Kia Optima 2017

• Recall 233151 [USA]: A person inside the trunk compartment may become trapped, increasing their risk of injury.
  Kia america, inc. (kia) is recalling certain 2016-2017 rio, 2016-2018 optima, 2017-2018 optima hybrid and optima plug-in hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 401, "internal trunk release."
  dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed october 19, 2023. Owners may contact kia customer service at 1-800-333-4542. Kia's number for this recall is sc278.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.

  Show Content

• Recall 187773 [USA]: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
  Kia motors america (kia) is recalling certain 2017-2018 optima hybrid and optima plug-in hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which can result in engine damage.
  dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a knock sensor detection system (ksds). Repairs will be performed free of charge. Owner notification letters were mailed november 29, 2021. Owners may contact kia customer service at 1-800-333-4542. Kia's number for this recall is sc218.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.

  Show Content

• Recall 130144 [USA]: A fuel leak in the presence of an ignition source can increase the risk of a fire.
  Kia motors america (kia) is recalling certain 2011-2017 optima, 2012-2017 sorento and 2011-2018 sportage vehicles that previously received an engine replacement under recall number 17v-224, warranty, or the knock sensor detection system (ksds) product improvement campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
  kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began january 17, 2019. Owners may contact kia customer service at 1-800-333-4542. Kia's number for this recall is sc172.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 139326 [USA]: If the vpd activates while the vehicle is being operated in electric vehicle (ev) mode, there may be a loss of power, increasing the risk of a crash.
  Kia motors america (kia) is recalling certain 2017-2018 kia optima hybrid vehicles. These vehicles are equipped with a voltage protection device (vpd), designed to protect the high voltage battery module, that may activate inadvertently.
  kia will notify owners, and dealers will remove the vpd switch and install two newly designed battery management systems (bms) that contain overvoltage protection devices (opds), free of charge. The recall is expected to begin may 2018. Owners may contact kia customer service at 1-800-333-4542. Kia's number for this recall is sc162.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall R/2018/123 [UK]: High voltage battery system may malfunction and cause a sudden loss of power
  Incorrect operation of the voltage protection device (vpd) may lead to the high voltage battery system intermittently switching off the hybrid electric vehicle (hev) motor whilst driving. If the fault occurs a warning light will be displayed on the dashboard and the vehicle could suffer a sudden loss of power.
  replace the battery management system (bms) main and sub units and wiring loom

  Show Content

• Recall R/2019/259 [UK]: The forward collision avoidance assist may fail to identify stationary vehicles
  The forward collision avoidance assist system may have problems identifying stationary cars.
  upgrade the software for the multi-function camera system.

  Show Content

• Recall 2021666 [Canada]: Engine
  Issue: on certain vehicles equipped with a 2.0 l nu gdi engine the connecting rod bearings can become damaged. If this happens, the engine could make abnormal knocking noises and/or the oil pressure warning light may turn on. If you continue to drive the vehicle with these symptoms, the engine could fail and/or a fire could occur. An engine failure can cause a sudden loss of power with an inability to restart. Note: only the optima hybrid and plug-in hybrid (phev) models are affected by this recall. Safety risk: a sudden loss of engine power could increase the risk of a crash. An engine failure could also create the risk of a fire. Corrective actions: kia will notify owners by mail and instruct you to take your vehicle to a dealer for an engine inspection test, to determine if there is bearing damage. If damage is found, the engine will be replaced. Dealers will also install a knock sensor detection system (ksds) software that will prevent engine damage from potential excessive connecting rod bearing wear. Note: kia recommends that you should always follow the correct vehicle maintenance schedule, which is printed in the owner's manual. If you experience unusual engine noise, reduced power, or a check engine/oil warning light, kia advises you to immediately visit a kia dealership to have your vehicle diagnosed.

  Show Content

• Recall 2019143 [Canada]: Engine
  Issue: kia canada is conducting a product improvement campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure may cause a sudden loss of power with an inability to restart. Safety risk: a sudden loss of engine power could increase the risk of a crash. Corrective actions: the company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: vehicles repaired under service campaign sc023 already have this software update.

