TSBENG162R1

GROUP
ENG
MODEL
2017MY
Multiple Models
(see table on Page 12)
NUMBER
162 (Rev 1, 09/xx/2017)
DATE
June 2017
TECHNICAL SERVICE BULLETIN
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS
DATA FROM ECU (DC17)
 NOTICE
This bulletin has been revised to include additional information. New/revised
sections of this bulletin are indicated by a black bar in the margin area.
This bulletin provides information related to extracting “in use performance tracking”
emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The
California Air Resources Board (CARB) requires the emissions data from vehicles with a
minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate
collection of this data at the dealer level, KDS screenshots will allow the capture of relevant
parameters.
 NOTICE
If the vehicle meets the criteria below, California dealers must perform this data
collection on vehicles whenever an affected vehicle is in the shop for any
maintenance or repair.
This data collection does not apply to vehicles or dealers operating outside of
California.
Once sufficient data is collected, individual line items per model may be closed
without updates to the TSB. Once a line item is closed on DCS, no further data
collection is required. Data collections initiated after a line item is closed are
subject to chargeback.
File Under: 
Circulate To:
X General Manager

X Service Advisors

X Technicians

X Service Manager

X Parts Manager

X Body Shop Manager  Fleet Repair

Page 2 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
SUBJECT:
For vehicles listed on DCS as requiring this procedure, follow the instructions in this
bulletin after confirming that the following criteria are met:

WebDCS shows this as an open Data Collection code DC17XXXX ( depending
on model; see table on page 13) for the vehicle.

Vehicle has more than 3,000 accumulated miles on its odometer.

Vehicle repair history does not show battery replacement/disconnection/reset or an
ECU update done in the last 3,000 miles, because IUMPR (In Use Monitor
Performance Ratio) data would have been cleared by such an event.

