T-SB-0010-15

T-SB-0010-15
March 6, 2015
Brake Warning Light Illuminated and/or DTC C1441
Service
Category
Vehicle Interior
Section
Meter/Gauge/Display
Market
USA
Applicability
YEAR(S)
MODEL(S)
ADDITIONAL INFORMATION
2015
Camry
Body Type(s): 4Dr. Sedan
Drive Type(s): 2WD
Engine(s): 2AR
Transmission(s): 6AT
VDS(s): BF1FK
Introduction
Some 2015 model year Camry vehicles equipped with the 2AR-FE engine may exhibit an intermittent
service brake warning light “ON” condition and stored Diagnostic Trouble Code (DTC) C1441.
Customers may also notice the light will illuminate as the vehicle is being started, and some
customers may notice a noise or feeling similar to the ABS activating during normal braking.
The Brake Booster has been updated to address this condition.
Production Change Information
This bulletin applies to vehicles produced BEFORE the Production Change Effective VINs
shown below.
MODEL
Camry
PLANT
ENGINE
2AR-FE
TMMK
PRODUCTION CHANGE EFFECTIVE VIN
Line 1
4T1BF1FK#FU028652
Line 2
4T1BF1FK#FU921374
SIA
4T4BF1FK#FR475697
Warranty Information
OP CODE
DESCRIPTION
TIME
OFP
T1
T2
BR1500
R & R Brake Booster Assembly
2.5
44610-06472
8C
50
APPLICABLE WARRANTY
• This repair is covered under the Toyota Basic Warranty. This warranty is in effect for 36 months
or 36,000 miles, whichever occurs first, from the vehicle’s in-service date.
• Warranty application is limited to occurrence of the specified condition described in
this bulletin.
© 2015 Toyota Motor Sales, USA
Page 1 of 3
March 6, 2015
T-SB-0010-15
Page 2 of 3
Brake Warning Light Illuminated and/or DTC C1441
Parts Information
PART NUMBER
PREVIOUS
NEW
44610-06472
44610-06760
PART NAME
QTY
Booster Assy, Brake
1
Required Tools & Equipment
REQUIRED EQUIPMENT
Techstream 2.0*
Techstream Lite
SUPPLIER
ADE
PART NUMBER
QTY
TS2UNIT
TSLITEPDLR01
* Essential SST.
NOTE
• Only ONE of the Techstream units listed above is required.
• Software version 10.00.029 or later is required.
• Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at
1-800-368-6787.
Repair Procedure
1. Confirm that the customer has noticed a brake warning light illuminated, or a “Check Brake
System” message from the multi-information display, and that DTC C1441 is stored in either
current or history DTCs.
Figure 1. Condition 1: Brake Warning Light
© 2015 Toyota Motor Sales, USA
Figure 2. Condition 2:
Multi-Information Display
1
March 6, 2015
T-SB-0010-15
Page 3 of 3
Brake Warning Light Illuminated and/or DTC C1441
Repair Procedure (Continued)
Has the customer noticed one or both conditions above?
• YES — Continue to step 2.
• NO — This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual.
2. Confirm the proper brake fluid level and proper operation of the braking system and parking
brake system.
Refer to the Technical Information System (TIS), applicable model and model year
Repair Manual:
• 2015 Camry:
Brake – Brake System – “Brake System (Other): Brake Fluid: On-vehicle Inspection”
• 2015 Camry:
Brake – Brake System – “Brake System (Other): Brake Booster: On-vehicle Inspection”
• 2015 Camry:
Brake – Parking Brake – “Parking Brake: Parking Brake Switch: Inspection”
Are the above systems operating normally?
• YES — Replace the Brake Vacuum Booster Assembly with the updated part.
Refer to TIS, applicable model and model year Repair Manual:
• 2015 Camry:
Brake – Brake System – “Brake System (Other): Brake Booster: Removal / Installation”
• NO — This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual.
3. Test drive the vehicle confirming that the brake system is operating normally, and that the
BRAKE warning indicator light is NOT illuminated.
© 2015 Toyota Motor Sales, USA