  Show Content

• Recall 2019098 [Canada]: Fuel supply
  Issue: when the engine was replaced under warranty or under kia's product improvement campaign sc023, the high pressure fuel pipe may not have been properly installed on the fuel pump outlet. A fuel leak could occur if the pipe was damaged, misaligned or improperly torqued during the recall repair. Safety risk: leaking fuel in the presence of an ignition source could increase the risk of a fire. Corrective actions: the company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer for an inspection. If fuel leakage is detected, the fuel pipe will be replaced with a new one.

  Show Content

• Recall 2018132 [Canada]: Powertrain
  On certain plug-in hybrid vehicles, the battery voltage protection device (vpd) switch could inadvertently activate. If the vpd switch is activated, electricity to the vehicle's electric motor may be disconnected. If this occurs while the vehicle is driven under electric vehicle (ev) mode, the vehicle may experience a loss of motive power, which could increase the risk of a crash causing injury and/or property damage. Correction: dealers will remove the current vpd switch and install two newly designed battery management systems containing new overvoltage protection devices. The corresponding wiring harness will also be installed. Note: this condition would result in the of the “check hybrid system" warning light illuminating.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

The following is a list of any known keyfobs for the Kia Optima 2017 as well as their FCC IDs if available

• EKB-KIA-D4060: 2016-2018 Kia Optima / Emergency Key / LXP90 / PN: 81999-D4060 (OEM)
• RFK-KIA-022: 2016-2020 Kia Optima / 4-Button Flip Key / PN: 95430-D4010 / SY5JFRGE04 (JF 4BT) (AFTERMARKET)
  FCC ID: SY5JFRGE04
• RFK-KIA-D4010: 2016-2020 Kia Optima / 4-Button Flip Key / PN: 95430-D4010 / SY5JFRGE04 (JF 4BT) (OEM)
  FCC ID: SY5JFRGE04 (JF (JF4BT)
• RFK-KIA049: 2016-2020 Kia Optima / 4-Button Flip Key / PN: 95430-D4010 / SY5JFRGE04 (JF 4BT) (OEM Refurb)
  FCC ID: SY5JFRGE04
• RSK-KIA-OPT: 2016-2020 Kia Optima / 4-Button Smart Key / PN: 95440-D4000 / SY5JFFGE04 (AFTERMARKET)
  FCC ID: SY5JFFGE04
• RSK-KIA-D4000: 2016-2020 Kia Optima / 4-Button Smart Key / PN: 95440-D4000 / SY5JFFGE04 (OEM)
  FCC ID: SY5JFFGE04
• RSK-ULK155: 2016-2020 Kia Optima / 4-Button Smart Key / PN: 95440-D4000 / SY5JFFGE04 (OEM Refurb)
  FCC ID: SY5JFFGE04
• SKS-KIA-OPT: 2016-2020 Kia Optima / 4-Button Smart Key SHELL / PN: 95440-D4000 / SY5JFFGE04 (AFTERMARKET)
  FCC ID: SY5JFFGE04
• EKB-KIA-1511-308: 2016-2021 Kia Optima Niro Rio / Emergency Key / LXP90 / PN: 81999-D4060 (AFTERMARKET)
• 3xRFK-KIA049: 3 x 2016-2020 Kia Optima / 4-Button Flip Key / PN: 95430-D4010 / SY5JFRGE04 (JF 4BT) (OEM Refurb) (BUNDLE OF 3)
  FCC ID: SY5JFRGE04 (JF (JF4BT)

• Pedestrian alert sounds investigation # DP22005

  Nhtsa received a petition on or about july 18, 2022, requesting that federal motor vehicle safety standard (fmvss) 141 be applied to all electric and hybrid vehicles operating in the united states. The petition can be reviewed at nhtsa.Gov under odi number 11486072. Fmvss 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 kg or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after march 1, 2021.On january 27, 2023, nhtsa opened defect petition (dp) 22-005 to evaluate the subject matter described in the petition. On june 24, 2023 and as supplemented on june 25, 2023, the petitioner notified nhtsa he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioners withdrawal, dp22-005 is closed. Closure of this dp does not represent a determination by nhtsa regarding the subject matter of the petition.
  

