V871505 2040811
Service Bulletin Details
Public Details for: V871505 2040811
Technical bulletin (vibration or rattling noise from front end or dash panel while driving): the refrigerant line from the compressor to the condenser of the heat pump has a contact point to the brake line in the area of the plenum chamber
- 2015 -
Models from 2015
2015 VOLKSWAGEN E-GOLF |
Technical Bulletin Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To E-Golf 2015 All All AU_FW900001 AU_FW910277 Condition 87 15 05 June 3, 2015 2040811 Vibration or Rattling Noise from Front End or Dash Panel while Driving (PR No.: 9M3) Customer states: • Vibration/rattling noises from front end/dash panel after on acceleration • Vibration/rattling noises from front end/dash panel with AC during idle. • Vibration/rattling noises from front end/dash panel while driving. Technical Background The refrigerant line from the compressor to the condenser of the heat pump has a contact point to the brake line in the area of the plenum chamber partition panel (Figure 1, red ellipse). As a result, the working noise of the air conditioning compressor is transmitted into the vehicle interior. Page 1 of 5 © 2015 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Figure 1 (contact point of refrigerant line to brake line) Production Solution Introduction of vibration damper in production VIN AU_FW910278. Page 2 of 5 © 2015 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Service Install vibration damper on brake line • Install the vibration damper (part number 03L 130 118) on the lower brake line in the area of the contact point to the refrigerant line (Figure 2, red arrow). Figure 2 (example of brake line with vibration damper installed) Page 3 of 5 © 2015 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Warranty To determine if this procedure is covered under Warranty, always refer to the Warranty Policies and 1) Procedures Manual Model(s) Year(s) Eng. Code(s) Trans. Code(s) VIN Range From VIN Range To E-Golf 2015 All All AU_FW900001 AU_FW910277 SAGA Coding Claim Type: Use applicable Claim Type 1) Damage Service Number: HST Damage Location (Depends on Service No.) -- Use applicable when indicated in Elsa(L/R) Code 8743 0010 Parts Manufacturer E-Golf Original Part Number: WWO 2) 5GE907044S 3) Labor Operation : Install Vibration Damper 87432399 = 10TU Causal Part: Select Labor Operation 87432399 Diagnostic Time GFF Time expenditure 01500000 = 00 TU max. Road Test 01210002 = 00 TU 4) NO NO 01210004 = 00 TU Technical Diagnosis 01320000 = 00 TU max. NO Claim Comment: Input “As per Technical Bulletin 2040811” in comment section of Warranty Claim. 1) Vehicle may be outside any Warranty in which case this Technical Bulletin is informational only 2) Code per warranty vendor code policy. 3) Labor Time Units (TUs) are subject to change with ELSA updates. 4) Documentation required per Warranty Policies and Procedures Manual. Page 4 of 5 © 2015 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Bulletin Required Parts and Tools Part No: Part Description Quantity 03L 130 118 Vibration Damper 1 No Special Tools required. Additional Information All part and service references provided in this Technical Bulletin are subject to change and/or removal. Always check with your Parts Dept. and Repair Manuals for the latest information. Page 5 of 5 © 2015 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.