TSBENG161R1

GROUP
ENG
MODEL
2016MY
Multiple Models
(see table on Page 12)
NUMBER
161 (Rev 1, 09/xx/2017)
DATE
November 2016
TECHNICAL SERVICE BULLETIN
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS
DATA FROM ECU (DC16)
 NOTICE
This bulletin has been revised to include additional information. New/revised
sections of this bulletin are indicated by a black bar in the margin area.
This bulletin provides information related to extracting “in use performance tracking”
emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California.
The California Air Resources Board (CARB) requires the emissions data from vehicles with
a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate
collection of this data at the dealer level, KDS screenshots will allow the capture of
relevant parameters.
 NOTICE
If the vehicle meets the criteria below, California dealers must perform this data
collection on vehicles whenever an affected vehicle is in the shop for any
maintenance or repair.
This data collection does not apply to vehicles or dealers operating outside of
California.
As sufficient data is collected, individual line items per model may be closed
without updates to the TSB. Once a line item is closed on DCS, no further data
collection is required. Data collections initiated after a line item is closed are
subject to chargeback.
File Under: 
Circulate To:
☒General Manager
☒Service Advisors
☒Technicians
☒Service Manager
☒ Parts Manager
☒Body Shop Manager
☐Fleet Repair
Page 2 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
For vehicles listed on DCS as requiring this procedure, follow the instructions in this
bulletin after confirming that the following criteria are met:
 WebDCS shows this as an open Data Collection code DC16XXXX ( depending
on model; see table on page 18) for the vehicle.
 Vehicle has more than 3,000 accumulated miles on its odometer.
 Vehicle repair history does not show battery replacement/disconnection/reset or an
ECU update done in the last 3,000 miles, because IUMPR (In Use Monitor
Performance Ratio) data would have been cleared by such an event.
 Vehicle does not have the check engine light on.
 NOTICE
If a vehicle meets the above criteria, collect data prior to any other campaign or
repair-related activities.
KDS Service Procedure:
 NOTICE
The KDS tablet MUST have a SD Card installed for this procedure.
1.
Open the engine compartment and
locate the Vehicle Emission Control
Information label.
Write down the “Group” number for
later entry into the form.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 3 of 13
SUBJECT:
2.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
With the ignition key on, insert the VCI
II into the DLC and swipe down on the
Vehicle Selection area to identify the
vehicle.
 NOTICE
Screens shown in this bulletin
are for demonstration ONLY
purposes
and
will
vary
depending on the vehicle.
3.
Click AUTO VIN, and then click OK.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 4 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
4.
From the KDS Home Screen, click
OBD-II.
5.
Click In USE Performance Ratio >
Gasoline.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 5 of 13
SUBJECT:
6.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
Click the Screen Capture button to
save a screenshot of the data.
 NOTICE
DO NOT use the Home/Power
button for the screen capture.
If the data list is longer than one (1)
page, scroll down and take another
screen capture.
 NOTICE
A SD Card must be inserted into
the KDS tablet to save KDS
images.
7.
8.
Click Save to save the image.
The KDS will set up a destination
folder and file name to save the
screenshot.
Change the file name to include the
model/engine, the last 6 digits of the
VIN, and the date (mmddyyyy), as
shown below.
Example:
XM33L_576681_06092015
(Model
(mmddyyyy)
&
Eng.)
(VIN)
Click Save.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 6 of 13
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
SUBJECT:
9.
Click the Return Arrow on the screen,
and then click the HOME button to
return to the KDS Home Screen.
10.
Set Chrome as the default browser,
then proceed to step 11.
If not, refer to the following Article in
KGIS: “KDS-Configuring Browser for
Techline and Feedback Cases” for
more information.
11.
Once Chrome is set as the default
browser, navigate to the KDS Home
Screen and then click Feedback.
12.
Enter all the information requested
in the form, including your name
and email address, and the
following information:
•
•
For System, enter Engine
For Subject, enter Data
Collection
• In the Description area,
○ Enter Group: followed by
the group number from the
Vehicle Emission Control
Information Label collected
in page 2, step 1.
○ Enter the current odometer
mileage.
○ Enter the RO#.
 NOTICE
Make sure the email address is
entered
correctly
or
the
Feedback form will fail to
submit.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 7 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
13.
Click one of the Choose File buttons
at the bottom of the screen.
14.
Click Documents
15A. (Steps 15A and 15B apply to the
Samsung Tab 10.1 (older tablet))
Click the Settings button in the upper
right hand corner.
15B. Verify an SD Card is displayed in the
left pane as a number (e.g., 1899C039).
If not, click Show SD card.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 8 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
16A. (Steps 16A and 16B apply to the
Samsung Tab S2 image (newer tablet)).