  Show Content

• Loss of motive power investigation # DP22003

  The office of defects investigation (odi) has received a petition on july 13, 2022, requesting a defect investigation into an alleged defect of the "oil drain pan assemblies" on the following 83 models/model year vehicles stated by the petitioner: 2006-2019 hyundai sonata, 2013-2018 hyundai santa fe sport, 2010-2012 and 2019-2020 hyundai santa fe, 2010-2015 and 2018-2019 hyundai tucson, 2011-2021 kia sportage 2005-2020 kia optima, 2011-2020 kia sorento, 2010-2013 kia forte, 2010-2013,kia forte coup, and 2007-2010 kia rondo vehicles equipped with the 1.6l t-gdi gamma, 2.4l theta ii gdi, 2.4l in-line gdi theta ii, kappa, and 3.8l v-shaped gdi lambda-ii engines. The petition also cites additional hyundai/kia vehicles that use similar drain pan assemblies as the above-mentioned vehicles as having drain pan assembly failures. The petitioner provided subject and peer vehicles information related to alleged engine failures. The petition itself can be reviewed at nhtsa.Gov under odi number 11481745.According to the petition, the hyundai/kia vehicle owners have made allegations of oil leakage failures occurring at highway speeds, without malfunction, indicator lights, or the leakage associated with under-tightening an oil drain plug, or a plug or pan with damaged thread. The alleged defects are causing engines to seize and loss of motive power. A defect petition has been opened to evaluate the issue and determine whether to grant or deny the petition. The petitioner identified a number of complaints received by nhtsa alleging complete engine failure from a variety of models stated above along with other models. The odi complaints cited in the petition can be reviewed at nhtsa.Gov under the following odi numbers: 11481745, 11433038, 11366918, 11431200, 11320689, 11245086, 11196311, 11114946, 11114946, 11097819.
  

  Show Content

• Engine fires investigation # EA21003

  There is no summary currently available
  

  Show Content

• Air bag acu electrical overstress investigation # EA19001

  The office of defects investigation (odi) is expanding the investigation to include the equipment supplier and vehicle manufacturers (oems) using this unit.The investigation focuses on acus manufactured by trw, now zf-trw (zf) , the tier-one supplier to hyundai and kia and the other affected oems.The acu senses a vehicle crash to determine whether air bag deployment is required, and if so, deploys the appropriate air bags and other supplemental restraints.Zf supplied subject acus to six oems: fca, honda, hyundai, kia, mitsubishi and toyota.Internal to the acu is an electronic component (an application specific integrated circuit, or asic) that monitors signals from crash sensors.A failure of the asic may prevent deployment of the required air bags and devices, or may otherwise affect the proper operation of the acu.The acu is located in the passenger compartment, and electrical wiring connects the asic to sensors located at the front of the vehicle.Odi’s current understanding is that a crash event may, in and of itself, produce harmful signals on the sensor wiring capable of damaging the asic, although the probability of this occurring appears to be low.While the acu incorporates electrical circuitry intended to protect the asic from harmful signals, the level and effectiveness of the protective circuitry varies by oem customer.During pe18-003, hyundai and kia filed recalls (18v-137 and 18v-363 respectively) to address a defect that could result in acu disablement and non-deployments.According to the filings, the disablement occurs in certain types of frontal crash events.Both filings discussed a condition known as electrical overstress (eos) that affected the subject asic and was likely caused by electrical signals that entered the acu via sensor wiring.The recalled vehicles used acus that had the lowest levels of asic protection while non-recalled hyundai and kia products using subject acus had higher levels of protection.Odi has not identified any eos failures in the non-recalled kia and hyundai populations.In september 2016, fca filed recall 16v-668 for certain model year (my) 2010 to 2014 chrysler, dodge and jeep products also manufactured with the subject acu.In that filing, fca also discussed an eos condition that resulted in a failure of the subject asic, which caused air bag non-deployment. Fca noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle.Other fca vehicles that also used the subject acu, but not the cross-car harnessing, had not experienced eos failures, despite similar time in service. The recalled fca vehicles used a mid-level form of asic protection.Other fca vehicles that did not use cross car wiring, or used higher levels of asic protection, have not been recalled.Odi has not identified any eos failures in the non-recalled fca population.Recently, odi has identified two substantial frontal crash events (one fatal) involving toyota products where eos is suspected as the likely cause of the non-deployments.The crashes involved a my 2018 and a my 2019 corolla equipped with the subject acu that incorporated higher levels of asic protection.Additionally, both acus were found to be non-communicative (meaning the acu could not be read with an event data recorder) after the crash, a condition found in other cases where eos occurred with other oems.No other eos events have been identified for other toyota products (including corolla models that used the subject acu since my 2011), or for the honda and mitsubishi vehicles that use the subject acu.Odi plans to evaluate the susceptibility of the subject acu designs to electrical signals, as well as other vehicle factors that can either lead to, or reduce the likelihood of, an eos event.Additionally, odi will evaluate whether an unreasonable risk exists that requires further field action.
  

