTICE
Steps 11~17 will need to be
performed
only once
to
properly set up KDS for this
Data Collection procedure.
If Chrome is already the
default KDS browser, proceed
to step 12.
If access to the External
Storage has already been
added to the file manager,
proceed to step 18.
TSB: ENG162 Multiple Models June 2017
Page 6 of 13
SUBJECT:
11.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
First, set Chrome as the default
browser.
If this step has been previously done,
proceed to step 12.
If not, refer to the following Article in
KGIS: “KDS-Configuring Browser for
Techline and Feedback Cases” for
more information.
12.
Once Chrome is set as the default
browser, navigate to the KDS Home
Screen and then click Feedback.
NOTE: Steps 12~17 will add access
to Internal and External Storage to
the file manager.
13.
Click one of the Choose File buttons
at the bottom of the screen.
14.
Click Documents.
TSB: ENG162 Multiple Models June 2017
Page 7 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
15.
Click the Settings button in the upper
right hand corner.
16.
Click the check box for Show
advanced device opt. and Show file
size as shown.
17.
Access to Internal and External
Memory (i.e., SD card) is now
available on the left hand side of the
file manager.
Internal
TSB: ENG162 Multiple Models June 2017
Page 8 of 13
SUBJECT:
18.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
Return to the KDS Home Screen
and click Feedback (page 10, step
12).
Enter all the information requested
in the form, including your name
and email address, and the
following information:
•
•
For System, enter Engine
For Subject, enter Data
Collection
• In the Description area,
○ Enter Group: followed by
the group number from the
Vehicle Emission Control
Information Label collected
in page. 7, step 1.
○ Enter the current odometer
mileage.
○ Enter the RO#.
 NOTICE
Make sure the email address is
entered
correctly
or
the
Feedback form will fail to
submit.
19.
To attach the screenshot to the report,
click Choose File.
TSB: ENG162 Multiple Models June 2017
GROUP:XXXXXXXXXXX
CURRENT ODOMETER MILEAGE: XXXXXX
RO#: XXXXXXXXXXX
Page 9 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
20.
Click Documents.
21.
Click External Storage > Android.
SD Card
22.
Click data.
23.
Scroll
down
gitauto.GDSM.
and
then
click
TSB: ENG162 Multiple Models June 2017
Page 10 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
24.
Click files.
25.
Click mvcidata.
26.
Click Record.
TSB: ENG162 Multiple Models June 2017
Page 11 of 13
SUBJECT:
27.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
Click the vehicle model.
Sorento (XMa)
June 15
28.
Click the VIN.
5XYKWDA7XEG437824
June 15
29.
Click the screenshot.
5XYKWDA7XEG437824
XM33L_576681_06092015
June 15
1.21MB
TSB: ENG162 Multiple Models June 2017
Page 12 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
30. Click Submit.
 NOTICE
Ensure that you attach the
correct
files.
Incorrect
attachments
render
data
submissions useless and are
subject to chargeback of the
warranty claim.
GROUP:XXXXXXXXXXX
CURRENT ODOMETER MILEAGE: XXXXXX
RO#: XXXXXXXXXXX
AFFECTED PRODUCT RANGE:
Model
Production Date Range
Sportage (QL) 2.0T, 2.4
Rio (UB) 1.6
Sedona (YP) 3.3
Sorento (UM) 2.0T, 2.4, 3.3
K900 (KH) 3.8, 5.0
Optima (JF) HEV 2.0, PHEV 2.0, 1.6T, 2.0T, 2.4
Forte (YD) 2.0, 1.6T
Soul (PS) 1.6, 1.6T, 2.0
Cadenza (YG) 3.3
Niro (DE) HEV 1.6
2017MY
(Sold in California only)
TSB: ENG162 Multiple Models June 2017
Page 13 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
SUBJECT:
2017MY DATA COLLECTION WARRANTY CLAIM INFORMATION:
 NOTICE
Once sufficient data is collected, individual line items per model may be closed
without updates to the TSB. Once a line item is closed on DCS, no further data
collection is required. Data collections initiated after a line item is closed are subject
to chargeback.
Campaign
ID
Claim
Type
Causal
P/N
Qty.
N.
Code
C.
Code
DC17QL1
DC17QL2
DC17QL3
DC17UB1
DC17YP1
DC17UM1
DC17UM2
DC17UM3
DC17KH1
DC17KH2
DC17JFH1
DC17JFP1
DC17JF1
DC17JF2
DC17JF3
DC17JF4
DC17YD1
DC17YD2
DC17YD3
DC17PS1
DC17PS2
DC17PS3
DC17YG1
DC17DE1
V
100CA
EM999
0
N99
C99
Repair
Description
Sportage 2.0T
50/FD
Sportage 2.4
CA
Sportage 2.4
50/FD
Rio 1.6
50/FD
Sedona 3.3
50/FD
Sorento 2.0T
50/FD
Sorento 2.4
50/FD
Sorento 3.3
50/FD
K900 3.8
50/FD
K900 5.0
50/FD
Optima HEV 2.0
50/FD
Optima PHEV 2.0
50/FD
Optima 1.6T
50/FD
Optima 2.0T
50/FD
Optima 2.4
CA
Optima 2.4
50/FD
Forte 2.0
CA
Forte 2.0
50/FD
Forte 1.6T
50/FD
Soul 1.6
50/FD
Soul 1.6T
50/FD
Soul 2.0
50/FD
Cadenza 3.3
50/FD
Niro HEV 1.6
50/FD
Labor Op
Code
Time
Replacement
P/N
Qty.
0.3
M/H
N/A
0
17QL20F1
17QL24C1
17QL24F1
17UB16F1
17YP33F1
17UM20F1
17UM24F1
17UM33F1
17KH38F1
17KH50F1
17JFH20F
17JFP20F
17JF16F1
17JF20F1
17JF24C1
17JF24F1
17YD20C1
17YD20F1
17YD16F1
17PS16F1
17PS16F2
17PS20F1
17YG33F1
17DE16F1
TSB: ENG162 Multiple Models June 2017