Vehicle does not have the check engine light on.
 NOTICE
If a vehicle meets the above criteria, collect data prior to any other campaign or
repair-related activities.
KDS Service Procedure:
 NOTICE
The KDS tablet MUST have a SD Card installed for this procedure.
1.
Open the engine compartment and
locate the Vehicle Emission Control
Information label.
Write down the “Group” number for
later entry into the form.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 3 of 13
SUBJECT:
2.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
With the ignition key on, insert the VCI
II into the DLC and swipe down on the
Vehicle Selection area to identify the
vehicle.
 NOTICE
Screens shown in this bulletin
are for demonstration ONLY
purposes
and
will
vary
depending on the vehicle.
3.
Click AUTO VIN, and then click OK.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 4 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
4.
From the KDS Home Screen, click
OBD-II.
5.
Click In USE Performance Ratio >
Gasoline.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 5 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
SUBJECT:
6.
Click the Screen Capture button to
save a screenshot of the data.
 NOTICE
DO NOT use the Home/Power
button for the screen capture.
If the data list is longer than one (1)
page, scroll down and take another
screen capture.
 NOTICE
A SD Card must be inserted into
the KDS tablet to save KDS
images.
7.
8.
Click Save to save the image.
The KDS will set up a destination
folder and file name to save the
screenshot.
Change the file name to include the
model/engine, the last 6 digits of the
VIN, and the date (mmddyyyy), as
shown below.
Example:
XM33L_576681_06092015
(Model
(mmddyyyy)
&
Eng.)
(VIN)
Click Save.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 6 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
SUBJECT:
9.
Click the Return Arrow on the screen,
and then click the HOME button to
return to the KDS Home Screen.
10.
Set Chrome as the default browser,
then proceed to step 11.
If not, refer to the following Article in
KGIS: “KDS-Configuring Browser for
Techline and Feedback Cases” for
more information.
11.
Once Chrome is set as the default
browser, navigate to the KDS Home
Screen and then click Feedback.
12.
Enter all the information requested
in the form, including your name
and email address, and the
following information:
•
•
For System, enter Engine
For Subject, enter Data
Collection
• In the Description area,
○ Enter Group: followed by
the group number from the
Vehicle Emission Control
Information Label collected
in page 2, step 1.
○ Enter the current odometer
mileage.
○ Enter the RO#.
 NOTICE
Make sure the email address is
entered
correctly
or
the
Feedback form will fail to
submit.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 7 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
13.
Click one of the Choose File buttons
at the bottom of the screen.
14.
Click Documents
15A. (Steps 15A and 15B apply to the
Samsung Tab 10.1 (older tablet))
Click the Settings button in the upper
right hand corner.
15B. Verify an SD Card is displayed in the
left pane as a number (e.g., 1899C039).
If not, click Show SD card.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 8 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
16A. (Steps 16A and 16B apply to the
Samsung Tab S2 image (newer tablet)).
Click the Recent button.
16B. This will provide access to the SD
Card.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 9 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
SUBJECT:
17.
Access to Internal and External
Memory (i.e., SD Card) is available on
the left hand side of the file manager.
External / SD Card
 NOTICE
Always select the SD Card to
save the images from this data
collection procedure. DO NOT
select internal storage.
Internal
18.
With the External/SD Card selected,
click Android.
19.
Click data.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 10 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
20.
Scroll
down
gitauto.GDSM.
21.
Click files.
22.
Click mvcidata.
23.
Click Record.
and
then
click
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 11 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
SUBJECT:
24.
Click the vehicle model (e.g., Sorento
(XMa)).
Sorento (XMa)
June 15
25.
Click the VIN.
5XYKWDA7XEG437824
June 15
26.
Click the screenshot.
5XYKWDA7XEG437824
XM33L_576681_06092015
June 15
27.
1.21MB
Click Submit.
 NOTICE
Ensure that you attach the
correct
files.
Incorrect
attachments
render
data
submissions useless and are
subject to chargeback of the
warranty claim.
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 12 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
AFFECTED PRODUCT RANGE:
Model
Production Date Range
Sportage (QL) 2.0T, 2.4
Rio (UB) 1.6
Sedona (YP) 3.3
Sorento (UM) 2.0T, 2.4, 3.3
K900 (KH) 3.8, 5.0
Optima (JF) HEV 2.0, PHEV 2.0, 1.6T, 2.0T, 2.4
Forte (YD) 2.0, 1.6T
Soul (PS) 1.6, 1.6T, 2.0
Cadenza (YG) 3.3
Niro (DE) HEV 1.6
2017MY
(Sold in California only)
TSB: ENG162 (Rev 1) Multiple Models June 2017
Page 13 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC17)
SUBJECT:
2017MY DATA COLLECTION WARRANTY CLAIM INFORMATION:
 NOTICE
Once sufficient data is collected, individual line items per model may be closed
without updates to the TSB. Once a line item is closed on DCS, no further data
collection is required. Data collections initiated after a line item is closed are subject
to chargeback.
Campaign
ID
Claim
Type
Causal
P/N
Qty.
N.
Code
C.
Code
DC17QL1
DC17QL2
DC17QL3
DC17UB1
DC17YP1
DC17UM1
DC17UM2
DC17UM3
DC17KH1
DC17KH2
DC17JFH1
DC17JFP1
DC17JF1
DC17JF2
DC17JF3
DC17JF4
DC17YD1
DC17YD2
DC17YD3
DC17PS1
DC17PS2
DC17PS3
DC17YG1
DC17DE1
V
100CA
EM999
0
N99
C99
Repair
Description
Sportage 2.0T
50/FD
Sportage 2.4
CA
Sportage 2.4
50/FD
Rio 1.6
50/FD
Sedona 3.3
50/FD
Sorento 2.0T
50/FD
Sorento 2.4
50/FD
Sorento 3.3
50/FD
K900 3.8
50/FD
K900 5.0
50/FD
Optima HEV 2.0
50/FD
Optima PHEV 2.0
50/FD
Optima 1.6T
50/FD
Optima 2.0T
50/FD
Optima 2.4
CA
Optima 2.4
50/FD
Forte 2.0
CA
Forte 2.0
50/FD
Forte 1.6T
50/FD
Soul 1.6
50/FD
Soul 1.6T
50/FD
Soul 2.0
50/FD
Cadenza 3.3
50/FD
Niro HEV 1.6
50/FD
Labor Op
Code
Time
Replacement
P/N
Qty.
0.3
M/H
N/A
0
17QL20F1
17QL24C1
17QL24F1
17UB16F1
17YP33F1
17UM20F1
17UM24F1
17UM33F1
17KH38F1
17KH50F1
17JFH20F
17JFP20F
17JF16F1
17JF20F1
17JF24C1
17JF24F1
17YD20C1
17YD20F1
17YD16F1
17PS16F1
17PS16F2
17PS20F1
17YG33F1
17DE16F1
TSB: ENG162 (Rev 1) Multiple Models June 2017