  Show Content

My 2017 kia optima hybrid began losing oil rapidly (more than 1 quart a week), and then knocking. There was never a warning light or an engine light. The mechanic at kirby kia (the dealership) confirmed engine knocking in the lower pistons. Kia will not honor the 100,000 mile drive train warranty because i am the second owner, and there is no recall on the hybrid engine. However, it's irrelevant that they won't cover the cost of the engine since they are not making engines available to anyone outside of the recall, so i cannot fix my car. I'm a little confused on why this engine is withheld for the recall, but mine is not recalled.

Engine has too much oil consumption , went to do my oil change 200 miles before it was due and the automotive place told me there was no oil on my drip stick. Also have a rattling noise in my engine when i accelerate. Noise has been happening for a few months but they can't seem to find a problem.

Engine has too much oil consumption , went to do my oil change 200 miles before it was due and the automotive place told me there was no oil on my drip stick. Also have a rattling noise in my engine when i accelerate. Noise has been happening for a few months but they can't seem to find a problem.

The wiring harness was replaced in my 2017 kia optima in 2019 at approximately 45,000 miles. Kia replaced my engine january 2020 because it was consuming large amounts of oil. I just got my car back in january 28, 2021 with a supposedly new engine. On march 3, 2021, my car caught fire while pulling out of my neighborhood actually driving down the street. Smoke and flames were coming out from underneath the hood the of the car. The entire front end of the car burned. Thankfully, the fire department got the fire out and no one was injured.

The wiring harness was replaced in my 2017 kia optima in 2019 at approximately 45,000 miles. Kia replaced my engine january 2020 because it was consuming large amounts of oil. I just got my car back in january 28, 2021 with a supposedly new engine. On march 3, 2021, my car caught fire while pulling out of my neighborhood actually driving down the street. Smoke and flames were coming out from underneath the hood the of the car. The entire front end of the car burned. Thankfully, the fire department got the fire out and no one was injured.

The wiring in these cars are coated with something that small rodents like to eat they chew through the tape then then wiring. Causing hybrid engine not to work lites come. Luckly no fire yet. Dealer say sorry that will be $ the cars wiring hybrid part . Rodents like to eat it kia has coating on it that attracts them then it costs you thousands of dollars to fix their problem cause it's not covered by them. Luckly the car did not caught on fire yet.

The wiring in these cars are coated with something that small rodents like to eat they chew through the tape then then wiring. Causing hybrid engine not to work lites come. Luckly no fire yet. Dealer say sorry that will be $ the cars wiring hybrid part . Rodents like to eat it kia has coating on it that attracts them then it costs you thousands of dollars to fix their problem cause it's not covered by them. Luckly the car did not caught on fire yet.

The headlights will go off no matter if the switch is on auto or normal on. The lights cut off while driving, it happens on the street, highway, and even if the car isn't moving. It started about a month ago. There hasn't been any damage or wrecks to my car.

The headlights will go off no matter if the switch is on auto or normal on. The lights cut off while driving, it happens on the street, highway, and even if the car isn't moving. It started about a month ago. There hasn't been any damage or wrecks to my car.

Common OBD-II Error Codes

• P1326 [17] Knock control, cylinder 1 - control limit reached
• P0442 [2] Evaporative Emission Control System Leak Detected (small leak)
• P0456 [2] Evaporative Emissions System Small Leak Detected
• P0128 [1] Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature)
• C2702 [1] C2702
• P0303 [2] Cylinder 3 Misfire Detected