A351619 2032211-
Service Bulletin Details
Public Details for: A351619 2032211-
- 2014 - 2013 - 2012 - 2011 - 2010 -
Models from 2014
| 2014 AUDI RS5 |
| 2014 AUDI S4 |
| 2014 AUDI S5 |
| 2014 AUDI S5 CABRIOLET |
| 2014 AUDI S6 |
| 2014 AUDI S7 |
Models from 2013
| 2013 AUDI RS5 |
| 2013 AUDI RS5 CABRIOLET |
| 2013 AUDI S4 |
| 2013 AUDI S5 |
| 2013 AUDI S6 |
| 2013 AUDI S7 |
Models from 2012
| 2012 AUDI A5 CABRIOLET |
| 2012 AUDI S4 |
Models from 2011
| 2011 AUDI A5 CABRIOLET |
| 2011 AUDI S4 |
Models from 2010
| 2010 AUDI A5 CABRIOLET |
| 2010 AUDI S4 |
Technical Service Bulletin 35 Gearbox warning light on (DTCs P179E00, P179F00, P0700, P060A) 35 16 19 2032211/3 January 11, 2016. Supersedes Technical Service Bulletin Group 35 number 14-17 dated September 25, 2014 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment S4, S5 Cabriolet 2010 - 2014 All 0B5 S tronic S5, RS5, S6, S7 2013 - 2014 All 0B5 S tronic Condition REVISION HISTORY Revision Date Purpose 3 - Revised Condition (Additional DFCC codes) 2 9/25/2014 Revised header data (Added S5, S6, S7, and RS5 models; added model years 2013 and 2014; added DTCs) Revised Required Parts and Tools (Part numbers updated) 1 12/21/2012 Initial publication • The driver information system displays the message “Gearbox malfunction: you can continue driving”. • One of the following scenarios is present: Scenario 1: The following entries are logged individually or in combination, with P179E logged first (using DTC environmental data). In this scenario, if DTC P179E is not logged first, this TSB does not apply: • DTC P179E (Drive position sensor electrical error) • DTC P0700 with DFCC 20196 (Transmission control system malfunction) • DTC P1758 with DFCC 8464 (Terminal 15 voltage supply open circuit) • DTC P060A with DFCC 8126, 8345 (Internal control module monitoring processor performance) Scenario 2: The following entries are logged individually or in combination. The order in which the DTCs are logged is not relevant: • DTC P179E with DFCC 8050, 8051, 8052, 8053, 17595, 17596, 17597, 17598, 17602 (Drive position sensor electrical error) • DTC P179F with DFCC 8054, 8055, 8056, 8057, 17599, 17600, 17601 (Drive position sensor malfunction) • DTC P0716 with DFCC 8096, 8101, 18153, 20738 (Input turbine/speed sensor “A” circ. range/performance) © 2016 Audi of America, Inc. Page 1 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin • DTC P171F with DFCC 8097, 8102, 18154 (Transmission input speed (RPM) sensor 2 implausible signal) • DTC P0715 with DFCC 8094, 8103, 18161 (Input turbine/speed sensor “A” circuit.) • DTC P2765 with DFCC 8095, 8104 (Input turbine/speed sensor “B” circuit) • DTC P0501 with DFCC 8098 (Vehicle speed sensor “A” range/performance) • DTC P2159 with DFCC 8099 (Vehicle speed sensor “B” range/performance) Tip: Fault codes and DFCC codes must match exactly for this TSB to apply. The DFCC is the 4-6 digit code that is typically listed before the fault code (Figure 1). Figure 1. DFCC 4-6 digit code listed before the fault code, underlined in red. Technical Background Incorrect driving mode sensor module. Production Solution Not applicable. Service If the Condition matches exactly, replace the G676 sensor module with circuit board by following instructions in Elsa >> Repair manual >>Transmission >>S Tronic Transmission Internal Components >>35 Gears, Shafts >>Removal and Installation >> Sensor Module with Transmission Input Speed Sensor -G612-,-G632-, -G676- and Circuit Board 3. When replacing the sensor module, its wiring loom must also be replaced. Note: These instructions require transmission case disassembly. Audi Academy course #950224 is required before repair service can be attempted. Complete the course and the assessment #950224B before attempting repair or warranty claim may be denied. The course can be found on the Audi Academy CRC site. © 2016 Audi of America, Inc. Page 2 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Tip: Use caution when lifting or lowering intermediate housing to avoid damage to components (Figure 2). Figure 2. Caution points: drip tray and sensor module connector. Warranty Claim Type: Use applicable claim type. If vehicle is outside any warranty, this Technical Service Bulletin is informational only. Service Number: 3512 Damage Code: 0012 Labor Operations: Remove and install gearbox 3435 19XX See Elsa Replaced sensor module G676 3512 1950 570 TU GFF to perform basic setting and adaptation after replacing sensor 0150 0000 Time stated on diagnostic protocol Diagnostic Time: (Max 100 TU) Road test prior to service procedure No allowance 0 TU Road test after service procedure 0121 0004 10 TU Technical diagnosis at dealer’s discretion (Refer to Section 2.2.1.2 and Audi Warranty Online for DADP allowance details) Claim Comment: As per TSB 2032211/3 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. © 2016 Audi of America, Inc. Page 3 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Required Parts and Tools Part Number Part Description Quantity 0B5321371E Gasket for transmission pan 1 N10405702 Bolts for mechatronics unit 6 G052513A2 Front final drive oil (MTF) 5.0 Liters G052529A2 Dual clutch gearbox oil (ATF) 7.5 Liters 0B5927321L Module 1 0B5321391A Harness 1 AMV18800102 Sealing paste 1 0B5301515H Pump with seals 1 WHT001955 Bolt 1 WHT002459 Bolt 28 WHT001958B Bolt 2 0B5301227C Seal kit 1 0B5323525B O-ring 1 0B5311113F Seal 1 0B5315105TC Oil pipe with seals 1 0B5315105TA Oil pipe with seals 1 0B5325571 Sleeve with seals 1 0B5311944B Seal 4 0B5321473 Oil pipe 1 WHT005379 Seal 1 WHT003379 Seal 1 0B5301311E Oil drip tray (Replace if broken) 1 © 2016 Audi of America, Inc. Page 4 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Additional Information All parts and service references provided in this TSB (2032211) are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information. © 2016 Audi of America, Inc. Page 5 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.