Click the Recent button.
16B. This will provide access to the SD
Card.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 9 of 13
SUBJECT:
17.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
Access to Internal and External
Memory (i.e., SD Card) is available on
the left hand side of the file manager.
External / SD Card
 NOTICE
Always select the SD Card to
save the images from this data
collection procedure. DO NOT
select internal storage.
Internal
18.
With the External/SD Card selected,
click Android.
19.
Click data.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 10 of 13
SUBJECT:
20.
Scroll
down
gitauto.GDSM.
21.
Click files.
22.
Click mvcidata.
23.
Click Record.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
and
then
click
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 11 of 13
SUBJECT:
24.
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
Click the vehicle model (e.g., Sorento
(XMa)).
Sorento (XMa)
June 15
25.
Click the VIN.
5XYKWDA7XEG437824
June 15
26.
Click the screenshot.
5XYKWDA7XEG437824
XM33L_576681_06092015
June 15
27.
1.21MB
Click Submit.
 NOTICE
Ensure that you attach the
correct
files.
Incorrect
attachments
render
data
submissions useless and are
subject to chargeback of the
warranty claim.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 12 of 13
SUBJECT:
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
AFFECTED PRODUCT RANGE:
Model
Cadenza 3.3L ULEV, Forte 1.6L ULEV, Forte 1.8L SULEV,
Forte 1.8L ULEV, Forte 2.0L SULEV, Forte 2.0L ULEV, K900
3.8L ULEV, K900 5.0L ULEV, Optima 1.6L ULEV, Optima 2.0
L ULEV, Optima 2.4L SULEV, Optima 2.4L ULEV, Optima
HEV 2.4L SULEV, Rio 1.6L ULEV, Sedona 3.3L ULEV,
Sorento 2.0L ULEV, Sorento 2.4L ULEV, Sorento 3.3L ULEV
, Soul 1.6L ULEV, Soul 2.0L ULEV, Sportage 2.0L ULEV,
Sportage 2.4L SULEV, and Sportage 2.4L ULEV
Production Date Range
2016MY
(Sold in California
only)
2016MY DATA COLLECTION WARRANTY CLAIM INFORMATION:
 NOTICE
As sufficient data is collected, individual line items per model may be closed without
updates to the TSB. Once a line item is closed on DCS, no further data collection is
required. Data collections initiated after a line item is closed are subject to
chargeback.
TSB: ENG 161 (Rev 1) Multiple Models November 2016
Page 13 of 13
SUBJECT:
Campaign
ID
DATA COLLECTION: EXTRACT CALIFORNIA
EMISSIONS DATA FROM ECU (DC16)
Claim
Type
Causal
P/N
Qty
N
Code
C
Code
Repair
Description
C99
CADENZA
3.3 ULEV
FORTE 1.6 ULEV
FORTE
1.8 SULEV
FORTE 1.8 ULEV
FORTE
2.0 SULEV
FORTE 2.0 ULEV
K900 3.8 ULEV
K900 5.0 ULEV
OPTIMA
1.6 ULEV
OPTIMA
2.0 ULEV
OPTIMA
2.4 SULEV
OPTIMA
2.4 ULEV
OPTIMA
HEV 2.4 SULEV
RIO 1.6 ULEV
SEDONA
3.3 ULEV
SORENTO
2.0 ULEV
SORENTO
2.4 ULEV
SORENTO
3.3 ULEV
SOUL 1.6 ULEV
SOUL 2.0 ULEV
SPORTAGE
2.0 ULEV
SPORTAGE
2.4 SULEV
SPORTAGE
2.4 ULEV
DC16VG1
DC16YD1
DC16YD2
DC16YD3
DC16YD4
DC16YD5
DC16KH1
DC16KH2
DC16JF1
DC16JF2
DC16JF3
DC16JF4
DC16TFH1
DC16UB1
DC16YP1
DC16UM1
DC16UM2
DC16UM3
DC16PS1
DC16PS2
DC16SL1
DC16SL2
DC16SL3
V
100CA
EM999
0
N99
Labor Op
Code
Time
Replacement
P/N
0.3
M/H
N/A
Qty
16VG33U1
16YD16U1
16YD18S1
16YD18U1
16YD20S1
16YD20U1
16KH38U1
16KH50U1
16JF16U1
16JF20U1
16JF24S1
16JF24U1
16TFH24S
0
16UB16U1
16YP33U1
16UM20U1
16UM24U1
16UM33U1
16PS16U1
16PS20U1
16SL20U1
16SL24S1
16SL24U1
TSB: ENG 161 (Rev 1) Multiple Models November 2016